ERGO-NAV EGN-J Series Analog Joystick Navigation Device Features/Benefits • Omni-directional analog control • Variable speed (rate and control) • Small form factor • Low power (instant wake-up) • Integrated switch (center click) • True deflection device (pointing device) • Simple electrical interface • Environmental protection • Long life ! NEW EGN-Jx3x-xx EGN-Jx2x-xx 17.3-20.3 5.8-7.5 less than 2 25 23-24 74-120 9-20 210-380 2000 16.3 topside, 17.3 bottom 5.8 less than 2 25 23 or less 74 9 210 2000 19.3 topside 20.3 bottom 7.5 less than 2 25 24 or less 120 20 380 2000 User Interface NUMBER OF AXSIS PROVIDED: DIRECTIONS/VECTORS: NUMBER OF RATE STEPS FROM FULL: SOUTH to FULL NORTH DEFLECTION POSITION SAMPLING RATE: 1, 2, 4 & continous >360 Up to 1024 64 standard 25-40hz 40hz standard < 4ms SIGNAL LATENCY: How To Order A screw-mount B solder-mount EGN-JO for 360º omni-direction wth Z switch U for 360º omni-direction wthout Z switch V for N-way (N=1,2,4 axis) wth Z switch W for N-way (N=1,2,4 axis) wthout Z switch 0 without dedicated PCB 1 with dedicated PCB 1 for 13mm base diameter 2 for 20mm base diameter 3 for 17mm base diameter C for custom integration* 0 without dedicated microcontroller chip 1 with dedicated microcontroller chip *Custom Integration - ErgoNav EGN-J Series can be customized per the design rules and limitations: -Joystick footprint and actuator height (scalable per the design rules) -Joystick top cap (plastic or silicone; color & fashion) -Joystick plastic retainer (reference retainer integratable to device chassis per the design rules) -Dedicated microcontroller (contains firmware for quick I/O interface, or firmware compiled into device controller) Dimensions are shown: mm (inch) Specifications and dimensions subject to change C–19 www.ittcannon.com C Navigation Series Values PCB FOOTPRINT REQUIREMENT (mm): PCB TO ACTUATOR TIP HEIGHT (mm): MIN ACTUATION ANGLE (deg): MAX DEFLECTION FROM VERTICAL (deg): LATERAL FORCE @ MIN ACTUATION (g force): LATERAL FORCE @ MAX ACTUATION (g force): MIN VERTICAL FORCE TO ACTIVATE (g force): DOME SWITCH ACTUATION FORCE (g force): SINGLE LARGE LATERAL FORCE SURVIVABLE (g force): Typical Applications • Cell phones • Gaming devices • MP3 players • PDA’s • GPS devices • Remote controls • Laptops • Convergent devices • Others ERGO-NAV EGN-J Series Analog Joystick Navigation Device ELECTRICAL/SOFTWARE Series Values LINEARITY OF DEVICE OUTPUT: REPEATABILITY OF SINGLE DEVICE OUTPUT: SETTING TIME OF SIGNAL VOLTAGE IN DEVICE: RESISTANCE FOR NS OR EW AXIS: JOYSTICK NOT ACTUATED RESISTANCE: DOME SWITCH OPEN/CLOSED RESISTANCE: POWERING VOLTAGES: # OF A/D INPUTS REQUIRED: # OF GPIO INTERFACE NEEDED: ROM REQUIREMENTS: CONTINUOUS USE CURRENT PEAK* TYPICAL/WORST CASE: CONTINUOUS USE CURRENT AVERAGE* TYPICAL/WORST CASE: SLEEP POWER CONSUMPTION: R^2>0.97 ±2% Negligible 400-10,000Ω 10MΩ 500kΩ /250Ω 1.8-5 One 8 bit ADC 5 10kb max 3.1/8.3 mA 62/165µA 0µW Navigation * Typical transducers are 800-1600 ohms, worse case current is for 400 ohm transducer RELIABILITY ENVIRONMENTAL Series Values Series Values OPERATING LIFE (DEFLECTIONS): DOME SWITCH OPERATING LIFE, (CYCLES): VIBRATION: PULLOUT FORCE: DROP TEST: EMI/EMC: ESD RATING: >3M 500,000 No Effects 2kgf/4.5lbf Pass Pass Pass OPERATING TEMP (deg C): STORAGE TEMP (deg C): SHIPPING ALTITUDE (feet): RELATIVE HUMIDITY: DUST PROTECTION: CONTAMINATION RESISTANCE: BABY OIL, HAND CREAM: ROBUST CONTAMINANT RESISTANCE; WATER, SUGAR WATER, SALT WATER, COFFEE: -10 TO 45 -30 TO 70 40,000ft (0.2 atm) 0-85% IP5X No effect IPX4 Specific test reference / method is available upon request EGN-J-X-2 XSEC0001 q Sym. 4.60 Typ. 9.30 Ø 8.70 9.30 Ø 2.50 (4x) q Sym. 4.60 Typ. Ø 8.70 Ø 2.50 (4x) Ø 2.80 (4x) 12 4.1 Ø2.80 (4x) 9.30 12 Ø7 1.50 9.30 1.50 18.60 18.60 5.9 12.6 19.3 Ø3 Ø 1.15 (2x) R 8.10 Ø 1.15 (2x) 2.10 30.50 2.10 30.50 R 8.10 30.5 23.4 5.90 5.90 1.27 8.50 10.03 XSEC0001 2.54 Typ. 2.54 Typ. 18.60 24 PCB no switch 2.28 1.27 8.50 17 17 18.60 24 PCB with switch 1.93 3.17 0.08 24 1.55 ** Reference only 1 Dimensions are shown: mm (inch) Specifications and dimensions subject to change C–20 www.ittcannon.com ERGO-NAV EGN-J Series Analog Joystick Navigation Device EGN-J-X-3 XSEC0001 22.5 4.1 10.16 4.54 16.3 29 22 29 8.23 XSEC0001 1.81 1.49 2.44 0.08 1 C 1.55 q SYM ø 6.70 3.60 TYP ø 2.50 (4x) 8.50 ø2.80(4x) 11.25 8.50 29 q Sym 3.60 1.61 ø1.15(2x) 17 29 R6.62 ø6.70 ø2.50 (4x) ø2.80(4x) ø5.38 1.15 11.25 8.50 1.15 Navigation 8.50 1.61 ø3 ø 1.15 (2x) 17 R 6.60 6.70 6.70 1.27 2.54 6.93 13.85 17 22.5 1.27 2.54 6.93 13.85 17 22.5 PCB no switch PCB with switch ** Reference only Dimensions are shown: mm (inch) Specifications and dimensions subject to change C–21 www.ittcannon.com