High Reliability Photologic® Hermetic Sensors OPL800TX, OPL800TXV Features: 100% screened and quality conformance tested to Optek’s High Reliability program Direct TTL/STTL interface Hermetic, lensed TO-18 package Mechanically and spectrally matched to OP235/OP236TX/TXV LEDs Description: The OPL800TX/TXV is a high reliability optoelectronic microcircuit that incorporates a photodiode, linear amplifier and Schmi trigger on a single silicon chip. The device features TTL/STTL compa ble logic level output which can drive up to 8 TTL loads without addi onal interface circuitry. The Photologic® chip is mounted on a standard TO‐18 header with gold plated leads which is herme cally sealed in a lensed gold plated metal can. These devices are mechanically and spectrally matched to the OP235TX/TXV and OP236TX/TXV infrared emi ng diodes. All parts are processed to Optek’s 100 percent screening program pa erned a er Method 5004 of MIL‐STD‐883 and the quality conformance tes ng of Method 5005. Typical characteris c curves are shown on the commercial OPL800 datasheet. Applications: Non-contact reflective object sensor Assembly line automation Machine automation Machine Safety End of travel sensor Door sensor Military and harsh environments (2) (1) (3) Absolute Maximum Ra ngs (TA = 25° C unless otherwise noted) Supply Voltage, VCC (not to exceed 3 sec) +10.0 V Storage Temperature Range ‐55° C to +150°C Opera ng Temperature Range ‐55° C to +125°C Lead Soldering Temperature [1/16 inch (1.6 mm) from case for 5 sec. with soldering iron] 240°C(1) Power Dissipa on 250 mW(2) Dura on of Output Short to VCC or Ground 1.00 sec Irradiance 3 mW/cm2 Notes: 1. RMA flux is recommended. Dura on can be extended to 10 seconds maximum when wave soldering. 2. Derate linearly 2.5 mW/°C above 25°C. 3. Light measurements are made with λ = 935 nm. General Note TT Electronics reserves the right to make changes in product specification without notice or liability. All information is subject to TT Electronics’ own data and is considered accurate at time of going to print. © TT electronics plc OPTEK Technology, Inc. 1645 Wallace Drive, Carrollton, TX 75006|Ph: +1 972 323 2200 www.optekinc.com | www.ttelectronics.com Issue A 11/2016 Page 1 High Reliability Photologic® Hermetic Sensors OPL800TX, OPL800TXV Group A Inspec on‐Electrical Tests (Performed on each inspec on lot a er all devices have been subjected to the 100% processing requirements.) SYMBOL EXAMINATION OR TEST METHOD CONDITIONS N/C LIMIT MIN MAX UNITS Subgroup 1(3) ICCH ICCL VOL VOH Supply Current, High Supply Current, Low Low Level Output Voltage High Level Output Voltage 3005 VCC= 5.5 V, Ee = 1.0 mw/cm2 15.0 mA 3005 2 VCC= 5.5 V, Ee = 0.0 mw/cm 15.0 mA 3007 VCC= 4.5 V, IOL = 12.8 mA, Ee = 0.0 mw/cm2 0.40 V 3006 116/0 VCC= 4.5 V, IOH = ‐800 μA, 1.0 mw/cm2 Ee = 2.4 V 2, IOS Short Circuit Output Current 3011 VCC= 4.5 V, Ee = 1.0 mw/cm Output = Ground 3005 VCC= 5.5 V, Ee = 1.0 mw/cm2 3005 2 ‐20 ‐100 mA 15.0 mA 15.0 mA 0.40 V Subgroup 2(3) TA = +125°C ICCH ICCL Supply Current, High Supply Current, Low VCC= 5.5 V, Ee = 0.0 mw/cm VOL Low Level Output Voltage 3007 VCC= 4.5 V, IOL = 12.8 mA, VOH High Level Output Voltage 3006 VCC= 4.5 V, IOH = ‐800 μA, 116/0 Ee = 2.4 V Subgroup 3(3) TA = ‐55°C ICCH Supply Current, High 3005 VCC= 5.5 V, Ee = 1.0 mw/cm2 ICCL Supply Current, Low 3005 VCC= 5.5 V, Ee = 0.0 mw/cm2 VOL Low Level Output Voltage 3007 VCC= 4.5 V, IOL = 12.8 mA, Ee = 0.0 mw/cm2 VOH High Level Output Voltage 3006 VCC= 4.5 V, IOH = ‐800 μA, 1.0 mw/cm2 15.0 mA 15.0 mA 0.40 V 116/0 Ee = 2.4 V Subgroup 3(3) tr, tf Rise and Fall Time 3004 VCC= 5.0 V, RL = 8TTL loads tPHL Propaga on Delay, Low‐High 3003 VCC= 5.0 V, RL = 8TTL loads tPLH Propaga on Delay, High‐Low 3003 VCC= 5.0 V, RL = 8TTL loads General Note TT Electronics reserves the right to make changes in product specification without notice or liability. All information is subject to TT Electronics’ own data and is considered accurate at time of going to print. © TT electronics plc 116/0 100 ns 10.0 μs 10.0 μs OPTEK Technology, Inc. 1645 Wallace Drive, Carrollton, TX 75006|Ph: +1 972 323 2200 www.optekinc.com | www.ttelectronics.com Issue A 11/2016 Page 2