STEVAL-IDS001V3 Low data-rate, short-range USB dongle transceiver in 433 MHz band based on the SPIRIT1 Data brief Description The STEVAL-IDS001V3 demonstration board is based on the SPIRIT1, which is a sub-GHz low power, low data-rate transceiver suitable for ISM bands and Wireless M-BUS. The board is equipped with an STM32L low power microcontroller to control the SPIRIT1. The board also features a USB connector for PC GUI interaction and firmware update. An optional JTAG connector (not mounted) allows the development of specific firmware on the microcontroller. STEVAL-IDS001V3 Features • SPIRIT1 low power sub-GHz transceiver integrated in a USB dongle for direct PC connection • External components tuned for 433 MHz band • STM32L microcontroller • Suitable for Wireless M-BUS systems • Associated SPIRIT1 development kit includes: documentation, firmware for STM32L and GUI • Optional debug connector (not mounted) • USB interface • Modulation schemes: 2-FSK, GFSK, MSK, GMSK, OOK, and ASK • Air data rate: from 1 to 500 kbps • Very low power consumption (9 mA RX and 21 mA TX at +11 dBm) • Excellent receiver sensitivity performance (up to -118 dBm) • Low duty cycle RX/TX operation mode • Automatic acknowledgment, retransmission, and timeout protocol engine • AES 128-bit encryption co-processor • SPI interface for microcontroller • RoHS compliant June 2013 DocID024792 Rev 1 For further information contact your local STMicroelectronics sales office. 1/7 www.st.com 2 1 2 SMD 0402 10nF C19 SPI1_CS SPI1_CLK 1 2 3 4 5 3 Y1 SMD 0402 50V 12pF C17 50V SPI1_MOSI SPI1_MISO IRQ0_SPIRIT1 SMD 0402 330pF C3 1 IRQ1_SPIRIT1 SMD 0402 1 2 1 50V 10pF C18 SMD 0402 1 50V CAV2P SMD 0402 16V GND NX2016SA-52MHZ SPIRIT1 GPIO_0 SDO SDI SCLK CSn U2 C4 100nF SMD 0402 50V 2 1 C2 100pF IRQ2_SPIRIT1 C1 TBD SMD 0402 50V C20 1 2 3 4 IRQ1_SPIRIT1 IRQ0_SPIRIT1 IRQ3_SPIRIT1 IRQ2_SPIRIT1 GND 21 3.9 pF for 315 MHz 2.2 pF for 433 MHz 2.2 pF for 868 MHz 2 pF for 915/920 MHz Not Mounted for 315/433 MHz 22 nH for 868 MHz 15 nH for 915/920 MHz C14 TBD 50V SMD 0402 GND 15 SDN_SPIRIT1 14 13 12 11 L12 TBD SMD 0402 EXPAD SDN SMPS_Ext1 SMPS_Ext2 TX REXT 4 HEADER J3 1 L1 10uH SMD 0805 TBD L13 SMD 0402 TBD L2 TBD SMD 0402 L5 2 C15 2 L8 TBD TBD 1 1.2 pF for 315 MHz Not Mounted for 433/868/915/920 MHz SMD 0402 16V C10 10V SMD 0402 TBD C5 2 SMD 0402 TBD TBD 50V 2 C16 12 pF for 315 MHz 8.2 pF for 433 MHz NM for 868 MHz 7 pF for 915/920 MHz SMD 0402 50V C11 SMD 0402 12 nH for 315 MHz 10 nH for 433 MHz 0R0 for 868 MHz 5.1 nH for 915/920 MHz 1 L9 1 SMD 0402 TBD 27 pF for 315 MHz 18 pF for 433 MHz 8.2 pF for 868 MHz 2.4 pF for 915/920 MHz SMD 0402 50V TBD SMD 0402 L6 2 2 SMD 0402 330pF C7 TBD 50V 15 pF for 315 MHz 10 pF for 433 MHz 5.6 pF for 868 MHz 3.6 pF for 915/920 MHz SMD 0402 50V C13 15 nH for 315 MHz 6.2 nH for 433 MHz 2.7 nH for 868 MHz Not Mounted for 915/920 MHz 1 16V 15 nH for 315 MHz 10 nH for 433 MHz 4.3 nH for 868 MHz 0R0 for 915/920 MHz TBD 1 L10 1 16V SMD 0402 100nF C6 TBD C12 2 C8 SMD 0402 220pF 2 1.8 pF for 315/433 MHz 1.2pF for 868 MHz Not Mounted for 915 MHz 1 uF for 315/433/915/920 MHz 470 nF for 868 MHz TBD SMD 0402 12 nH for 315 MHz 8.2 nH