Data Sheet No. PD60017 Rev.Q IR2125(S) & (PbF) CURRENT LIMITING SINGLE CHANNEL DRIVER Features Product Summary • Floating channel designed for bootstrap operation • • • • • • • Fully operational to +500V Tolerant to negative transient voltage dV/dt immune Gate drive supply range from 12 to 18V Undervoltage lockout Current detection and limiting loop to limit driven power transistor current Error lead indicates fault conditions and programs shutdown time Output in phase with input 2.5V, 5V and 15V input logic compatible Also available LEAD-Free VOFFSET 500V max. IO+/- 1A / 2A VOUT 12 - 18V VCSth 230 mV ton/off (typ.) 150 & 150 ns Packages Description The IR2125(S) is a high voltage, high speed power MOSFET and IGBT driver with over-current limiting protection circuitry. Proprietary HVIC and latch immune CMOS technologies enable ruggedized monolithic construction. Logic inputs are compatible with 16-Lead SOIC 8-Lead PDIP standard CMOS or LSTTL outputs, down to 2.5V (Wide Body) logic. The output driver features a high pulse current buffer stage designed for minimum driver cross-conduction. The protection circuitry detects over-current in the driven power transistor and limits the gate drive voltage. Cycle by cycle shutdown is programmed by an external capacitor which directly controls the time interval between detection of the over-current limiting conditions and latched shutdown. The floating channel can be used to drive an N-channel power MOSFET or IGBT in the high or low side configuration which operates up to 500 volts. Typical Connection (Refer to Lead Assignments for correct pin configuration). This/These diagram(s) show electrical connections only. Please refer to our Application Notes and DesignTips for proper circuit board layout. www.irf.com 1 IR2125(S) & (PbF) Absolute Maximum Ratings Absolute Maximum Ratings indicate sustained limits beyond which damage to the device may occur. All voltage parameters are absolute voltages referenced to COM. The Thermal Resistance and Power Dissipation ratings are measured under board mounted and still air conditions. Symbol Definition VB High Side Floating Supply Voltage Min. Max. -0.3 525 VS High Side Floating Offset Voltage VB - 25 VB + 0.3 VHO High Side Floating Output Voltage VS - 0.3 VB + 0.3 VCC Logic Supply Voltage -0.3 25 VIN Logic Input Voltage -0.3 VCC + 0.3 VERR Error Signal Voltage -0.3 VCC + 0.3 VCS Current Sense Voltage VS - 0.3 VB + 0.3 dVs/dt PD RthJA Allowable Offset Supply Voltage Transient — 50 Package Power Dissipation @ TA ≤ +25°C (8 lead PDIP) — 1.0 (16 lead SOIC) — 1.25 (8 lead PDIP) — 125 (16lLead SOIC) — 100 Thermal Resistance, Junction to Ambient TJ Junction Temperature — 150 TS Storage Temperature -55 150 TL Lead Temperature (Soldering, 10 seconds) — 300 Units V V/ns W °C/W °C Recommended Operating Conditions The Input/Output logic timing diagram is shown in Figure 1. For proper operation the device should be used within the recommended conditions. The VS offset rating is tested with all supplies biased at 15V differential. Symbol Definition Min. Max. VB High Side Floating Supply Voltage VS + 12 VS + 18 VS High Side Floating Offset Voltage Note 1 500 VHO High Side Floating Output Voltage VS VB VCC Logic Supply Voltage 0 18 VIN Logic Input Voltage 0 VCC VERR Error Signal Voltage 0 VCC VCS Current Sense Signal Voltage VS VB TA Ambient Temperature -40 125 Units V °C Note 1: Logic operational for VS of -5 to +500V. Logic state held for VS of -5V to -VBS. (Please refer to the Design Tip DT97-3 for more details). 