BTCPower TM Broadband TelCom Power, Inc. Redefining “Current” Limits In Power Conversion BSIP10-12W BSMT10-12W Series 10A SIP & SMT 12V Input DC-DC Converters Features • • • • • • • • • • Industry standard pin out High efficiency to 95% 300KHz switching frequency 6.0 – 14 Vdc input range 0.75-5.0Vdc wide output range Over temperature protection Continuous short circuit protection Remote On/Off Cost efficient open frame design UL / cUL 60950 certified Model Number Input Voltage Output Voltage Output Current Input Current No Load Full Load % Efficiency BSIP10-12-075W / BSMT10-12-075W 6.0 -14 Vdc 0.75 Vdc 10A 40 mA 762 mA 82 BSIP10-12-120W / BSMT10-12-120W 6.0 -14 Vdc 1.2 Vdc 10A 40 mA 1149 mA 87 BSIP10-12-150W / BSMT10-12-150W BSIP10-12-180W / BSMT10-12-180W 6.0 -14 Vdc 6.0 -14 Vdc 1.5 Vdc 1.8 Vdc 10A 10A 50 mA 40 mA 1404 mA 1666 mA 89 90 BSIP10-12-200W / BSMT10-12-200W 6.0 -14 Vdc 2.0 Vdc 10A 60 mA 1832 mA 91 BSIP10-12-250W / BSMT10-12-250W 6.0 -14 Vdc 2.5 Vdc 10A 65 mA 2264 mA 92 BSIP10-12-330W / BSMT10-12-330W 6.0 -14 Vdc 3.3 Vdc 10A 75 mA 2956 mA 93 BSIP10-12-500W / BSMT10-12-500W 6.5 -14 Vdc 5.0 Vdc 10A 95 mA 4386 mA 95 Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS BSIP10-12W Rev1 10-26-04 BSIP10-12W Series 10A SIP&SMT 12Vi DC-DC Converters BTCPower TM Specifications Input Specifications: Input Voltage Range…………….………12V………………... 6.0-14V Under voltage lock-out ………………power up ……………5.0V Typ. Power down ………..4.0V Typ. Input Filter……………………………………………………Capacitive Positive remove on /off control: Module On …………………………Open circuit or =Vin Module Off …………………………………….. < 0.4Vdc Isolation Resistance………………………………………Non-isolation Switching Frequency……………………………………..300 KHz, Typ. Over temperature protection ………………….………….. 130 ºC Typ. Operating Temperature Range…………………………-40ºC ~ +85ºC Case Temperature………………………………………….100 ºC max. Power derating curve …………………………………….. see fig. 1,2. Storage Temperature Range……………………..…..-55 ºC ~ +125ºC Dimensions: SIP package: 2.0” x 0.51” x 0.327“ (50.8 x 12.95 x 8.3 mm) Output Specifications: Voltage Accuracy…………….. ………………………….+/- 1.5 % max. Transient response : 25% step load change ……………< 200 u sec. Ripple & Noise, 20 MHz BW (note3)………………….50 mV p-p max. 5Vo ………………………………...75 mV p-p max. Temperature Coeffcient………………………… +/- 0.03 % / ºC max. Short Circuit Protection………………………………..……Continuous Line Regulation (note1) ………………………….……..+/- 0.2 % max. Load Regulation (note2) …… …………….…….….….+/- 0.5 % max. Capacitive load, low ESR…………………………………8000uF max. Sequencing delay time …………………………….……….20 ms max. Sequencing slew rate capacibility (dVseq/dt) …………0.1-1.0V / ms. SMT package: 1.3” x 0.53” x 0.346” (33.0 x 13.46 x 8.8 mm) Structure …………………………..Non-potted with open frame type Note: 1. Measured from high line to low line; 2. Measured from full load to zero load; 3. 4. Power good signal asserted logic high ….… Vo = 90% - 110%, nom. The input terminal recommend to parallel with 100uF capacitor ESR < 100 mohm 5. Suffix “N” to the model number with Negative logic remote Model On: Open circuit or < 0.4Vdc Tracking accuracy ………………………power up ……..200 mv max. Power down …….400 mv max. Measured with 10uF tantalum capacitor and 1 uF ceramic capacitor across output Model Off: > +2.8Vdc to Vin 6. Suffix “P” to the model number with Power Good function General Specifications: Efficiency………………………………………………..……...see table Outline Information and Pin-out SMT Outline information Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS BSIP10-12W Rev1 10-26-04 BSIP10-12W Series 10A SIP&SMT 12Vi DC-DC Converters BTCPower TM SIP Outline Inforamtion Dimensions are in Inches (millimeters) Tolerances: .XX ± 0.2” (.X ±0.5), unless otherwise noted .XXX ±0.01” (.XX ±0.25) PIN CONNECTION Pin Function 1 + Output 2 + Output 3 + Sense 4 + Output 5 Common 6 No pin / PGood 7 Common 8 + V Input 9 + V Input 10 Squency 11 Trim 12 On / Off Control Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS BSIP10-12W Rev1 10-26-04 BSIP10-12W Series 10A SIP&SMT 12Vi DC-DC Converters BTCPower TM Product Brief Temperature Typical Derating Curve Fig 1.: Typical Derating Curve of BSIP10-12W series Fig 2.: Typical Derating Curve of BSMT10-12W series Trim Resistor Values Vo (set) (V) Rtrim (Kohm) 0.75 Open 1.2 22.46 1.5 13.05 1.8 9.024 2 7.417 2.5 5.009 3.3 3.122 3.63 1.472 Fig 3.: Simplified Schematic The information and specifications contained in this brief are believed to be accurate and reliable at the time of publication. Specifications are subject to change without notice. Refer to product specification sheet for performance characteristics and application guidelines. Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS BSIP10-12W Rev1 10-26-04