for 433 MHz 3.0 nH for 868 MHz 3.6 nH for 915/920 MHz 1 SMD 0402 4.7 pF for 315 MHz 3.3 pF for 433 MHz 1.8 pF for 868 MHz 1.5 pF for 915/920 MHz 50V TBD 2 150 nH for 433 MHz 100 nH for 868/915/920 MHz SMD 0402 220 nH for 315 MHz 220 pF for 315/433/868 MHz 330 pF for 915/920 MHz 47 nH for 315 MHz 39 nH for 433 MHz 18 nH for 868 MHz 15 nH for 915/920 MHz 1 1 270 nH for 315 MHz 100 nH fo r 4 33 MHz 27 nH for 868/915/920 MHz 2 39 nH for 315 MHz 27 nH for 433 MHz 18 nH for 868/915 MHz SMD 0402 L11 10uH 2 1 10V IRQ3_SPIRIT1 20 19 18 17 16 1 2 1uF 2 1 2 4 2 1 1 2 1 2 2 2 1 1 2 GPIO_1 GPIO_2 GPIO_3 VR_DIG VDD_SMPS XOUT XIN VDD_DIG RFp RFn 6 7 8 9 10 1 1 VDD CAV1 2 1 2 1 1 2 1 2 DocID024792 Rev 1 2 220pF SMD 0402 2 C9 1 1 50V 50V GND1 GND 220pF SMD 0402 2 C36 U.FL connector 2 U6 SIG 1 2 3 1 2 1 2 2/7 1 L3 91 nH for 315 MHz 30 nH for 433 MHz 4.3 nH for 868 MHz 8.7 nH for 915/920 MHz L4 L7 TBD SMD 0603 1 33 nH for 315 MHz 16 nH for 433 MHz 8.2 nH for 868 MHz 7.5 nH for 915/920 MHz 2 TBD 390 nH for 315 MHz 220 nH for 433 MHz 47 nH for 868 MHz 39 nH for 915/920 MHz SMD 0603 TBD AM11DG-ST01 Mitsubishi 315/433/868/915 MHz ANT1 SMD 0603 TBD 2 1 2 Schematic diagram STEVAL-IDS001V3 Schematic diagram Figure 1. SPIRIT1 circuit schematic AM17488v1 STEVAL-IDS001V3 Schematic diagram Figure 2. Oscillator circuit schematic D_VDD D_VDD C29 100nF 16V 100nF 16V SPI1_MOSI SPI1_MISO 2 2 SMD 0402 VCC /HOLD C /W D Q /S 6 5 2 SPI1_CLK 4 GND R2 7 100k 3 1 E2P_CS 2 1 1 C22 1 IC1 8 VBAT GND M95256-RMC6TG GND A_VDD GND 100nF 2 C21 1 VDD_A C24 10V 16V SMD 0402 1uF 1 2 SMD 0402 GND D_VDD U1 nRESET VDD_A User_Button_2 UART2 TX UART2 RX USER_LED_1 USER_LED_2 User_Button_1 IRQ3_SPIRIT1 D_VDD C23 1 1 C30 100nF 16V C31 4V 10uF BOOT0 2 IRQ2_SPIRIT1 IRQ1_SPIRIT1 IRQ0_SPIRIT1 SMD 0402 GND SWO D_VDD SWCLK VDD_2 USBDP C28 16V USBDM SMD 0402 SWDIO 100nF E2P_CS SPI1_MOSI GND SPI1_MISO SPI1_CLK SPI1_CS 1 VDD_1 VDD_3 1 OSC_IN OSC_OUT 3 GND Y2 8MHz 2 Vdd3 VLCD Vss3 PC13/WKUP2 PC14/OCS32IN PB9 PC15/OCS32OUT PB8 BOOT0 PH0/OSCIN PB7/I2C1SDA PH1/OSCOUT NRST PB6/IC2C1SCL VssA PB5 VddA PB4/JNTRST PA0/WKUP1 PB3/JTDO PA1 PA15/JTDI PA14/JTCK PA2/UART2TX PA3/UART2RX Vdd2 PA4/SPI1NSS Vss2 PA5/SPI1SCK PA13/JTMS PA6/SPI1MISO PA12/USBDP PA7/SPI1MOSI PA11/USBDM PB0/ADC12IN8 PA10/UART1RX PB1/ADC12IN9 PA9/UART1TX PB2/BOOT1 PA8 PB10/I2C2SCL/UART3TX PB15/SPI2MOSI PB11/I2C2SDA/UART3RX PB14/SPI2MISO PB13/SPI2SCK Vss1 Vdd1 PB12/SPI2NSS/I2C2SMBA 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 2 1 SDN_SPIRIT1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 2 VBAT 100nF 16V STM32L151CBU6 EPAD D_VDD 2 1 SMD 0402 R19 GND 10k GND SMD 0402 2 GND nRESET AM17494v1 DocID024792 Rev 1 3/7 7 Schematic diagram STEVAL-IDS001V3 Figure 3. SWD circuit schematic Boot BOOT0 R7 1 10k 2 SMD 0402 1 R10 10k 10k 10k SW2 1 1 PUSHBUTTON PUSHBUTTON C32 KMR221GLFS 100nF 401-1427-1-ND SMD 0402 C&K 16V 6 5 4 3 2 1 C33 KMR221GLFS 100nF 401-1427-1-ND SMD 0402 16V SMD 0402 2 D_VDD SWCLK SWO SWDIO 1 2 R14 nRESET 0 R15 Header 6 2 10k 2 2 Digikey P1 User_Button_2 2 2 SW1 JTAG SMD 0402 User_Button_1 GND R9 2 10k C&K User_Button_2 R6 SMD 0402 Digikey D_VDD 1 D_VDD User_Button_1 1 R5 1 1 D_VDD R12 D1 