RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet Features ♦ ♦ ♦ ♦ 2 Watt Saturated Output Power Level Variable Drain Voltage (6-10V) Operation MSAG™ Process 5x5 mm 20 Lead PQFN Package YYWW AP067G XXXX MACOM Description The MAAP-000067-PKG0003 is a 3-stage 2 W power amplifier with on-chip bias networks in a 20 lead MLP package, allowing easy assembly. This product is fully matched to 50 ohms on both the input and output. It can be used as a power amplifier stage or as a driver stage in high power applications. Each device is 100% RF tested to ensure performance compliance. The part is fabricated using M/A-COM’s GaAs Multifunction Self-Aligned Gate (MSAG™) Process. Primary Applications: ♦ Point-to-Point Radio ♦ SatCom Also Available in: SAMPLES Description Die Sample Board (Die) Sample Board (Package) Mechanical Sample (Die) Part Number MAAPGM0067-DIE MAAP-000067-SMB004 MAAP-000067-SMB003 MAAP-000067-MCH000 Electrical Characteristics: TC = 35°C1, Z0 = 50Ω, VDD = 8V, IDQ = 640mA2, Pin = 12dBm, RG=150Ω 1 1. 2. Parameter Symbol Typical Units Bandwidth f 5.7-8.5 GHz Output Power POUT 33 dBm 1-dB Compression Point P1dB 33 dBm Small Signal Gain G 26 dB Power Added Efficiency PAE 30 % Input VSWR VSWR 1.7:1 Output VSWR VSWR 2.5:1 Gate Supply Current IGG 7 mA Drain Supply Current, under RF Drive IDD 900 mA Output Third Order Intercept TOI 41 dBm Output Third Order Intermod, Single Carrier Level = 23 dBm IM3 35 dBc TC = Case Temperature Adjust VGG between –2.6 and –1.2V to achieve specified IDQ. M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet Maximum Ratings3 Parameter Symbol Absolute Maximum Units Input Power PIN 17 dBm Drain Supply Voltage VDD +12.0 V Gate Supply Voltage VGG -3.0 V Quiescent Drain Current (No RF) IDQ 1.02 A Quiescent DC Power Dissipated (No RF) PDISS 10.2 W Junction Temperature TJ 170 °C Storage Temperature TSTG -55 to +150 °C 3. Operation beyond these limits may result in permanent damage to the part. Recommended Operating Conditions4 Characteristic Symbol Min Typ Max Unit Drain Supply Voltage VDD 6.0 8.0 10.0 V Gate Supply Voltage VGG -2.6 -2.0 -1.2 V 15.0 Input Power PIN 12.0 Thermal Resistance ΘJC 15.6 Case Temperature TC dBm °C/W Note 5 °C 4. Operation outside of these ranges may reduce product reliability. 5. Case Temperature = 170°C — ΘJC* VDD * IDQ Power Derating Curve, Quiescent (No RF) Operating Instructions This device is static sensitive. Please handle with care. To operate the device, follow these steps. Peak Power Dissipation, Pdiss (W) 12 10 8 6 4 2 1. Apply VGG = -2.7V, VDD= 0 V. 2. Ramp VDD to desired voltage, typically 8.0 V. 3. Adjust VGG to set IDQ, (approximately @ –2.0 V). 0 0 20 40 60 80 100 120 140 160 180 Maximum Case Temperature (°C) 4. Set RF input. 5. Power down sequence in reverse. Turn VGG off 2 last. M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet 40 40 6V 8V 10V 36 34 28 32 24 30 28 Small Signal Gain 4 16 26 12 24 8 22 4 3 Output VSWR 2 Input VSWR 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 0 9.0 1 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 9.0 Frequency (GHz) Frequency (GHz) Figure 1. 1dB Compression Point vs. Frequency and Drain Voltage at IDQ = 640mA Figure 2. Small Signal Gain and Input & Output VSWR vs. Frequency and Drain Voltage at IDQ = 640 mA 40 50 6V 8V 10V 38 36 6V 45 8V 40 34 35 32 30 PAE (%) 30 25 28 20 26 15 24 10 22 5 20 10V 0 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 9.0 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 Frequency (GHz) Frequency (GHz) Figure 3. Saturated Output Power vs. Frequency and Drain Voltage at IDQ = 640mA Figure 4. Saturated Power Added Efficiency vs. Frequency and Drain Voltage at IDQ = 640mA 9.0 44 38 42 36 40 0.8 38 0.7 36 0.6 34 0.5 32 0.4 30 0.3 28 0.2 22 26 0.1 20 24 SSG (dB), POUT (dBm), & PAE (%) 40 34 32 30 28 26 -25ºC 35ºC 95ºC 24 5.0 5.5 6.0 6.5 7.0 7.5 8.0 8.5 Frequency (GHz) Figure 5. Saturated Output Power vs Frequency and Case Temperature at Vd = 8V and IDQ = 640mA 3 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. 