Qualtek 300Watts Single Output LED Driver P P C Electronics Corporation PLV-300 Series Features: Constant Voltage Design Universal AC input/ Full Range Built-in Active PFC function, PF 0.99 Typical High Efficiency (Up to 95%) Output Protections: OLP/OVP/SCP/OTP Lightning Protection Waterproof (IP67) 5 Year Warranty Model PLV-300S036 PLV-300S042 PLV-300S048 PLV-300S052 PLV-300S054 PLV-300S056 PLV-300S060 PLV-300S084 PLV-300S105 PLV-300S150 Output Characteristics DC Output 36V 42V 48V 52V 54V 56V 60V 84V 105V 150V Rated Current 8.33A 7.14A 6.25A 5.77A 5.55A 5.35A 5.0A 3.57A 2.85A 2.0A 0~8.33A 0~7.14A 0~6.25A 0~5.77A 0~5.55A 0~5.35A 0~5.0A 0~3.57A 0~2.85A 0~2.0A Current Range Ripple and Noise (max) Note 1 ±2% Vo Voltage Accuracy ±2% Vo Line Regulation ±1% Vo Load Regulation ±2% Vo Rise Time 20mS Max @ Rated Load Hold-up Time (Typ.) 10mS Min (110VAC input, full load), 20mS Min (220VAC input, full load) Input Characteristics Voltage Range 90VAC~305VAC Frequency Range 47Hz-63Hz Power Factor 110VAC >0.99 >0.99 >0.99 >0.99 >0.99 >0.99 >0.99 >0.99 >0.99 >0.99 (Typical) 220VAC >0.95 >0.95 >0.95 >0.95 >0.95 >0.95 >0.95 >0.95 >0.95 >0.95 Efficiency (Typical) 93% 93% 94% 94% 94% 94% 94% 94% 95% 95% AC Current (max) 3.5A @ 100-277VAC Input Full Load Inrush Current (max) 75A @ 230VAC, 25°C Leakage Current 0.75mA max @ 277VAC Protection Over Temperature (OTP) 110°C (Temperature of internal components); shut down, auto recover after the temperature decreases Over Voltage (OVP) 1.2~1.4Vo Note 2 Short Circuit (SCP) Long-term mode, auto recovery Environmental Characteristics Operating Temperature -35°C~70°C Operating Relative Humidity 10% RH to 100% RH Storage Temperature -40°C~85°C, 5% to 100% RH non-condensing Vibration 10 to 300Hz sweep at constant acceleration of 1.0G(Breadth: 3.5mm) for 1 Hour for each of the perpendicular axes X, Y, Z Waterproof Rating IP67 Safety Standards UL8750, Compliance to UL1012 UL935, IEC61347 Withstand Voltage L/N-GND: 4kV, L-N: 2kV Isolation Resistance I/P-O/P: >100M Ohms / 500VDC / 25°C / 70% RH EMC Emission Compliance to EN55022(CISPR22) Class B, EN61000-3-2 Class A, EN61000-3-3 EMC Immunity Compliance to EN61000-3-2, 3 EN61000-4-2, 3, 4, 5, 6, 8, 11, EN61547 Characteristics Life Time More than 50,000Hrs (25°C, 80% Load) MTBF (MIL-HDBK-217F) More than 255,000Hrs (25°C, 80% Load) Dimension (LxWxH) 260x101x46.3mm Note 1. Ripple & Noise: Measured by 20 MHz bandwidth oscilloscope and the output paralleled with a 0.1 uF ceramic capacitor and a 1 0 uF electrolytic capacitor. 2. Latch Mode: The power supply shall return to normal operation only after the power is turned on again Rev. B Page 1 of 3 300Watts Single Output LED Driver Qualtek Electronics Corporation P P C MECHANICAL SPECIFICATIONS PLV-300 Series UNIT: mm PLV-300S024 AC INPUT (18AWG/3C SJOW) BLACK (AC L) WHITE (AC N) YELLOW/GREEN (GND) DC OUTPUT (18AWG/2C SJOW) RED (V+) BLACK (V-) Note: The 2 DC output cables are connected in parallel internally because one #18 AWG wire can only carry 10A. Please connect the 2 red wires together and 2 black wires together, or ensure each cable carries the same current. ISO-9001 Company www.qualtekusa.com Page 2 of 3 300Watts Single Output LED Driver Qualtek P PLV-300 Series P C Electronics Corporation MECHANICAL SPECIFICATIONS UNIT: mm OTHERS Ambient Temperature vs.Load 100 100 80 80 Load（%） Load(%) Derating Curve 60 40 60 40 20 20 0 0 90 120 150 180 210 240 Input Voltage(V) ISO-9001 Company 270 300 330 -35 -20 -5 10 25 40 55 70 Ambient Temperature(℃) www.qualtekusa.com Page 3 of 3