rev. 10/00 AC518 AC519 5 TO 500 MHz TO-8 CASCADABLE AMPLIFIERS AC518 AC519 . 28.0 dB . +19.3 dBm . +32.0 dBm . 4.0 dB 27.5 dB +21.8 dBm +33.0 dBm 3.5 dB Typical Values HIgh Gain . . . . . . . . . . . . . . . High Output Power . . . . . . . High Third Order I.P.. . . . . . . Low Noise Figure. . . . . . . . . High Performance Thin Film Available in Surface Mount . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . AC518/AC519 TO-8 Package for Amplifiers 0.450 (11.43) DIA. 0.025 (0.64) 0.208 (5.28) MAX. 0.185 ± 0.015 (4.70 ± 0.38) SPECIFICATIONS Parameter Typical Frequency (Min.) Gain Flatness (Max.) Noise Figure (Max.) SWR (Max.) Guaranteed* 0 to 50° C -55 to +85° C 3-600 MHz Small Signal Gain (Min.) AC518 AC519 5-500 MHz 5-500 MHz 28.0 dB 27.5 dB 26.5 dB 26.5 dB 26.0 dB 26.0 dB < ±0.25 dB ±0.5 dB ±0.7 dB AC518 AC519 4.0 dB 3.5 dB 4.7 dB 4.5 dB 5.2 dB 5.0 dB Input/Output < 1.4:1 1.7:1 1.8:1 +19.3 dBm +21.8 dBm +18.5 dBm +20.5 dBm +17.0 dBm +20.0 dBm 96.0 mA 127.0 mA 103.0 mA 135.0 mA 110.0 mA 140.0 mA Power Output (Min.) @ 1dB comp. AC518 AC519 DC Current (Max.) AC518 AC519 0.018 ± 0.002 DIA. PIN (0.46 ± 0.05) (4) PLCS 0.504 (12.80) DIA. GROUND 50 OHM INPUT 50 OHM OUTPUT 0.033 (0.84) 0.031 (0.79) 45° ± 3° +DC VOLTAGE 0.300 (7.62) DIA. B.C. AS518/AS519 * Measured in a 50-ohm system at +15 Vdc unless otherwise specified. 0 0.225 (5.72) INTERMODULATION PERFORMANCE Typical @ 25° C Second Order Harmonic Intercept Point . . . . . Second Order Two Tone Intercept Point . . . . . Third Order Two Tone Intercept Point . . . . . . . AC518 AC519 55 dBm 50 dBm 32 dBm 50 dBm 44 dBm 33 dBm 0.450 (11.43) SMTO-8 Package for Amplifiers DETAIL A (NO SCALE) DC BIAS 0.016 ± 0.002 0.010 ± 0.002 0 0.016 ± 0.002 (0.41 ± 0.05) (4) PLCS 50 Ω INPUT 0.250 (6.35) 0.012 0.008 50 Ω OUTPUT Storage Temperature . . . . . . . . . . . . . . . . . . . . . . . . . Maximum Case Temperature . . . . . . . . . . . . . . . . . . . Maximum DC Voltage . . . . . . . . . . . . . . . . . . . . . . . . . Maximum Continuous RF Input Power . . . . . . . . . . . Maximum Short Term Input Power (1 Minute Max.) . . Maximum Peak Power (3 µsec Max.) . . . . . . . . . . . . . Burn-in Temperature (AC518/AC519) . . . . . . . . . . . . Thermal Resistance1 (θjc; AC518) . . . . . . . . . . . . . . . . Thermal Resistance1 (θjc; AC519) . . . . . . . . . . . . . . . . Junction Temperature Rise Above Case (Tjc; AC518) Junction Temperature Rise Above Case (Tjc; AC519) 1 Thermal resistance is based on total power dissipation. 