5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Features: • Peak breakdown voltage - 250V: EL303X(P5) - 400V: EL304X(P5) - 600V: EL306X(P5) - 800V: EL308X(P5) • High isolation voltage between input and output (Viso=5000 V rms ) • Zero voltage crossing • Pb free and RoHS compliant. • UL approved (No.E214129) • VDE approved (No.132249) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved • CSA approved • CQC approved Description The EL303X(P5), EL304X(P5), EL306X(P5) and EL308X(P5) series of devices each consist of a GaAs infrared emitting diode optically coupled to a monolithic silicon zero voltage crossing photo triac. They are designed for use with a discrete power triac in the interface of logic systems to equipment powered from 110 to 380 VAC lines, such as solid-state relays, industrial controls, motors, solenoids and consumer appliances. Schematic Applications Solenoid/valve controls Light controls Static power switch AC motor drivers E.M. contactors Temperature controls AC Motor starters Everlight Electronics Co., Ltd. Document No DPC-0000076 ： Pin Configuration 1. Anode 2. Cathode 3. No Connection 4. Terminal 5. Pin Cut 6. Terminal 1 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Absolute Maximum Ratings (Ta=25°C) Parameter Symbol Rating Unit Forward current IF 60 mA Reverse voltage VR 6 V 100 mW 3.8 mW /°C Input Power dissipation PD Derating factor (above 85°C) EL303X Off-state Output EL304X Terminal Voltage EL306X 250 400 VDRM EL308X V 600 800 Output 1 A 300 mW 7.6 mW /°C Viso 5000 V rms Total power dissipation PD 330 mW Operating temperature Topr -55~+100 °C Storage temperature Tstg -55~+125 °C Tsol 260 °C Peak Repetitive Surge Current ITSM Power dissipation PD Derating factor (above 85°C) Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2 & 3 are shorted together, and pins 4, 5 & 6 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 2 Rev. 1 http://www.everlight.com October 12, 2011 EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER Electrical Characteristics (Ta=25°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Condition Forward voltage VF - - 1.5 V IF = 30mA Reverse Leakage current IR - - 10 µA VR = 6V Symbol Min. Typ.* Max. Unit IDRM1 - - Output Parameter EL303X/304X Peak Blocking Current 100 EL306X/308X Peak On-state Voltage nA VDRM = Rated VDRM IF = 0mA V ITM=100mA peak, IF=Rated IFT 500 VTM EL303X /304X Critical Rate /306X of Rise of off-state EL308X Voltage dv/dt Inhibit Voltage (MT1-MT2 voltage above which device will not trigger) Leakage in lnhibited State - - 3 1000 - - Condition V/µs VPEAK =Rated VDRM, IF=0 (Fig. 10) 600 - - VINH - - 20 V IF= Rated IFT IDRM2 - - 500 µA IF= Rated IFT, VDRM=Rated VDRM, off state Symbol Min. Typ.* Max. Unit Condition - - 15 - - 10 mA Main terminal Voltage=3V - - 5 - 280 - Transfer Characteristics Parameter LED Trigger Current EL3031 EL3041 EL3061 EL3081 EL3032 EL3042 EL3062 EL3082 EL3033 EL3043 EL3063 EL3083 IFT Holding Current IH µA * Typical values at Ta = 25°C Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 3 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 4 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 5 Rev. 1 EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Figure 10. Static dv/dt Test Circuit & Waveform D.U.T. 10 kΩ T1 A K CTEST VT Zero Crossing Circuit RTEST 50 Ω High Voltage Pulse Source T2 Applied VT Waveform VPEAK 0.632 x VPEAK 0 τRC Measurement Method The high voltage pulse is set to the required VPEAK value and applied to the D.U.T. output side through the RC circuit above. LED current is not applied. The waveform VT is monitored using a x100 scope probe. By varying RTEST, the dv/dt (slope) is increased, until the D.U.T. is observed to trigger (waveform collapses). The dv/dt is then decreased until the D.U.T. stops triggering. At this point, τRC is recorded and the dv/dt calculated. dv/dt = 0.632 x VPEAK τRC For example, VPEAK = 600V for EL306X series. The dv/dt value is calculated as follows: 0.63 x 600 dv/dt = Everlight Electronics Co., Ltd. Document No DPC-0000076 ： τRC 378 = τ RC 6 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Order Information Part Number or or or EL303XY(Z)(P5)-V EL304XY(Z)(P5)-V EL306XY(Z)(P5)-V EL308XY(Z)(P5)-V Note X = Part No. (1, 2 or 3) Y = Lead form option (S, S1, M or none) Z = Tape and reel option (TA, TB or none). P5 = 5 pins type V = VDE safety approved (optional) Option Description Packing quantity None Standard DIP-6 65 units per tube M Wide lead bend (0.4 inch spacing) 65 units per tube S (TA) Surface mount lead form + TA tape & reel option 1000 units per reel S (TB) Surface mount lead form + TB tape & reel option 1000 units per reel S1 (TA) Surface mount lead form (low profile) + TA tape & reel option 1000 units per reel S1 (TB) Surface mount lead form (low profile) + TB tape & reel option 1000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 7 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Package Drawings (Dimensions in mm) Standard DIP Type Option M Type Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 8 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Option S Type Option S1 Type Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 9 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Recommended pad layout for surface mount leadform Device Marking EL 3083 YWWV Notes EL 3083 Y WW V denotes Everlight denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE optional Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 10 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A B Do D1 E F Dimension (mm) 10.4±0.1 7.52±0.1 1.5+0.1/-0 1.5+0.1/-0 1.75±0.1 7.5±0.1 Dimension No. Po P1 P2 t W K Dimension (mm) 4.0±0.15 1.6±0.1 2.0±0.1 0.35±0.03 16.0±0.2 4.5±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 11 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series Solder Reflow Temperature Profile 260 °C(peak) >255 °C (30s Max) 217°°C 1-3 °C/Sec Max 200°°C 60 – 100 Sec 150°°C 60 – 120 Sec 1-3 °C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 12 Rev. 1 http://www.everlight.com October 12, 2011 5 PIN DIP ZERO CROSS TRIAC DRIVER PHOTOCOUPLER EL303X(P5) Series EL304X(P5) Series EL306X(P5) Series EL308X(P5) Series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for use outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT. Reproduction in any from is prohibited without the specific consent of EVERLIGHT. Everlight Electronics Co., Ltd. Document No DPC-0000076 ： 13 Rev. 1 http://www.everlight.com October 12, 2011