ETC TP339UG

THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
▓ Features
The thermopile sensor consists of a series of 116 thermoelements, forming a sensitive region
size of 900*900μm2 .The sensor is hermetically sealed into a TO-18 metal housing, with an optical
filter. This standard filter allows measurements to be made in the spectral range above 5μm
wavelength. The thermosensor exhibits an almost white noise, comparable to an ohmic resistance.
It has a constant signal versus frequency up to its frequency limit, and is directly proportional to
incident radiation. The thermopile sensors are featured with an additional temperature reference
resistor on the same chip. The standard version of temperature reference resistor is housing
connected to ground.
▓ Applications
* Ear thermometers; clinic thermometers
* Infrared thermometers
* Consumer applications: hair dryer, micro-wave oven, air conditioner, refrigerator
* Continuous temperature control of manufacturing
* Security system
* Radiation monitor switch system
* Absorbing measurement for gas analysis
* Thermoelectric converter
* Heat flux flowmeter
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
1 / 16
THERMOPILE
Part No:
80-01-00008
Type:
TP339UG
▓ Electrical Characteristics
Parameter
Condition
Min.
Typ.
Max.
Unit
630
900
1170
uV
Number of thermojunctions
---
116
---
Chip size
---
1740*1740
---
μm2
---
900*900
---
μm
Thermopile
Tambient=25C
Output Voltage
Tblack-body=37C
Active region size
High efficiency
absorber layer
Thickness of substrate
Silicon-substrate
600
625
650
μm
Resistance of thermopile
25℃
50
60
80
KΩ
45
V/W
Temperature Coefficient of
Thermopile Resistance
o
<0.1 %/ C
With 5-14μm
filter
*Sensitivity *
30
37
8
Detecctivity
8
8
1/2
0.8*10
1.1*10
1.3*10
cm*Hz /W
Time constant
---
20
---
ms
Noise voltage
28
32
36
nV/Hz
0.71
0.86
1.07
nW/Hz
NEP
1/2
1/2
Cut on
5+/-0.5um
Filter Range
Incident Angle to
achieve 10%
responsivity
Field of View
72
Degree
-7
Sealing
<1*10
Temperature range
Operation
-20
---
Atm*cc/sec
100
℃
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
2 / 16
THERMOPILE
Part No:
80-01-00008
Type:
TP339UG
Temperature reference resistor
Resistance
25℃
97
100
103
KΩ
β value
25 C/100℃
o
3944
3964
3984
K
* Measured at 1 Hz chopper frequency, within spectral range 5-14μm, using a blackbody radiator
of 500K temperature.
Note : Thermistor should be operated under 1mA.
▓ Frequency response
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
3 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
▓ Thermopile voltage(uV) vs. blackbody & ambient temperature(C)
Ta \ Tb
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
32
1643
1590
1537
1484
1429
1374
1319
1262
1205
1148
1090
1031
971
911
850
789
726
664
600
536
471
406
340
273
205
137
69
0
-71
-141
-213
-285
-357
-431
-505
-579
33
1713
1660
1607
1554
1499
1444
1389
1332
1276
1218
1160
1101
1041
981
920
859
797
734
670
606
541
476
410
343
276
207
139
69
0
-71
-143
-215
-287
-361
-435
-509
34
1783
1731
1678
1624
1570
1515
1460
1403
1346
1289
1230
1172
1112
1052
991
929
867
804
741
677
612
547
480
414
346
278
209
140
70
0
-72
-144
-217
-290
-364
-439
35
1855
1802
1749
1696
1642
1587
1531
1475
1418
1360
1302
1243
1183
1123
1062
1001
939
876
812
748
683
618
552
485
418
350
281
212
142
71
0
-73
-145
-219
-292
-367
36
1927
1875
1822
1768
1714
1659
1603
1547
1490
1432
1374
1315
1256
1195
1135
1073
1011
948
885
820
756
690
624
557
490
422
353
284
214
143
72
0
-73
-146
-220
-295
37
2000
1947
1894
1841
1786
1731
1676
1620
1563
1505
1447
1388
1328
1268
1207
1146
1084
1021
957
893
828
763
697
630
563
495
426
356
286
216
144
72
0
-74
-148
-222
38
2073
2021
1968
1914
1860
1805
1749
1693
1636
1579
1520
1461
1402
1342
1281
1219
1157
1094
1031
967
902
836
770
704
636
568
499
430
360
289
218
146
73
0
-74
-149
39
2147
2095
2042
1988
1934
1879
1824
1767
1710
1653
1595
1536
1476
1416
1355
1293
1231
1168
1105
1041
976
911
845
778
710
642
574
504
434
363
292
220
147
74
0
-75
40
2222
2170
2117
2063
2009
1954
1898
1842
1785
1728
1669
1610
1551
1491
1430
1368
1306
1243
1180
1116
1051
985
919
853
785
717
648
579
509
438
367
295
222
149
75
0
41
2298
2245
2192
2139
2085
2030
1974
1918
1861
1803
1745
1686
1626
1566
1505
1444
1382
1319
1255
1191
1126
1061
995
928
861
793
724
655
585
514
442
370
298
224
151
76
42
2374
2322
2269
2215
2161
2106
2050
1994
1937
1879
1821
1762
1703
1642
1582
1520
1458
1395
1332
1267
1203
1137
1071
1004
937
869
800
731
661
590
519
447
374
301
227
152
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
4 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
▓ Thermistor vs. temperature
The resistance of the temperature reference resistor varies with temperature and the behaviour
is illustrated in the following table.