104 . . . . . . . . . . . . . . . . . . . . . . -62 to 125° C +125° C +19 Volts +13 dBm 100 Milliwatts 0.5 Watt +85° C/+105° C +35° C/Watt +20° C/Watt +50° C +37.4° C 0.040 ± 0.012 (1.02 ± 0.30) (4) PLCS 0.375 (9.53) 0 GND SEE DETAIL "A" 0.225 (5.72) ABSOLUTE MAXIMUM RATINGS .0.075 (1.91) 0.450 (11.43) 0.170 (4.32) 0.050 (1.27) (4) PLCS 0 0.075 (1.91) 0.200 (5.08) 0.350 (8.89) 0.450 (11.43) 0.100 (2.54) (4) PLCS 0.031 (0.79) 0.031 (0.79) 0.010 (TYP.) (0.25) 45° 0.008 ± 0.001 (0.20 ± 0.03) DIMENSIONS ARE IN INCHES (MILLIMETERS) 408-522-3838 • Fax: 408-522-3839 • Check for updates: www.cougarcorp.com 2003 AC518/AC519 TYPICAL AUTOMATIC TEST DATA TYPICAL PERFORMANCE Gain vs Temperature AC518 KEY: +25 °C +85 °C -55 °C GAIN - dB 29.0 28.0 27.0 26.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 Gain vs Temperature AC519 GAIN - dB 29.0 28.0 27.0 26.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 NOISE FIGURE - dB Noise Figure 5.0 AC518 4.0 AC519 3.0 2.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 OUTPUT POWER - dBm Power Output at 1 dB Compression 23.0 AC519 (15 V) 22.0 21.0 20.0 AC518 (15 V) 19.0 18.0 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 INTERCEPT POINT - dBm Intercept Point AC518 70 60 2nd HAR 50 40 IP 3 IP 2 30 20 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 INTERCEPT POINT - dBm Intercept Point AC519 2003 70 60 2nd HAR 50 IP 2 40 IP 3 30 20 5 10 30 50 100 200 300 FREQUENCY - MHz 400 500 600 Model: AC519 FREQ MHZ 5 10 20 50 100 200 300 400 500 600 700 Model: AC519 FREQ. MHz 5 10 20 50 100 200 300 400 500 600 700 SWR IN 1.09 1.12 1.15 1.17 1.19 1.26 1.34 1.42 1.44 1.39 1.27 SWR OUT 1.09 1.05 1.03 1.05 1.06 1.07 1.10 1.17 1.27 1.46 1.82 S11 MAG 0.04 0.06 0.07 0.08 0.09 0.11 0.15 0.17 0.18 0.16 0.12 ANG -53.0 -13.2 -8.6 -19.4 -36.7 -64.5 -84.1 -102.4 -122.2 -148.9 163.0 Vcc=+15V GAIN PHASE DB DEG 26.88 36 27.27 16 27.43 4 27.51 -11 27.48 -29 27.43 -60 27.36 -92 27.32 -123 27.27 -155 27.26 172 27.20 137 SWR IN 1.11 1.14 1.16 1.18 1.20 1.28 1.37 1.45 1.47 1.43 1.33 SWR OUT 1.11 1.06 1.04 1.05 1.06 1.09 1.13 1.20 1.32 1.53 1.94 Vcc=+12V GAIN PHASE DB DEG 26.71 35 27.10 16 27.26 3 27.33 -12 27.30 -29 27.25 -61 27.17 -92 27.12 -124 27.09 -156 27.09 170 27.02 134 Model: AC518 FREQ MHZ 5 10 20 50 100 200 300 400 500 