2 www.irf.com IR2125(S) & (PbF) Dynamic Electrical Characteristics VBIAS (VCC, VBS) = 15V, CL = 3300 pF and TA = 25°C unless otherwise specified. The dynamic electrical characteristics are measured using the test circuit shown in Figures 3 through 6. Symbol ton t off t sd tr tf t cs terr Definition Turn-On Propagation Delay Turn-Off Propagation Delay ERR Shutdown Propagation Delay Turn-On Rise Time Turn-Off Fall Time CS Shutdown Propagation Delay CS to ERR Pull-Up Propagation Delay Figure Min. Typ. Max. Units Test Conditions 7 8 9 10 11 12 13 — — — — — — — 170 200 1.7 43 26 0.7 9.0 240 270 2.2 60 35 1.2 12 ns VIN = 0 & 5V VS = 0 to 600V µs ns µs CERR = 270 pF Static Electrical Characteristics VBIAS (VCC, VBS) = 15V and TA = 25°C unless otherwise specified. The VIN, VTH and IIN parameters are referenced to COM. The VO and IO parameters are referenced to VS. Symbol Definition VIH VIL 14 15 16 17 18 19 20 21 22 23 24 25 26 27 2.2 — 150 130 — — — — — — — — — 8.5 — — 230 210 — — — 400 700 4.5 — 4.5 — 9.2 — 0.8 320 300 100 100 50 1000 1200 10 1.0 10 1.0 10.0 28 7.7 8.3 9.0 29 8.3 8.9 9.6 30 7.3 8.0 8.7 IERR Logic “1” Input Voltage Logic “0” Input Voltage CS Input Positive Going Threshold CS Input Negative Going Threshold High Level Output Voltage, VBIAS - VO Low Level Output Voltage, VO Offset Supply Leakage Current Quiescent VBS Supply Current Quiescent VCC Supply Current Logic “1” Input Bias Current Logic “0” Input Bias Current “High” CS Bias Current “Low” CS Bias Current VBS Supply Undervoltage Positive Going Threshold VBS Supply Undervoltage Negative Going Threshold VCC Supply Undervoltage Positive Going Threshold VCC Supply Undervoltage Negative Going Threshold ERR Timing Charge Current 31 65 100 130 IERR+ ERR Pull-Up Current 32 8.0 15 — IERRIO+ ERR Pull-Down Current Output High Short Circuit Pulsed Current 33 34 16 1.0 30 1.6 — — I O- Output Low Short Circuit Pulsed Current 35 2.0 3.3 — VCSTH+ VCSTHV OH V OL ILK IQBS I QCC IIN+ IINICS+ ICSVBSUV+ VBSUVVCCUV+ VCCUV- Figure Min. Typ. Max. Units Test Conditions V mV µA V µA mA A www.irf.com IO = 0A IO = 0A VB = VS = 500V VIN = VCS = 0V or 5V VIN = VCS = 0V or 5V VIN = 5V VIN = 0V VCS = 3V VCS = 0V VIN = 5V, VCS = 3V ERR < VERR+ VIN = 5V, VCS = 3V ERR > VERR+ VIN = 0V VO = 0V, VIN = 5V PW ≤ 10 µs VO = 15V, VIN = 0V PW ≤ 10 µs 3 IR2125(S) & (PbF) Functional Block Diagram Y:Z :?X [ Y:Z \ !"#!$ %#'* Lead Definitions Symbol Description VCC IN ERR Logic and gate drive supply Logic input for gate driver output (HO), in phase with HO Serves multiple functions; status reporting, linear mode timing and cycle by cycle logic shutdown Logic ground High side floating supply High side gate drive output High side floating supply return Current sense input to current sense comparator COM VB HO VS CS Lead Assignments 1 1 V CC VB 3 IN HO 7 3 ERR CS 6 4 COM VS 5 8 Lead PDIP IR2125 4 VB IN HO 14 ERR COM CS 13 VS 12 2 8 2 Vcc 4 5 Part Number 16 15 6 11 7 10 8 9 16 Lead SOIC (Wide Body) IR2125S www.irf.com IR2125(S) & (PbF) HV=10 to 600V ERR t sd HO www.irf.com 5 500 500 