H HiTRON PCB-MOUNT DC-DC CONVERTER ENCAPSULATED MODULES INDUSTRIAL GRADE 17 WATTS SINGLE & DUAL OUTPUT HDM17-S & HDM17-D SERIES FEATURES: SINGLE & DUAL OUTPUT 2:1 INPUT RANGE 17W ISOLATED OUTPUT SIX-SIDED METAL SHIELD SPECIFICATION INPUT SPECIFICATION OUTPUT SPECIFICATION Input Range: 2:1 DC input range. See Ratings Chart. Input Voltage: Nominal 12/24/48Vdc. Input Current: Various with input range & load. See Ratings Chart. Input Fuse: Use external fuse. Input Filter: Pi-Network. Undervoltage Shutdown: 8Vdc. Isolation Resistor: 1,000 Mega Ohms. Isolation Voltage: 1,500Vdc. EMI: Six-sided metal shielding. Remote On/Off: TTL/CMOS-Compatible Input Control. Positive Logic version for Standard set up: ON(Enable)=Open(or 2.5-5.0Vdc above-Vin). OFF(Disable)=Short(or 0-0.8Vdc above-Vin). Negative Logic version option available by adding a “N” suffix to the end of Model #. Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Voltage Accuracy: Main O/P ±1.0% typical. Line Regulation: Various with output voltages. ±0.5% typical. Load Regulation: Various with output voltages. Single O/P ±1.0% typical. Dual O/P ±2.0% typical. Noise & Ripple: Typical 100mV for 3.3V/5.0V & 1.0% for others peak to peak. OVP: Built-in on main output. Adjustability: Not available. Overload Protection (OLP): Fully protected against output overload and short circuit. Typical 120-150% of rating output load. Consult the factory for special OLP setting. Remark: Logic voltage refer to –Input(-Vin). GENERAL SPECIFICATION Efficiency: 80-81% typical various with input. Switching Frequency: Fixed frequency 450K Hz. Circuit Topology: 450K Hz. Forward Circuit. Transient Response: Peak deviation 200mV, Recovery time <3mSec. @ 25% step load change. Case: Black coated steel with non-conductive metal base. Power Density: 18.0Watts. / Cubic inch. MTBF: 1,000,000 hours to Mil. Std. 217, 25°C. Operating Temperature: -25°C to +85°C range. –10°C to +70°C @ full load without derating. Derating linearly from +70°C to half-load @ +85°C. (Refer to the Derating Chart). Storage Temperature: -40°C to +105°C. Temperature Coefficient: ± 0.03% /°C. Humidity: Up to 95% RH, Non-condensing. Cooling: Convection cooling up to+70°C @full load. At least 100LFM moving air is recommended for full load >+70°C in a confined area. Industrial Grade only. NOTE:(1) All measurements are at nominal input, full load and +25°C unless otherwise specified. (2) Line Regulation measured from High to Low Lines at full load. (3) Load Regulation measured from Full Load (F-L) to Half-Load (H-L) at nominal input. (4) Correct fuse size by calculating the max. DC current drains at low Line input & Load and then adding 20-25% for the desired fuse size. Due to requests in market and advances in technology, specifications subject to change without notice. -23- INPUT/OUTPUT & VOLTAGE/CURRENT RATINGS CHART SINGLE OUTPUT MODEL NO. HDM17-12B-S03 HDM17-12B-S05 HDM17-12B-S09 HDM17-12B-S12 HDM17-12B-S15 HDM17-24B-S03 HDM17-24B-S05 HDM17-24B-S09 HDM17-24B-S12 HDM17-24B-S15 HDM17-48B-S03 HDM17-48B-S05 HDM17-48B-S09 HDM17-48B-S12 HDM17-48B-S15 INPUT VDC 9.0- 18.0 9.0- 18.0 9.0- 18.0 9.0- 18.0 9.0- 18.0 18.0- 36.0 18.0- 36.0 18.0- 36.0 18.0- 36.0 18.0- 36.0 36.0- 72.0 36.0- 72.0 36.0- 72.0 36.0- 72.0 36.0- 72.0 INPUT CURRENT N. L. (mA) F.L. 20 1,200 15 1,740 15 1,740 15 1,740 15 1,730 15 600 10 870 10 870 10 870 10 860 15 300 10 435 10 435 10 435 10 430 OUTPUT ★ OUTPUT VO1(A) VO1(Vdc) 3.3V 3.40A 5.0V 3.40A 9.0V 1.88A 12.0V 1.41A 15.0V 1.13A 3.3V 3.40A 5.0V 3.40A 9.0V 1.88A 12.0V 1.41A 15.0V 1.13A 3.3V 3.40A 5.0V 3.40A 9.0V 1.88A 12.0V 1.41A 15.0V 1.13A INPUT Vdc 9.0- 18.0 9.0- 18.0 9.0- 18.0 9.0- 18.0 18.0- 36.0 18.0- 36.0 18.0- 36.0 18.0- 36.0 36.0- 72.0 36.0- 72.0 36.0- 72.0 36.0- 72.0 INPUT CURRENT N. L. (mA) F.L. 25 1220 20 1760 20 1740 20 1760 20 610 15 880 15 870 15 855 20 305 15 440 15 435 15 427 OUTPUT (Vdc) +VO1 ★ -VO2║ +3.3V -3.3V + 5.0V - 5.0V +12.0V -12.0V +15.0V -15.0V +3.3V -3.3V + 5.0V - 5.0V +12.0V -12.0V +15.0V -15.0V +3.3V -3.3V + 5.0V - 5.0V +12.0V -12.0V +15.0V -15.0V CASE SIZE DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DUAL OUTPUT MODEL NO. HDM17-12B-D03 HDM17-12B-D05 HDM17-12B-D12 HDM17-12B-D15 HDM17-24B-D03 HDM17-24B-D05 HDM17-24B-D12 HDM17-24B-D15 HDM17-48B-D03 HDM17-48B-D05 HDM17-48B-D12 HDM17-48B-D15 Symbols: "★" OVP built-in. OUTPUT (A) +VO1 -VO2 1.70A 1.70A 1.70A 1.70A 0.70A 0.70A 0.55A 0.55A 1.70A 1.70A 1.70A 1.70A 0.70A 0.70A 0.55A 0.55A 1.70A 1.70A 1.70A 1.70A 0.70A 0.70A 0.55A 0.55A CASE SIZE DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C DM2C "║" Double Feedback. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 27.5g (0.97 Oz.) PIN ASSIGNMENT PIN NO. PIN# 1. PIN# 2. PIN# 3. PIN# 4. PIN# 5. PIN# 6. SINGLE Remote ON/OFF -INPUT/-Vin + INPUT DC-COM NO PIN VO1 DERATING CHART CASE SIZE: DM2C -24- DUAL Remote ON/OFF -INPUT/-Vin +INPUT -VO2 DC-COM +VO1