600 700 SWR IN 1.24 1.13 1.08 1.08 1.11 1.20 1.31 1.38 1.45 1.53 1.76 SWR OUT 1.07 1.15 1.18 1.19 1.20 1.21 1.20 1.21 1.24 1.40 1.77 Vcc=+15V GAIN PHASE DB DEG 27.71 30 27.84 13 27.91 2 27.94 -11 27.93 -28 27.96 -58 28.01 -88 28.04 -119 28.01 -151 27.84 175 27.44 140 Model: AC518 FREQ MHZ 5 10 20 50 100 200 300 400 500 600 700 S11 MAG 0.11 0.06 0.04 0.04 0.05 0.09 0.13 0.16 0.18 0.21 0.27 SWR IN 1.24 1.12 1.07 1.06 1.09 1.18 1.27 1.34 1.43 1.55 1.85 ANG -109.0 -127.0 -157.0 157.5 128.0 106.5 97.5 93.6 94.6 103.0 113.5 SWR OUT 1.07 1.15 1.17 1.19 1.19 1.21 1.22 1.22 1.26 1.42 1.81 3.4 1.4 0.97 0.88 0.86 0.87 0.89 0.92 0.98 LINEAR S-PARAMETERS Vcc=+15V S21 S12 MAG ANG MAG ANG 22.09 35.7 0.014 35.0 23.11 16.1 0.014 17.6 23.53 3.7 0.014 10.6 23.73 -11.4 0.015 0.5 23.67 -28.8 0.015 -6.8 23.53 -60.5 0.014 -17.1 23.35 -91.5 0.015 -24.1 23.21 -122.9 0.015 -32.3 23.10 -154.8 0.016 -40.8 23.08 172.0 0.017 -54.9 22.91 136.7 0.020 -69.6 Model: AC519 FREQ MHZ 5 10 20 50 100 200 300 400 500 600 700 Model: AC518 FREQ. MHz 5 10 20 50 100 200 300 400 500 600 700 GROUP DELAY NSEC Vcc=+12V GAIN PHASE DB DEG 27.51 29 27.65 13 27.72 2 27.75 -12 27.74 -28 27.78 -58 27.85 -89 27.90 -120 27.89 -152 27.72 174 27.29 138 408-522-3838 • Fax: 408-522-3839 • Check for updates: www.cougarcorp.com Icc=129.18 S22 MAG ANG 0.04 -84.7 0.02 -60.5 0.02 -17.6 0.02 0.7 0.03 0.5 0.04 1.0 0.05 -3.7 0.08 -14.4 0.12 -30.8 0.19 -53.3 0.29 -77.2 GROUP DELAY NSEC 3.4 1.4 0.97 0.89 0.87 0.88 0.9 0.93 1 GROUP DELAY NSEC 3 1.3 0.9 0.84 0.84 0.86 0.89 0.93 0.97 LINEAR S-PARAMETERS Vcc=+15V S21 S12 MAG ANG MAG ANG 24.28 30.1 0.013 37.2 24.66 12.8 0.014 17.7 24.85 2.1 0.015 10.7 24.94 -11.5 0.014 0.6 24.91 -27.7 0.014 -0.6 25.01 -57.9 0.015 -10.1 25.14 -88.1 0.016 -10.7 25.24 -119.1 0.016 -17.0 25.16 -151.1 0.017 -26.6 24.66 175.3 0.019 -38.5 23.55 140.4 0.021 -51.5 Icc=102.49 REV/ISO DB -37.1 -36.7 -36.6 -36.6 -36.8 -36.2 -36.4 -35.9 -35.7 -34.6 -33.8 Icc=96.59 REV/ISO DB -37.6 -37.1 -36.7 -36.8 -36.9 -36.6 -36.0 -35.9 -35.6 -34.2 -33.7 Icc=96.59 S22 MAG ANG 0.03 47.2 0.07 15.1 0.08 7.7 0.09 2.3 0.09 -2.5 0.09 -10.6 0.09 -25.0 0.09 -52.2 0.11 -95.6 0.17 -142.0 0.28 -179.2 GROUP DELAY NSEC 2.9 1.3 0.9 0.84 0.85 0.87 0.9 0.95 0.98 Icc=129.18 REV/ISO DB -37.1 -37.0 -37.0 -36.7 -36.7 -36.9 -36.7 -36.6 -36.1 -35.2 -34.0 Icc=76.42 REV/ISO DB -37.4 -37.1 -37.2 -36.6 -36.7 -36.9 -36.3 -35.7 -34.8 -34.3 -33.2 105