GBJ25005 THRU GBJ2510 GLASS PASSIVATED BRIDGE RECTIFIER Reverse Voltage - 50 to 1000 Volts Forward Current - 25.0 Ampere FEATURES Glass passivated chip junction Reliable low cost construction utilizing molded plastic technique ● Ideal for printed circuit board ● Low reverse leakage current ● Low forward voltage drop ● High surge current capabiliy GBJ ● ● MECHANICAL DATA ● ● ● ● Case:Molded plastic, GBJ Terminals : Terminals: Leads solderable per MIL-STD-202 method 208 guaranteed Epoxy: UL 94V-0 rate flame retardant Mounting Position: Any Dimensions in inches and (millimeters) MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS Ratings at 25 C ambient temperature unless otherwise specified. Single phase half-wave 60Hz,resistive or inductive load,for capacitive load current derate by 20%. Symbols GBJ 25005 GBJ 2501 GBJ 2502 GBJ 2504 GBJ 2506 GBJ 2508 GBJ Units 2510 Maximum Recurrent Peak Reverse Voltage VRRM 50 100 200 400 600 800 1000 V Maximum RMS Voltage VRMS 35 70 140 280 420 560 700 V Maximum DC Blocking Voltage VDC 50 100 200 400 600 800 1000 V Maximum Average Forward Rectified Current with Heatsink at TC = 100 OC I(AV) 25 A Peak Forward Surge Current, 8.3 ms Single Half-Sine -Wave superimposed on rated load (JEDEC Method) IFSM 350 A VF 1.1 V IR 10 500 µA CJ 85 RθJC 0.6 TJ,TS -55 to +150 Parameter Maximum Forward Voltage at 12.5 A DC and 25OC Maximum Reverse Current at TA = 25 OC at Rated DC Blocking Voltage TA = 125 OC Typical Junction Capacitance Typical Thermal Resistance 1) 2) Operating and Storage Temperature Range 1) 2) Measured at 1 MHz and applied reverse voltage of 4 VDC. Thermal resistance from junction to case with device mounted on 300 mm X 300 mm X 1.6 mm Cu plate heatsink. pF C/W O C O GBJ25005 THRU GBJ2510 RATINGS AND CHARACTERISTIC CURVES Fig. 1 – Derating Curve Output Rectified Current 400 Heat-Sink Mounting, TC 25 P eak Forward S urge Current (A) Average Forward Output Current (A) 30 20 15 10 P.C.B. Mounting, 5 0 0 25 50 75 100 125 Fig. 2 – Maximum Non-Repetitive Peak Forward Surge Current Per Leg 350 300 200 150 100 50 1.0 Cycle 0 150 1 Temperature (°C) Number of Cycles at 60 H Z Fig. 4 – Typical Reverse Characteristics Per Leg Fig. 3 – Typical Forward Characteristics Per Leg Instantaneous R everse Current (µA) 1000 10 1 0.1 TA = 125°C 100 10 1 TA = 25°C 0.1 0.80 1.00 1.20 1.40 0 1000 20 40 Fig. 5 - Typical Junction Capacitance Per Leg 100 10 1 1 60 80 Percent of Rated Peak Reverse Voltage (%) Instantaneous Forward Voltage (V) Junction Capacitance (pF) Instantaneous Forward Current (A) 100 0.01 0.60 100 10 10 Reverse Voltage (%) 100 100