TOTAL POWER INT'L UNIVERSAL AC INPUT HARMONIC CORRECTION AC-DC 19" COMPATIBLE EUROCARD 60 WATTS MULTIPLE OUTPUT SWITCHING MODE POWER SUPPLIES HPU60 SERIES FEATURES: ACCOMMODATE UNIVERSAL AC SOURCES MEET IEC1000-3-2 HARMONIC CORRECTION MEET UNIVERSAL SAFETY STANDARDS 19” COMPATIBLE EUROCARD FORMAT EMI MEET EN 55022 & FCC CLASS B CE MARKING COMPLIANCE 3U X 8HP X 160MM FOR VMEbus STANDARD SPECIFICATION INPUT SPECIFICATION OUTPUT SPECIFICATION Input Voltage: Typ. 90-264Vac with PFC. Input Connector: DIN 41612 at rear. Input Frequency: 47-63Hz. Inrush Current: Typ. ≤30.6A @ 230Vac. Input Current: 0.73A @ 115Vac, 0.37A @ 230Vac. Dielectric Withstand: Meet IEC950. EMI/RFI: Meet EN 55022 & FCC B. Power Indicator: Green LED. Power Failure Signal: Installed. Remote On/Off: Installed. Power Factor Correction: Meet Harmonic Correction IEC1000-3-2 .PF typ. 0.97-0.98. Hold-up Time: 41mS @ 115Vac & 230Vac. Earth Leakage: Less than 0.40mA @ 230Vac. Output Voltage: See Ratings Chart. Output Current: See Ratings Chart. Output Connector: DIN 41612 at rear. Line Regulation: Typ. 0.5%. Load Regulation: Main VO1 typ. ±1.0%. Aux.VO2 typ. ±2.0% (Mag. Amp.) typ. ±3.0%.(P.R.). Aux.VO3 typ. ±3.0%(P.R.). Noise & Ripple: Typ. 1% peak to peak. OVP: Built-in at main VO1. Adjustability: Available at VO1 & VO2. Overload Protection (OLP): Fully protected against output overload and short circuit. Consult the factory for OLP setting. GENERAL SPECIFICATION Efficiency: Typ. 73%. Switching Frequency: Fixed frequency 83K Hz. Circuit Topology: Fixed frequency forward circuit. Transient Response: Output voltage returns in less than 3mS following a 25% load change. Safety Standard: IEC950 /UL1950 Class I. Power Density: 1.52 Watts / Cubic Inch. Operating Temperature: 0 to +50°C. Storage Temperature: -25 to +85°C. Temperature Coefficient: Typ. 0.03% /°C. Cooling: Forced air flow is recommended for full load >+40°C operation. Construction format: 3U x 8HP(TE) x 160mm. VMEbus standard Eurocard format. Note: All measurements are at nominal input, full load, and +25°C unless otherwise specified. OUTPUT VOLTAGE/CURRENT RATINGS CHART DUAL OUTPUT SINGLE OUTPUT MAIN VO1 @# Typ. Volt. 18.0A 2.5V 15.0A 3.3V 12.0A 5.0V 10.0A 6.0V 5.0A 12.0V 4.0A 15.0V 3.0A 19.0V 2.5A 24.0V 1.3A 48.0V MODEL NO. HPU60-S025180 HPU60-S033150 HPU60-S050120 HPU60-S060100 HPU60-S120050 HPU60-S150040 HPU60-S190030 HPU60-S240025 HPU60-S480013 03/14/2002 AUX. VO2 ▲◇ Typ. Volt. 6.0A 5.0V 3.0A 12.0V 3.0A 12.0V 2.5A 12.0V 2.5A 15.0V 2.0A 15.0V 1.5A 24.0V 1.4A 24.0V MAIN VO1 @# Typ. Volt. 6.0A 3.0V 6.0A 3.0V 5.0A 5.0V 2.5A 12.0V 5.0A 5.0V 2.0A 15.0V 5.0A 5.0V 1.4A 24.0V MODEL NO. HPU60-D030E HPU60-D030I HPU60-D050I HPU60-D120I HPU60-D050K HPU60-D150K HPU60-D050M HPU60-D240M TRIPLE OUTPUT MAIN VO1 @◇ Typ. Volt. MODEL NO. HPU60-T050IE (HPU60-30) HPU60-T050KK (HPU60-31) HPU60-T050II (HPU60-32) HPU60-T030EI HPU60-T030KK HPU60-T030II AUX. VO2 @▲◇ or● Typ. Volt. AUX. VO3 ●◇ Typ. Volt. 5.0A 5.0V 2.5A 12.0V 1.0A 5.0V 5.0A 5.0V 2.0A 15.0V 0.5A 15.0V 5.0A 5.0V 2.5A 12.0V 0.5A 12.0V 6.0A 6.0A 6.0A 3.0V 3.0V 3.0V 5.0A 2.0A 2.5A 5.0V 15.0V 12.0V 1.0A 0.5A 0.5A 12.0V 15.0V 12.0V Symbol: "★" OVP built-in. "@" Adjustable. "▲" Magnetic Amplifier" "●" Installed with Post Regulator. "◇" Floating(or isolated)output. "#" Remote sensing. MECHANICAL DIMENSIONS: MM [INCHES] WEIGHT: 720.0g (25.4Oz.) INPUT & OUTPUT CONNECTORS PIN ASSIGNMENT AC INPUT ASSIGNMENT CNTR & Pin# SINGLE OUTPUT AC- AC- AC+VO1 +S -VO1 -S L N G 28 30 32 4,6 Mating connector: DIN 41612-H15 Female 8 DUAL OUTPUT NC 16,18, 12,14 10 24,26 +VO1 -VO1 +VO2 -VO2 4 6 8 10 Status/ Control Log. P. +VO1 -VO1 +VO2 -VO2 +VO3 -VO3 NC Inh. Fail TRIPLE OUTPUT NC 12,14,16 18,24,26 4,6 8,10 12 14 16 18 24,26 20 22