Ta(C)
-40
-35
-30
-25
-20
-15
-10
-5
0
5
10
15
20
25
30
35
40
45
50
55
60
min(k-ohms)
2958
2157
1590
1183
888.9
673.8
515.1
397.1
308.4
241.4
190.3
151.0
120.7
97.0
78.29
63.56
51.89
42.60
35.15
29.16
24.30
Typical(k-ohms)
3106
2262
1664
1236
927.3
701.9
535.8
412.4
319.9
250.1
196.9
156.1
124.5
100.0
80.80
65.66
53.67
44.10
36.43
30.24
25.23
Max(k-ohms)
3259
2369
1740
1291
966.5
730.4
556.8
427.9
331.5
258.8
203.5
161.1
128.4
103.0
83.31
67.78
55.45
45.61
37.71
31.34
26.17
1 1 
 −

T25 
βT
describes the resistance vs. temperature, where R25 is
At temperature 25℃, R(T)=R25e
the resistance at ambient temperature 25℃ and T, T25 are the ambient temperatures in unit of kelvin
degrees.
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
5 / 16
THERMOPILE
Part No:
Type:
Temp.(C) min.(KΩ) typical(KΩ)
0.0
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1.0
1.1
1.2
1.3
1.4
1.5
1.6
1.7
1.8
1.9
2.0
2.1
2.2
2.3
2.4
2.5
2.6
2.7
2.8
2.9
3.0
3.1
3.2
3.3
3.4
3.5
3.6
3.7
3.8
3.9
4.0
308.4
306.9
305.4
303.9
302.4
300.9
299.4
297.9
296.4
295.0
293.5
292.1
290.6
289.2
287.8
286.4
285.0
283.6
282.2
280.8
279.4
278.0
276.7
275.3
274.0
272.6
271.3
270.0
268.6
267.3
266.0
264.7
263.4
262.2
260.9
259.6
258.4
257.1
255.9
254.6
253.4
319.9
318.3
316.7
315.2
313.6
312.0
310.5
308.9
307.4
305.9
304.4
302.9
301.4
299.9
298.4
296.9
295.4
294.0
292.5
291.1
289.6
288.2
286.8
285.4
284.0
282.6
281.2
279.8
278.4
277.1
275.7
274.4
273.0
271.7
270.4
269.0
267.7
266.4
265.1
263.8
262.5
max.(KΩ)
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
331.5
329.9
328.2
326.6
324.9
323.3
321.7
320.1
318.5
316.9
315.3
313.8
312.2
310.6
309.1
307.6
306.0
304.5
303.0
301.5
300.0
298.5
297.0
295.6
294.1
292.6
291.2
289.8
288.3
286.9
285.5
284.1
282.7
281.3
279.9
278.5
277.2
275.8
274.5
273.1
271.8
4.1
4.2
4.3
4.4
4.5
4.6
4.7
4.8
4.9
5.0
5.1
5.2
5.3
5.4
5.5
5.6
5.7
5.8
5.9
6.0
6.1
6.2
6.3
6.4
6.5
6.6
6.7
6.8
6.9
7.0
7.1
7.2
7.3
7.4
7.5
7.6
7.7
7.8
7.9
8.0
8.1
252.2
250.9
249.7
248.5
247.3
246.1
244.9
243.7
242.6
241.4
240.2
239.1
237.9
236.8
235.6
234.5
233.4
232.3
231.2
230.1
229.0
227.9
226.8
225.7
224.6
223.5
222.5
221.4
220.3
219.3
218.3
217.2
216.2
215.2
214.1
213.1
212.1
211.1
210.1
209.1
208.1
261.3
260.0
258.7
257.5
256.2
255.0
253.7
252.5
251.3
250.1
248.8
247.6
246.4
245.3
244.1
242.9
241.7
240.6
239.4
238.2
237.1
236.0
234.8
233.7
232.6
231.5
230.3
229.2
228.1
227.0
226.0
224.9
223.8
222.7
221.7
220.6
219.6
218.5
217.5
216.4
215.4
270.4
269.1
267.8
266.5
265.2
263.9
262.6
261.3
260.1
258.8
257.5
256.3
255.0
253.8
252.6
251.3
250.1
248.9
247.7
246.5
245.3
244.1
242.9
241.8
240.6
