Rev. 5/10 10 TO 500 MHz TO-8 CASCADABLE AMPLIFIER AC540 AC540 Typical Values Low Noise Figure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Medium Gain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Low Power Output. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . High Performance Thin Film Standard Size TO-8 Package 1.8 dB 12.5 dB +4.5 dBm AC540 TO-8 Package for Amplifiers SPECIFICATIONS* Parameter Typical Guaranteed 0 to 50 °C -55 to +85 °C Frequency (Min.) 5-600 MHz 10-500 MHz 10-500 MHz Small Signal Gain (Min.) 12.5 dB 11.5 dB 11.0 dB Gain Flatness (Max.) ±0.4 dB ±0.5 dB ±0.8 dB Noise Figure (Max.) 1.8 dB 2.5 dB 3.0 dB SWR (Max.) <1.6:1 1.8:1 2.0:1 +4.5 dBm +3.5 dBm +3.0 dBm Reverse Isolation 18.0 dB — — DC Current (Max.) 15.0 mA 18.0 mA 21.0 mA Input/Output Power Output (Min.) @ 1dB comp. AS540 * Measured in a 50-ohm system at +15 Vdc unless otherwise specified. SMTO-8 Package for Amplifiers INTERMODULATION PERFORMANCE Typical @ 25 °C; 100 MHz AC540 Second Order Harmonic Intercept Point. . . . . . . . . . . . . . . Second Order Two Tone Intercept Point . . . . . . . . . . . . . . . Third Order Two Tone Intercept Point . . . . . . . . . . . . . . . . . +30 dBm +24 dBm +17 dBm ABSOLUTE MAXIMUM RATINGS Storage Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -62 to +125 °C Maximum Case Temperature . . . . . . . . . . . . . . . . . . . . . . . . +125 °C Maximum DC Voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . +17 Volts Maximum Continuous RF Input Power . . . . . . . . . . . . . . . . +13 dBm Maximum Short Term Input Power (1 Minute Max.) . . . . . . . 50 Milliwatts Maximum Peak Power (3 µsec Max.) . . . . . . . . . . . . . . . . . . 0.5 Watt Burn-in Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . +125 °C Thermal Resistance1 (θjc) . . . . . . . . . . . . . . . . . . . . . . . . . . +47 °C/Watt Junction Temperature Rise Above Case (Tjc) . . . . . . . . . . . +12.8 °C 1 Thermal resistance is based on total power dissipation. DIMENSIONS ARE IN INCHES [MILLIMETERS] 650-691-9800 • Fax: 650-962-6845 • Updates: www.teledynemicrowave.com • [email protected] AC540 TYPICAL PERFORMANCE Gain vs Temperature Vcc = TYPICAL AUTOMATIC TEST DATA KEY: +25 °C +85 °C -55 °C 15 GAIN - dB 14.0 13.0 12.0 11.0 10.0 NOISE FIGURE - dB 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 Noise Figure Vcc = 15 & 12 4.0 3.0 2.0 1.0 10 20 30 50 100 200 300 FREQUENCY - MHz 400 500 600 Power Output at 1 dB Compression OUTPUT POWER - dBm 6.0 15v 5.0 4.0 12v 3.0 2.0 1.0 10 20 30 50 100 200 300 FREQUENCY - MHz 400 500 600 INTERCEPT POINT - dBm Intercept Point Vcc = 15 