9.0 1.0 SSG POUT PAE 0.9 IDS 0.0 -25 -15 -5 5 15 25 35 45 55 65 75 85 95 Case Temperature (ºC) Figure 6. Small Signal Gain & Saturated Output Power, Power Added Efficiency, and Drain Current vs Case Temperature at 7GHz, VD = 8V and IDQ = 640mA • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. IDS (A) Output Power (dBm) 5 10V 20 20 Output Power (dBm) 6V 8V 32 Gain (dB) P1dB (dBm) 36 VSWR 38 6 RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet 35 40 38 31 34 32 29 28 Gain (dB) VD = 6V Output Power (dBm) 30 26 24 22 20 18 14 15 -10 -8 -6 -4 -2 0 2 4 6 8 10 12 12 14 16 18 20 22 24 26 28 30 Input Power (dBm) Output Power (dBm) Figure 7. Output Power vs. Input Power and Frequency at VD = 6V and IDQ = 640mA Figure 8. Gain vs. Output Power and Frequency at VD = 6V and IDQ = 640mA 32 34 36 38 35 40 38 6 GHz 7 GHz 8 GHz 33 36 31 34 32 29 30 28 Gain (dB) Output Power (dBm) 23 17 10 26 24 22 20 18 14 27 25 23 21 6 GHz 7 GHz 8 GHz 16 19 17 12 10 15 -10 -8 -6 -4 -2 0 2 4 6 8 10 12 12 14 14 16 18 20 22 24 26 28 30 32 Input Power (dBm) Output Power (dBm) Figure 9. Output Power vs. Input Power and Frequency at VD = 8V and IDQ = 640mA Figure 10. Gain vs. Output Power and Frequency at VD = 8V and IDQ = 640mA 40 34 36 38 35 38 6 GHz 7 GHz 8 GHz 33 36 34 31 32 29 30 28 Gain (dB) Output Power (dBm) 25 19 12 VD = 8V 27 21 6 GHz 7 GHz 8 GHz 16 VD = 10V 6 GHz 7 GHz 8 GHz 33 36 26 24 22 20 27 25 23 21 18 6 GHz 7 GHz 8 GHz 16 14 19 17 12 10 15 -10 -8 -6 -4 -2 0 2 4 6 8 10 12 14 Input Power (dBm) Figure 11. Output Power vs. Input Power and Frequency at VD = 10V and IDQ = 640mA 4 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. 16 12 14 16 18 20 22 24 26 28 30 32 34 36 Output Power (dBm) Figure 12. Gain vs. Output Power and Frequency at VD = 10V and IDQ = 640mA • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. 38 RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet 50 1.5 6 GHz 7 GHz 8 GHz 45 40 1.4 Drain Current (A) 1.2 30 PAE (%) VD = 6V 35 25 20 1.0 0.9 0.8 10 0.7 5 0.6 0.5 -10 -8 -7 -5 -3 -2 0 2 4 5 7 9 10 -10 12 -8 -6 -4 -2 0 6 8 Figure 13. Power Added Efficiency vs. Input Power and Frequency at VD = 6V and IDQ = 640mA Figure 14. Drain Current vs. Input Power and Frequency at VD = 6V and IDQ = 640mA 10 12 1.5 40 6 GHz 7 GHz 8 GHz 1.4 1.3 35 Drain Current (A) 1.2 30 25 20 1.1 1.0 0.9 15 0.8 10 0.7 5 0.6 0 0.5 -10 -8 -6 -4 -3 -1 1 3 5 7 8 10 12 14 -10 -8 -6 -4 -2 0 Input Power (dBm) 2 4 6 8 10 12 14 Input Power (dBm) Figure 15. Power Added Efficiency vs. Input Power and Frequency at VD = 8V and IDQ = 640mA Figure 16. Drain Current vs. Input Power and Frequency at VD = 8V and IDQ = 640mA 1.5 50 6 GHz 7 GHz 8 GHz 45 40 1.4 6 GHz 7 GHz 8 GHz 1.3 1.2 Drain Current (A) 35 30 PAE (%) 4 Input Power (dBm) 6 GHz 7 GHz 8 GHz 45 VD = 10V 2 Input Power (dBm) 50 PAE (%) 1.1 15 0 VD = 8V 6 GHz 7 GHz 8 GHz 1.3 25 20 1.1 1.0 0.9 15 0.8 10 0.7 5 0.6 0.5 0 -10 -8 -6 -4 -2 0 2 4 6 8 10 12 14 Input Power (dBm) Figure 17. Power Added Efficiency vs. Input Power and Frequency at VD = 10V and IDQ = 640mA 5 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. 16 -10 -8 -6 -4 -2 0 2 4 6 8 10 12 14 Input Power (dBm) Figure 18. Darin Current vs. Input Power and Frequency at VD = 10V and IDQ = 640mA • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. 