239.4
238.3
237.1
236.0
234.9
233.7
232.6
231.5
230.4
229.3
228.2
227.1
226.0
224.9
223.8
222.8
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
6 / 16
THERMOPILE
Part No:
Type:
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
8.2
8.3
8.4
8.5
8.6
8.7
8.8
8.9
9.0
9.1
9.2
9.3
9.4
9.5
9.6
9.7
9.8
9.9
10.0
10.1
10.2
10.3
10.4
10.5
10.6
10.7
10.8
10.9
11.0
11.1
11.2
11.3
11.4
11.5
11.6
11.7
11.8
11.9
12.0
12.1
12.2
207.1
206.2
205.2
204.2
203.2
202.3
201.3
200.4
199.4
198.5
197.6
196.6
195.7
194.8
193.9
193.0
192.1
191.2
190.3
189.4
188.5
187.6
186.8
185.9
185.0
184.2
183.3
182.4
181.6
180.7
179.9
179.1
178.2
177.4
176.6
175.8
175.0
174.1
173.3
172.5
171.7
214.4
213.4
212.4
211.4
210.3
209.4
208.4
207.4
206.4
205.4
204.4
203.5
202.5
201.6
200.6
199.7
198.7
197.8
196.9
195.9
195.0
194.1
193.2
192.3
191.4
190.5
189.6
188.7
187.8
186.9
186.1
185.2
184.3
183.5
182.6
181.8
180.9
180.1
179.2
178.4
177.6
221.7
220.6
219.6
218.5
217.5
216.5
215.4
214.4
213.4
212.4
211.4
210.4
209.4
208.4
207.4
206.4
205.4
204.4
203.5
202.5
201.6
200.6
199.7
198.7
197.8
196.9
195.9
195.0
194.1
193.2
192.3
191.4
190.5
189.6
188.7
187.8
186.9
186.1
185.2
184.3
183.5
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
12.3
12.4
12.5
12.6
12.7
12.8
12.9
13.0
13.1
13.2
13.3
13.4
13.5
13.6
13.7
13.8
13.9
14.0
14.1
14.2
14.3
14.4
14.5
14.6
14.7
14.8
14.9
15.0
15.1
15.2
15.3
15.4
15.5
15.6
15.7
15.8
15.9
16.0
16.1
16.2
16.3
171.0
170.2
169.4
168.6
167.8
167.0
166.3
165.5
164.8
164.0
163.2
162.5
161.8
161.0
160.3
159.5
158.8
158.1
157.4
156.6
155.9
155.2
154.5
153.8
153.1
152.4
151.7
151.0
150.3
149.7
149.0
148.3
147.6
147.0
146.3
145.6
145.0
144.3
143.7
143.0
142.4
176.8
175.9
175.1
174.3
173.5
172.7
171.9
171.1
170.3
169.5
168.8
168.0
167.2
166.4
165.7
164.9
164.1
163.4
162.6
161.9
161.1
160.4
159.7
158.9
158.2
157.5
156.8
156.1
155.3
154.6
153.9
153.2
152.5
151.8
151.1
150.5
149.8
149.1
148.4
147.7
147.1
182.6
181.8
180.9
180.1
179.2
178.4
177.6
176.7
175.9
175.1
174.3
173.5
172.7
171.9
171.1
170.3
169.5
168.7
167.9
167.2
166.4
165.6
164.9
164.1
163.3
162.6
161.8
161.1
160.4
159.6
158.9
158.2
157.4
156.7
156.0
155.3
154.6
153.9
153.2
152.5
151.8
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
7 / 16
THERMOPILE
Part No:
80-01-00008
Type:
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
16.4
16.5
16.6
16.7
16.8
16.9
17.0
17.1
17.2
17.3
17.4
17.5
17.6
17.7
17.8
17.9
18.0
18.1
18.2
18.3
18.4
18.5
18.6
18.7
18.8
18.9
19.0
19.1
19.2
19.3
19.4
19.5
19.6
19.7
19.8
19.9
20.0
20.1
20.2
20.3
20.4
141.7
141.1
140.5
139.8
139.2
138.6
137.9
137.3
136.7
136.1
135.5
134.9
134.3
