DG5N miniature pcb power relay • miniature - only 20.5 x 7 x 15mm • High switching capacity 140W, 1250VA • High sensitivity 200mW coils • Cadmium free contacts • RoHS Compliant E305753 Contacts Contact number & arrangement SPST-NO (1 Form A) Contact material AgSnO2 Max. switching voltage Rated load (resistive - cos φ=1) AC/DC 250VAC, 28VDC AC1 5A/250VAC DC1 5A/28VDC Max. switching power 1250VA / 140W Contact Resistance (Initial) ≤ 50mΩ at 6VDC/1A Coil Rated voltage DC 3...48V (3V coil not UL approved) Must release voltage ≥0.10Un Operating range of supply voltage See coil table 1 Rated power consumption DC 200mW Insulation Insulation resistance Tracking resistance Dielectric strength ≥100MΩ at 500VDC, 50%RH CTI 250 coil to contact 4,000Vrms, 1min (50/60Hz); 10,000V surge contact to contact 1,000Vrms, 1min (50/60Hz) General Data Operating time (typical) ms ≤ 10 Release time (typical) ms ≤ 5 Max Switch Rate (On/Off) electrical 30 operations / minute mechanical 300 operations / minute Electrical Life ops 1 x 105 (resistive 5A/250VAC) Mechanical life ops 1 x 107 (no load) Dimensions Weight L x W x H 20.5 x 7.0 x 15mm ≤ 4g Ambient temperature storage -30 to 85°C operating -30 to 85°C Flammability Class UL 94V-0 Humidity range 45~85% RH Shock resistance Functional: 98.1m/s2 (10g) / Destructive: 981m/s2 6ms (100g) Vibration resistance 10-55Hz DA. 1.5mm Specifications are subject to change without notice. E&OE. Page 1 of 2 Ref: DG5N 090514JHM www.durakoolrelays.com Sales Department Tel: (888) 847-6552 DG5N miniature pcb power relay Coil Data (at 20°C) Table 1 Coil Resistance (Ω) ±10% Nominal Current (mA) Must Operate Voltage max. (VDC) Must Release Voltage min. (VDC) Max. Allowable Voltage (VDC) 3 45 66.7 2.25 0.3 3.9 5 125 40.0 3.75 0.5 6.5 6 180 33.7 4.50 0.6 7.8 1009 9 405 22.2 6.75 0.9 11.7 1012 12 720 16.7 9.00 1.2 15.6 1024 24 2880 8.3 18.0 2.4 31.2 Coil Voltage Code Nominal Voltage (VDC) 1003 1005 1006 Notes: 1) Operating the relay coil below the nominal voltage may compromise the current ratings for the contacts. 2) 3VDC Coil not UL approved. Ordering codes Contact Material Type D G 5 N - 3 Contact arrangement 0 2 1 Cover protection and mounting - 3 5 Coil code - Contact material 30 - see Table 1 AgSnO2 Contact arrangement 21 - SPST-NO (1N/O) Cover protection category 3 - in cover, sealed - IP67 (RTIII) Connection mode 5 - for PCB Options NIL - standard GW - GWFI IEC60695-2-12 850°C GWIT IEC60695-2-13 750°C Fig. 1 Dimensions Fig. 2 7 15 4.7 20. 5 PCB Mounting Dimensions 7 4 11. 5 0.4 0.2 0.2 0.8 0.4 Dimensions in millimeters Dimensions in millimeters Specifications are subject to change without notice. E&OE. Page 2 of 2 Ref: DG5N 090514JHM American Electronic Components Inc., 1101 Lafayette St. Elkhart, IN46516 www.durakoolrelays.com Sales Department Tel: (888) 847-6552 Bottom view