400 400 Turn-On Time (ns) Turn-On Delay Time (ns) IR2125(S) & (PbF) 300 200 Max. 300 Max. 200 Typ. Typ. 100 100 0 0 -50 -25 0 25 50 75 100 10 125 12 Figure 7A. Turn-On Time vs. Temperature 16 18 20 Figure 7B. Turn-On Time vs. Voltage 500 500 400 400 Turn-Off Time (ns) Turn-Off Delay Time (ns) 14 VBIAS Supply Voltage (V) Temperature (°C) 300 200 300 Max. 200 Typ. Max. Typ. 100 100 0 0 -50 -25 0 25 50 75 100 125 10 12 Temperature (°C) Figure 8A. Turn-Off Time vs. Temperature ERR to Output Shutdown Delay Time (µs) ERR to Output Shutdown Delay Time (µs) 18 20 5.00 4.00 3.00 Max. Typ. 1.00 0.00 4.00 3.00 2.00 1.00 Max. Typ. 0.00 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 9A. ERR to Output Shutdown vs. Temperature 6 16 Figure 8B. Turn-Off Time vs. Voltage 5.00 2.00 14 VBIAS Supply Voltage (V) 10 12 14 16 18 20 VBIAS Supply Voltage (V) Figure 9B. ERR to Output Shutdown vs. Voltage www.irf.com IR2125(S) & (PbF) 100 100 80 80 60 Turn-On Rise Time (ns) Turn-On Rise Time (ns) Max. Max. Typ. 40 20 60 Typ. 40 20 0 0 -50 -25 0 25 50 75 100 10 125 12 Figure 10A. Turn-On Rise Time vs. Temperature 16 18 20 Figure 10B. Turn-On Rise Time vs. Voltage 100 100 80 80 Turn-Off Fall Time (ns) Turn-Off Fall Time (ns) 14 VBIAS Supply Voltage (V) Temperature (°C) 60 40 Max. 60 Max. 40 Typ. Typ. 20 20 0 0 -50 -25 0 25 50 75 100 125 10 12 Figure 11A. Turn-Off Fall Time vs. Temperature 18 20 2.00 CS to Output Shutdown Delay Time (µs) CS to Output Shutdown Delay Time (µs) 16 Figure 11B. Turn-Off Fall Time vs. Voltage 2.00 1.60 1.20 14 VBIAS Supply Voltage (V) Temperature (°C) Max. 0.80 Typ. 0.40 1.60 Max. 1.20 Typ. 0.80 0.40 0.00 0.00 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 12A. CS to Output Shutdown vs. Temperature www.irf.com 10 12 14 16 18 20 VBIAS Supply Voltage (V) Figure 12B. CS to Output Shutdown vs. Voltage 7 IR2125(S) & (PbF) 20.0 CS to ERR Pull-Up Delay Time (µs) CS to ERR Pull-Up Delay Time (µs) 20.0 16.0 Max. 12.0 Typ. 8.0 4.0 0.0 16.0 12.0 M ax. Typ. 8.0 4.0 0.0 -50 -25 0 25 50 75 100 125 10 12 5.00 5.00 4.00 4.00 3.00 Min. 2.00 1.00 20 3.00 Min. 2.00 0.00 -50 -25 0 25 50 75 100 125 10 12 Temperature (°C) 14 16 18 20 VCC Logic Supply Voltage (V) Figure 14A. Logic “1” Input Threshold vs. Temperature Figure 14B. Logic “1” Input Threshold vs. Voltage 5.00 5.00 4.00 4.00 Logic "0" Input Threshold (V) Logic "0" Input Threshold (V) 18 1.00 0.00 3.00 2.00 3.00 2.00 1.00 Max. 0.00 Max. 0.00 -50 -25 0 25 50 75 100 Temperature (°C) Figure 15A. Logic “0” Input Threshold vs. Temperature 8 16 Figure 13B. CS to ERR Pull-Up vs. Voltage Logic "1" Input Threshold (V) Logic "1" Input Threshold (V) Figure 13A. CS to ERR Pull-Up vs. Temperature 1.00 14 VBIAS Supply Voltage (V) Temperature (°C) 125 10 12 14 16 18 20 VCC Logic Supply Voltage (V) Figure 15B. Logic “0” Input Threshold vs. Voltage www.irf.com IR2125(S) & (PbF) 500 CS Input Positive Going Threshold (mV) CS Input Positive Going Threshold (mV) 500 400 Max. 300 Typ. 200 Min. 100 400 Max. 300 Typ. 200 Min. 100 0 0 -50 -25 0 25 50 75 100 125 10 12 Figure 16A. CS Input Threshold (+) vs. Temperature 18 20 500 CS Input Negative Going Threshold (mV) CS Input Negative Going Threshold (mV) 16 Figure 16B. CS Input Threshold (+) vs. Voltage 500 400 300 Max. Typ. 200 Min. 100 0 400 300 Max. Typ. 200 Min. 