133.7
133.1
132.5
131.9
131.3
130.7
130.1
129.5
129.0
128.4
127.8
127.3
126.7
126.1
125.6
125.0
124.5
123.9
123.4
122.8
122.3
121.7
121.2
120.7
120.1
119.6
119.1
118.5
146.4
145.7
145.1
144.4
143.8
143.1
142.5
141.8
141.2
140.6
139.9
139.3
138.7
138.0
137.4
136.8
136.2
135.6
135.0
134.4
133.8
133.2
132.6
132.0
131.4
130.8
130.2
129.6
129.0
128.5
127.9
127.3
126.8
126.2
125.6
125.1
124.5
124.0
123.4
122.9
122.3
151.1
150.4
149.7
149.0
148.4
147.7
147.0
146.3
145.7
145.0
144.4
143.7
143.1
142.4
141.8
141.1
140.5
139.9
139.2
138.6
138.0
137.4
136.7
136.1
135.5
134.9
134.3
133.7
133.1
132.5
131.9
131.3
130.7
130.1
129.6
129.0
128.4
127.8
127.3
126.7
126.1
Temp.(C) min.(KΩ) typical(KΩ)
20.5
20.6
20.7
20.8
20.9
21.0
21.1
21.2
21.3
21.4
21.5
21.6
21.7
21.8
21.9
22.0
22.1
22.2
22.3
22.4
22.5
22.6
22.7
22.8
22.9
23.0
23.1
23.2
23.3
23.4
23.5
23.6
23.7
23.8
23.9
24.0
24.1
24.2
24.3
24.4
24.5
118.0
117.5
117.0
116.5
116.0
115.4
114.9
114.4
113.9
113.4
112.9
112.4
111.9
111.5
111.0
110.5
110.0
109.5
109.0
108.6
108.1
107.6
107.2
106.7
106.2
105.8
105.3
104.9
104.4
103.9
103.5
103.0
102.6
102.2
101.7
101.3
100.8
100.4
100.0
99.54
99.11
121.8
121.3
120.7
120.2
119.6
119.1
118.6
118.1
117.6
117.0
116.5
116.0
115.5
115.0
114.5
114.0
113.5
113.0
112.5
112.0
111.5
111.0
110.5
110.0
109.6
109.1
108.6
108.1
107.7
107.2
106.7
106.3
105.8
105.3
104.9
104.4
104.0
103.5
103.1
102.6
102.2
TP339UG
max.(KΩ)
125.6
125.0
124.5
123.9
123.4
122.8
122.3
121.7
121.2
120.6
120.1
119.6
119.0
118.5
118.0
117.5
117.0
116.4
115.9
115.4
114.9
114.4
113.9
113.4
112.9
112.4
111.9
111.4
110.9
110.5
110.0
109.5
109.0
108.5
108.1
107.6
107.1
106.7
106.2
105.7
105.3
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
8 / 16
THERMOPILE
Part No:
Type:
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
24.6
24.7
24.8
24.9
25.0
25.1
25.2
25.3
25.4
25.5
25.6
25.7
25.8
25.9
26.0
26.1
26.2
26.3
26.4
26.5
26.6
26.7
26.8
26.9
27.0
27.1
27.2
27.3
27.4
27.5
27.6
27.7
27.8
27.9
28.0
28.1
28.2
28.3
28.4
28.5
28.6
98.69
98.26
97.84
97.42
97.00
96.58
96.16
95.74
95.33
94.92
94.51
94.10
93.69
93.29
92.88
92.48
92.09
91.69
91.29
90.90
90.51
90.12
89.73
89.35
88.97
88.58
88.20
87.83
87.45
87.08
86.70
86.33
85.97
85.60
85.23
84.87
84.51
84.15
83.79
83.43
83.08
101.7
101.3
100.9
100.4
100.0
99.57
99.14
98.71
98.29
97.86
97.44
97.02
96.61
96.19
95.78
95.37
94.96
94.55
94.15
93.74
93.34
92.94
92.55
92.15
91.76
91.37
90.98
90.59
90.20
89.82
89.44
89.06
88.68
88.30
87.93
87.55
87.18
86.81
86.45
86.08
85.72
104.8
104.4
103.9
103.4
103.0
102.6
102.1
101.7
101.2
100.8
100.4
99.95
99.52
99.10
98.67
98.25
97.83
97.42