50 40 2nd HAR 20 IP 3 0 10 20 30 50 100 200 300 FREQUENCY - MHz 400 500 600 500 600 Intercept Point Vcc = 12 INTERCEPT POINT - dBm Model: AC540 FREQ. MHz 5 10 20 30 50 100 200 300 400 500 600 650 700 Model: AC540 FREQ MHZ 5 10 20 30 50 100 200 300 400 500 600 SWR IN 1.39 1.19 1.08 1.07 1.08 1.11 1.12 1.12 1.08 1.07 MAG 0.16 0.09 0.05 0.04 0.03 0.04 0.05 0.06 0.05 0.04 0.04 0.05 0.07 SWR IN 1.40 1.21 1.14 1.12 1.11 1.12 1.13 1.14 1.13 1.11 1.11 IP 2 30 10 Model: AC540 FREQ MHZ 5 10 30 50 100 200 300 400 500 600 50 40 IP 2 2nd HAR Model: AC540 FREQ. MHz 5 10 20 30 50 100 200 300 400 500 600 700 MAG 0.17 0.10 0.06 0.06 0.05 0.05 0.06 0.06 0.06 0.05 0.05 0.09 SWR OUT 1.14 1.06 1.03 1.05 1.12 1.24 1.34 1.44 1.48 1.45 Vcc=+15V GAIN PHASE DB DEG 12.09 -165 12.31 -174 12.30 177 12.30 173 12.25 164 12.19 148 12.18 132 12.19 116 12.24 99 12.24 82 DELAY NSEC 0.69 0.58 0.49 0.45 0.44 0.45 0.47 0.48 LINEAR S-PARAMETERS Vcc=+15V S11 S21 S12 ANG MAG ANG MAG ANG -61.9 4.02 -165.1 0.121 -174.2 -60.8 4.13 -173.8 0.125 -177.9 -47.2 4.13 -179.7 0.125 178.7 -33.5 4.12 177.4 0.125 177.0 -12.7 4.12 173.0 0.124 174.4 8.3 4.1 164.1 0.123 168.0 16.1 4.07 148.0 0.122 156.3 5.4 4.06 132.2 0.122 144.8 -11.2 4.07 116.0 0.122 133.1 -46.0 4.09 99.4 0.121 121.4 -108.7 4.09 81.9 0.121 109.8 -147.6 4.07 73.0 0.123 103.7 -175.6 4.05 63.8 0.121 97.7 SWR OUT 1.15 1.08 1.05 1.06 1.07 1.13 1.24 1.33 1.42 1.45 1.42 Vcc=+12V GAIN PHASE DB DEG 11.88 -165 12.09 -174 12.10 -180 12.08 177 12.05 173 12.03 164 11.96 148 11.95 132 11.98 116 12.03 99 12.02 81 DELAY NSEC 0.74 0.58 0.49 0.45 0.44 0.45 0.48 0.49 LINEAR S-PARAMETERS Vcc=+12V S11 S21 S12 ANG MAG ANG MAG ANG -55.3 3.93 -165.3 0.119 -174.6 -49.3 4.02 -173.9 0.122 -178.1 -34.2 4.03 -179.7 0.123 178.6 -23.0 4.02 177.3 0.123 177.0 -11.4 4.01 172.9 0.122 174.5 -3.1 3.99 164.1 0.121 168.0 0.9 3.96 148.0 0.120 156.4 -10.5 3.96 132.1 0.119 144.9 -28.9 3.97 115.8 0.120 132.9 -65.9 4.00 99.0 0.120 121.4 -119.8 3.99 81.4 0.120 109.6 -173.5 3.95 63.2 0.120 97.3 30 20 IP 3 10 0 10 20 30 50 100 200 300 FREQUENCY - MHz 400 650-691-9800 • Fax: 650-962-6845 • Updates: www.teledynemicrowave.com • [email protected] Icc=15.27 REV/ISO DB -18.4 -18.1 -18.0 -18.1 -18.2 -18.2 -18.3 -18.3 -18.3 -18.4 Icc=15.27 S22 MAG ANG 0.07 -65.3 0.03 -61.7 0.01 -19.5 0.01 28.9 0.03 57.8 0.06 63.8 0.11 55.3 0.15 42.1 0.18 29.2 0.19 17.6 0.18 3.5 0.18 -3.2 0.16 -10.2 Icc=12.46 REV/ISO DB -18.5 -18.3 -18.2 -18.2 -18.2 -18.4 -18.4 -18.5 -18.4 -18.4 -18.4 M Icc=12.46 S22 MAG ANG 0.07 -53.4 0.04 -40.8 0.03 -9.7 0.03 13.8 0.03 35.1 0.06 49.6 0.11 47.9 0.14 36.8 0.17 24.9 0.18 13.8 0.17 -0.1 0.15 -14.3