USER_LED_1 1 2 RED LED Digikey D2 680 1 2 USER_LED_2 R13 1 2 SMD 0402 680 1 2 SMD 0402 ORANGE LED Digikey 751-1182-1-ND 751-1174-1-ND Vishay TLMS1100-GS08 Vishay SMD 0603 TLMO1100-GS08 SMD 0603 AM17495v1 Figure 4. USB circuit schematic USBA Male J1 USB_5V 1 2 3 4 DM DP 5 5 Digikey WM17118-ND Molex 048037-1000 1 VDD R1 1k5 2 U3 DP 1 2 DM 3 D1 GND D2 D4 3.3V D3 6 USBDP 5 USB_5V 4 USBDM USBLC6-2P6 AM17496v1 4/7 DocID024792 Rev 1 STEVAL-IDS001V3 Schematic diagram Figure 5. Power management circuit schematic U4 LDS3985PU33R DFN6D exposed pad VDD D6 1 VIN VOUT 3 C25 U5 6 10V NC VINH C26 2.2uF 2 BAT46ZFILM 6.3V SMD 0402 1 1uF SMM4F50A 2 2 USB_5V 4 GND 5 C27 33nF 25V 7 2 BYPASS GND7 1 SMD 0402 STmite flat (DO222-AA) 1 SMD 0402 GND A_VDD VDD D_VDD L14 2 10nF 2 1 2 C34 50V L15 2 1 0.6 Ohm 300 mA 0.6 Ohm 300 mA SMD 0402 SMD 0402 C35 10nF 50V 1 SMD 0402 1 SMD 0402 GND GND AM17497v1 DocID024792 Rev 1 5/7 7 Revision history 2 STEVAL-IDS001V3 Revision history Table 1. Document revision history 6/7 Date Revision 28-Jun-2013 1 Changes Initial release. DocID024792 Rev 1 STEVAL-IDS001V3 Please Read Carefully: Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any time, without notice. All ST products are sold pursuant to ST’s terms and conditions of sale. Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no liability whatsoever relating to the choice, selection or use of the ST products and services described herein. No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such third party products or services or any intellectual property contained therein. UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT. ST PRODUCTS ARE NOT AUTHORIZED FOR USE IN WEAPONS. NOR ARE ST PRODUCTS DESIGNED OR AUTHORIZED FOR USE IN: (A) SAFETY CRITICAL APPLICATIONS SUCH AS LIFE SUPPORTING, ACTIVE IMPLANTED DEVICES OR SYSTEMS WITH PRODUCT FUNCTIONAL SAFETY REQUIREMENTS; (B) AERONAUTIC APPLICATIONS; (C) AUTOMOTIVE APPLICATIONS OR ENVIRONMENTS, AND/OR (D) AEROSPACE APPLICATIONS OR ENVIRONMENTS. WHERE ST PRODUCTS ARE NOT DESIGNED FOR SUCH USE, THE PURCHASER SHALL USE PRODUCTS AT PURCHASER’S SOLE RISK, EVEN IF ST HAS BEEN INFORMED IN WRITING OF SUCH USAGE, UNLESS A PRODUCT IS EXPRESSLY DESIGNATED BY ST AS BEING INTENDED FOR “AUTOMOTIVE, AUTOMOTIVE SAFETY OR MEDICAL” INDUSTRY DOMAINS ACCORDING TO ST PRODUCT DESIGN SPECIFICATIONS. PRODUCTS FORMALLY ESCC, QML OR JAN QUALIFIED ARE DEEMED SUITABLE FOR USE IN AEROSPACE BY THE CORRESPONDING GOVERNMENTAL AGENCY. Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any liability of ST. ST and the ST logo are trademarks or registered trademarks of ST in various countries. Information in this document supersedes and replaces all information previously supplied. The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners. © 2013 STMicroelectronics - All rights reserved STMicroelectronics group of companies Australia - Belgium - Brazil - Canada - China - Czech Republic - Finland - France - Germany - Hong Kong - India - Israel - Italy - Japan Malaysia - Malta - Morocco - Philippines - Singapore - Spain - Sweden - Switzerland - United Kingdom - United States of America www.st.com DocID024792 Rev 1 7/7 7