97.00
96.59
96.18
95.77
95.36
94.96
94.55
94.15
93.75
93.35
92.96
92.57
92.17
91.78
91.40
91.01
90.62
90.24
89.86
89.48
89.11
88.73
88.36
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
28.7
28.8
28.9
29.0
29.1
29.2
29.3
29.4
29.5
29.6
29.7
29.8
29.9
30.0
30.1
30.2
30.3
30.4
30.5
30.6
30.7
30.8
30.9
31.0
31.1
31.2
31.3
31.4
31.5
31.6
31.7
31.8
31.9
32.0
32.1
32.2
32.3
32.4
32.5
32.6
32.7
82.73
82.37
82.02
81.68
81.33
80.98
80.64
80.30
79.96
79.62
79.29
78.95
78.62
78.29
77.96
77.63
77.30
76.98
76.65
76.33
76.01
75.69
75.37
75.05
74.74
74.43
74.11
73.80
73.50
73.19
72.88
72.58
72.28
71.97
71.67
71.37
71.08
70.78
70.49
70.19
69.90
85.35
84.99
84.63
84.28
83.92
83.57
83.21
82.86
82.52
82.17
81.82
81.48
81.14
80.80
80.46
80.12
79.78
79.45
79.12
78.79
78.46
78.13
77.80
77.48
77.15
76.83
76.51
76.19
75.88
75.56
75.25
74.93
74.62
74.31
74.00
73.70
73.39
73.09
72.79
72.48
72.18
87.99
87.62
87.25
86.88
86.52
86.15
85.79
85.43
85.07
84.72
84.36
84.01
83.66
83.31
82.96
82.62
82.27
81.93
81.59
81.25
80.91
80.57
80.24
79.91
79.57
79.24
78.92
78.59
78.26
77.94
77.62
77.30
76.98
76.66
76.34
76.03
75.71
75.40
75.09
74.78
74.47
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
9 / 16
THERMOPILE
Part No:
Type:
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
32.8
32.9
33.0
33.1
33.2
33.3
33.4
33.5
33.6
33.7
33.8
33.9
34.0
34.1
34.2
34.3
34.4
34.5
34.6
34.7
34.8
34.9
35.0
35.1
35.2
35.3
35.4
35.5
35.6
35.7
35.8
35.9
36.0
36.1
36.2
36.3
36.4
36.5
36.6
36.7
36.8
69.61
69.32
69.03
68.75
68.46
68.18
67.90
67.62
67.34
67.06
66.78
66.51
66.23
65.96
65.69
65.42
65.15
64.88
64.61
64.35
64.08
63.82
63.56
63.30
63.04
62.78
62.52
62.26
62.01
61.76
61.50
61.25
61.00
60.75
60.51
60.26
60.01
59.77
59.53
59.28
59.04
71.89
71.59
71.29
71.00
70.71
70.42
70.13
69.84
69.55
69.26
68.98
68.69
68.41
68.13
67.85
67.57
67.30
67.02
66.75
66.47
66.20
65.93
65.66
65.40
65.13
64.86
64.60
64.34
64.07
63.81
63.55
63.30
63.04
62.78
62.53
62.27
62.02
61.77
61.52
61.27
61.02
74.17
73.86
73.56
73.26
72.96
72.66
72.36
72.06
71.77
71.48
71.18
70.89
70.60
70.31
70.03
69.74
69.46
69.17
68.89
68.61
68.33
68.06
67.78
67.50
67.23
66.96
66.69
66.42
66.15
65.88
65.61
65.35
65.08
64.82
64.56
64.30
64.04
63.78
63.52
63.27
63.01
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
36.9
37.0
37.1
37.2
37.3
37.4
37.5
37.6
37.7
37.8
37.9
38.0
38.1
38.2
38.3
38.4
38.5
38.6
38.7
38.8
38.9
39.0
39.1
39.2
39.3
39.4
39.5
39.6
39.7
39.8
39.9
40.0
40.1
40.2
40.3
40.4
40.5
40.6
40.7
40.8
40.9
58.80
58.57
58.33
58.09
57.86
57.62
57.39
57.16
56.92
56.69
56.47
56.24
56.01
55.78
55.56
55.34
55.11
54.89
54.67
54.45