16 RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet 100 50 48 80 44 70 42 60 IM3 (dBc) TOI (dBm) VD = 6V 46 40 38 34 20 32 10 0 10 12 14 16 18 20 22 24 26 28 30 8 32 12 14 16 18 20 22 24 26 28 Fundamental Output Power - Single Tone (dBm) Figure 19. Third Order Intercept vs. Output Power and Frequency at VD = 6V and IDQ = 640mA Figure 20. Third Order Intermod vs. Output Power and Frequency at VD = 6V and IDQ = 640mA 30 32 100 6 GHz 7 GHz 8 GHz 48 46 6 GHz 7 GHz 8 GHz 90 80 44 70 42 60 IM3 (dBc) TOI (dBm) 10 Fundamental Output Power - Single Tone (dBm) 50 VD = 8V 40 30 8 40 38 50 40 36 30 34 20 32 10 x 0 30 8 10 12 14 16 18 20 22 24 26 28 30 8 32 10 12 14 16 18 20 22 24 26 28 Fundamental Output Power - Single Tone (dBm) Fundamental Output Power - Single Tone (dBm) Figure 21. Third Order Intercept vs. Output Power and Frequency at VD = 8V and IDQ = 640mA Figure 22. Third Order Intermod vs. Output Power and Frequency at VD = 8V and IDQ = 640mA 50 30 32 100 6 GHz 7 GHz 8 GHz 48 46 90 6 GHz 7 GHz 8 GHz 80 44 70 42 60 IM3 (dBc) TOI (dBm) 50 36 30 VD = 10V 6 GHz 7 GHz 8 GHz 90 6 GHz 7 GHz 8 GHz 40 38 50 40 36 30 34 20 32 10 30 0 8 10 12 14 16 18 20 22 24 26 28 30 32 8 10 12 14 16 18 20 22 24 26 28 Fundamental Output Power - Single Tone (dBm) Fundamental Output Power - Single Tone (dBm) Figure 23. Third Order Intercept vs. Output Power and Frequency at VD = 10V and IDQ = 640mA Figure 24. Third Order Intermod vs. Output Power and Frequency at VD = 10V and IDQ = 640mA 6 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. 30 • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. 32 RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet 60 50 48 50 44 45 42 40 IM3 (dBc) TOI (dBm) 46 6 GHZ 7 GHZ 8 GHZ 55 6 GHZ 7 GHZ 8 GHZ 40 38 35 30 36 25 34 20 32 15 30 10 -25 -15 -5 5 15 25 35 45 55 65 75 85 95 -25 -15 -5 5 15 25 35 45 55 65 75 85 Case Temperature (ºC) Case Temperature (ºC) Figure 25. Third Order Intercept vs. Temperature and Frequency at Single Carrier Output Power Level = 23 dBm, VD = 8V and IDQ = 640mA Figure 26. Third Order Intermod vs. Temperature and Frequency at Single Carrier Output Power Level = 23 dBm, VD = 8V and IDQ = 640mA 7 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. 95 RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet Figure 27. 5x5 mm 20-Lead MLP. Figure 28. Recommended Bias Configuration. Note: The exposed pad centered on the package bottom must be connected to RF and dc ground for proper electrical and thermal operation. Refer to M/A-COM Application Note Surface Mounting Instructions for PQFN Packages #S2083* for assembly guidelines. Additional Precaution: All parts must receive a bake-out of 125ºC for 24 hours prior to any solder reflow operation. 8 *Application Notes can be found by going to the Site Search Page of M/A-COM’s web page (http://www.macom.com/Application%20Notes/ index.htm) and searching for the required Application Note. M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information. RoHS Compliant MAAP-000067-PKG003 Amplifier, Power, 2W 5.7-8.5 GHz Rev A Preliminary Datasheet (Twisted Pair) VGG (Twisted Pair) VDD 150Ω GND GND YYWW AP067G XXXX MACOM If the power supplies (VGG, VDD) are more then 12" from the Device Under Test, then additional decoupling capacitors may be required. Figure 29. Demonstration Board PN MAAP-000067-SMB003 (available upon request). 9 M/A-COM Inc. and its affiliates reserve the right to make changes to the product(s) or information contained herein without notice. M/A-COM makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does M/A-COM assume any liability whatsoever arising out of the use or application of any product(s) or information. • North America Tel: 800.366.2266 / Fax: 978.366.2266 • Europe Tel: 44.1908.574.200 / Fax: 44.1908.574.300 • Asia/Pacific Tel: 81.44.844.8296 / Fax: 81.44.844.8298 Visit www.macom.com for additional data sheets and product information.