54.23
54.01
53.80
53.58
53.37
53.15
52.94
52.73
52.52
52.31
52.10
51.89
51.68
51.48
51.27
51.07
50.86
50.66
50.46
50.26
50.06
60.78
60.53
60.29
60.04
59.80
59.56
59.32
59.08
58.84
58.61
58.37
58.14
57.90
57.67
57.44
57.21
56.98
56.75
56.53
56.30
56.08
55.85
55.63
55.41
55.19
54.97
54.75
54.53
54.31
54.10
53.88
53.67
53.45
53.24
53.03
52.82
52.61
52.40
52.19
51.99
51.78
62.76
62.51
62.26
62.01
61.76
61.51
61.26
61.02
60.78
60.53
60.29
60.05
59.81
59.57
59.33
59.10
58.86
58.63
58.39
58.16
57.93
57.70
57.47
57.24
57.01
56.79
56.56
56.34
56.12
55.89
55.67
55.45
55.23
55.02
54.80
54.58
54.37
54.15
53.94
53.73
53.52
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
10 / 16
THERMOPILE
Part No:
Type:
Temp.(C) min.(KΩ) typical(KΩ)
41.0
41.1
41.2
41.3
41.4
41.5
41.6
41.7
41.8
41.9
42.0
42.1
42.2
42.3
42.4
42.5
42.6
42.7
42.8
42.9
43.0
43.1
43.2
43.3
43.4
43.5
43.6
43.7
43.8
43.9
44.0
44.1
44.2
44.3
44.4
44.5
44.6
44.7
44.8
44.9
45.0
49.86
49.66
49.47
49.27
49.07
48.88
48.69
48.49
48.30
48.11
47.92
47.73
47.54
47.36
47.17
46.98
46.80
46.61
46.43
46.25
46.07
45.89
45.71
45.53
45.35
45.17
44.99
44.82
44.64
44.47
44.29
44.12
43.95
43.78
43.61
43.44
43.27
43.10
42.93
42.76
42.60
51.58
51.37
51.17
50.97
50.77
50.57
50.37
50.17
49.97
49.78
49.58
49.39
49.19
49.00
48.81
48.62
48.43
48.24
48.05
47.86
47.67
47.49
47.30
47.12
46.93
46.75
46.57
46.39
46.20
46.03
45.85
45.67
45.49
45.31
45.14
44.96
44.79
44.62
44.44
44.27
44.10
max.(KΩ)
53.31
53.10
52.89
52.68
52.47
52.27
52.06
51.86
51.66
51.45
51.25
51.05
50.85
50.65
50.46
50.26
50.06
49.87
49.67
49.48
49.29
49.10
48.91
48.72
48.53
48.34
48.15
47.96
47.78
47.59
47.41
47.23
47.04
46.86
46.68
46.50
46.32
46.14
45.97
45.79
45.61
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
45.1
45.2
45.3
45.4
45.5
45.6
45.7
45.8
45.9
46.0
46.1
46.2
46.3
46.4
46.5
46.6
46.7
46.8
46.9
47.0
47.1
47.2
47.3
47.4
47.5
47.6
47.7
47.8
47.9
48.0
48.1
48.2
48.3
48.4
48.5
48.6
48.7
48.8
48.9
49.0
49.1
42.43
42.27
42.10
41.94
41.78
41.62
41.45
41.29
41.13
40.98
40.82
40.66
40.50
40.35
40.19
40.04
39.88
39.73
39.58
39.42
39.27
39.12
38.97
38.82
38.67
38.52
38.38
38.23
38.08
37.94
37.79
37.65
37.50
37.36
37.22
37.08
36.94
36.79
36.65
36.52
36.38
43.93
43.76
43.59
43.42
43.25
43.09
42.92
42.76
42.59
42.43
42.26
42.10
41.94
41.78
41.62
41.46
41.30
41.14
40.99
40.83
40.67
40.52
40.36
40.21
40.05
39.90
39.75
39.60
39.45
39.30
39.15
39.00
38.85
38.70
38.56
38.41
38.26
38.12
37.98
37.83
37.69
45.44
45.26
45.09
44.92
44.74
44.57
44.40
44.23
44.06
43.89
43.72
43.56
43.39
43.23
43.06
42.90
42.73
42.57
42.41
42.25
42.09
41.93
41.77
41.61
41.45
41.29
41.14
40.98
40.82
40.67
40.52
40.36
40.21
40.06
39.91
39.76
39.61
39.46
39.31
39.16
39.01
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
11 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
Temp.(C) min.(KΩ) typical(KΩ) max.(KΩ)
49.2
49.3
49.4
49.5
49.6
49.7
49.8
49.9
50.0
36.24
36.10
35.96
35.83
35.69
35.56
35.42
35.29
35.15
37.55
37.40
37.26
37.12
36.98
36.84
36.70
36.57
36.43
38.87
38.72
38.57
38.43
38.28
38.14
38.00
37.86
37.71
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
12 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
▓ Field of view
▓ Transmission of filter
Transmission of optical filter is measured by FTIR from 2μm
Cut on wavelength : 5.0 +/-0.5um
Band range and minimum average transmission : 7~14um , 78%
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
13 / 16
THERMOPILE
Part No:
80-01-00008
Type:
TP339UG
Variation of Output Voltage MIL-STD reference
IEC reference
▓ Reliability Test
Items
Conditions
Vibration
15g, 20 min/ cycle,12 cycles/ axis
<+/- 2%
Mechanical Shock
Half-sine, 100g, 6 ms
<+/- 2%
IEC 68-2-27 test Ea
Damp Heat
85℃, 85RH, 504 Hrs
<+/- 2%
IEC 68-2-3 test Ca
-40℃,504Hrs
<+/- 2%
IEC 68-2-1 test Aa
130℃, 1008 Hrs
<+/- 3%
IEC 68-2-2 test Ba
-40℃/85℃, 30 mins dwell,
10 Cycles
1atm,15oC~35oC, 1 years
<+/- 2%
IEC 68-2-14 test Nb
35psig, 30min, (1 x 10-7
atm*cc/sec)
100% No Leakage
Cold
Dry Heat
Thermal Shock
General preservation
Leakage
202F , 204D, B
<+/- 2%
883D , 1014.9 , E
> 5Kg
Lead tension strength
*The thermopile sensor can be damaged by ESD . Please take appropriate precautions of the handing .
▓ Pin assignment & description
Pin assignment:
2(R)
3(V-)
2 : thermistor pin
4 : thermistor pin (GND)
1(V+) 4(GND)
1 : thermopile output pin (+)
3 : thermopile output pin (-)
BACKSIDE VIEW
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
14 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
▓ Package
The sensor is hermetically sealed into a TO-18 metal housing, with optical filter. This standard
filter allows measurements to be made in the spectral range above 5μm wavelength. The
dimensions of header and cap are shown below.
5.55 +/- 0.1
Unit: mm
4.55 +/- 0.1
2.9 +/- 0.05
Chip
Cap
0.47 +/- 0.03
2.87 +/- 0.05
Header
0.50 +/- 0.05
(Side view)
(Top view)
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
15 / 16
THERMOPILE
Part No:
Type:
80-01-00008
TP339UG
(Bottom view)
1.80 +/- 0.15
Unit : mm
1.80+/- 0.15
1.0 +/-0.1
2.54 +/- 0.15
1.0 +/- 0.1
OPTO TECH CORPORATION
Tel: 886-3-5638951
Fax: 886-3-5783696
http://www.opto.com.tw
OPTO TECH
Since 1983
Microelectronics Business Division
2003.01
16 / 16