100 0 -50 -25 0 25 50 75 100 125 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Temperature (°C) Figure 17A. CS Input Threshold (-) vs. Temperature Figure 17B. CS Input Threshold (-) vs. Voltage 1.00 1.00 0.80 0.80 High Level Output Voltage (V) High Level Output Voltage (V) 14 VBS Floating Supply Voltage (V) Temperature (°C) 0.60 0.40 0.20 0.60 0.40 0.20 Max. Max. 0.00 0.00 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 18A. High Level Output vs. Temperature www.irf.com 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Figure 18B. High Level Output vs. Voltage 9 1.00 1.00 0.80 0.80 Low Level Output Voltage (V) Low Level Output Voltage (V) IR2125(S) & (PbF) 0.60 0.40 0.20 0.60 0.40 0.20 Max. Max. 0.00 0.00 -50 -25 0 25 50 75 100 125 10 12 Figure 19A. Low Level Output vs. Temperature 16 18 20 Figure 19B. Low Level Output vs. Voltage 500 500 400 400 Offset Supply Leakage Current (µA) Offset Supply Leakage Current (µA) 14 VBS Floating Supply Voltage (V) Temperature (°C) 300 200 100 300 200 100 Max. Max. 0 0 -50 -25 0 25 50 75 100 125 0 100 2.00 2.00 1.60 1.60 1.20 Max. 0.80 400 500 1.20 0.80 0.40 Typ. Max. Typ. 0.00 0.00 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 21A. VBS Supply Current vs. Temperature 10 300 Figure 20B. Offset Supply Current vs. Voltage VBS Supply Current (mA) VBS Supply Current (mA) Figure 20A. Offset Supply Current vs. Temperature 0.40 200 VB Boost Voltage (V) Temperature (°C) 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Figure 21B. VBS Supply Current vs. Voltage www.irf.com 2.00 2.00 1.60 1.60 VCC Supply Current (mA) VCC Supply Current (mA) IR2125(S) & (PbF) Max. 1.20 0.80 Typ. 0.40 1.20 Max. 0.80 Typ. 0.40 0.00 0.00 -50 -25 0 25 50 75 100 125 10 12 Figure 22A. VCC Supply Current vs. Temperature 16 18 20 Figure 22B. VCC Supply Current vs. Voltage 25 25 20 20 Logic "1" Input Bias Current (µA) Logic "1" Input Bias Current (µA) 14 VCC Logic Supply Voltage (V) Temperature (°C) 15 10 Max. 5 15 Max. 10 Typ. 5 Typ. 0 0 -50 -25 0 25 50 75 100 125 10 12 16 18 20 Figure 23B. Logic “1” Input Current vs. Voltage 5.00 5.00 4.00 4.00 Logic "0" Input Bias Current (µA) Logic "0" Input Bias Current (µA) Figure 23A. Logic “1” Input Current vs. Temperature 3.00 2.00 1.00 14 VCC Logic Supply Voltage (V) Temperature (°C) Max. 0.00 3.00 2.00 1.00 Max. 0.00 -50 -25 0 25 50 75 100 Temperature (°C) Figure 24A. Logic “0” Input Current vs. Temperature www.irf.com 125 10 12 14 16 18 20 VCC Logic Supply Voltage (V) Figure 24B. Logic “0” Input Current vs. Voltage 11 25.0 25.0 20.0 20.0 "High" CS Bias Current (µA) "High" CS Bias Current (µA) IR2125(S) & (PbF) 15.0 10.0 Max. Typ. 5.0 15.0 10.0 Max. Typ. 5.0 0.0 0.0 -50 -25 0 25 50 75 100 125 10 12 5.00 5.00 4.00 4.00 3.00 2.00 Max. 2.00 Max. -25 0 25 50 75 100 125 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Temperature (°C) Figure 26A. “Low” CS Bias Current vs. Temperature Figure 26B. “Low” CS Bias Current vs. Voltage 11.0 11.0 Max. VBS Undervoltage Lockout - (V) VBS Undervoltage Lockout + (V) 20 0.00 -50 Typ. 9.0 Min. 8.0 7.0 10.0 9.0 Max. Typ. 8.0 Min. 7.0 6.0 6.0 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 27. VBS Undervoltage (+) vs. Temperature 12 18 3.00 1.00 0.00 10.0 16 Figure 25B. “High” CS Bias Current vs. Voltage "Low" CS Bias Current (µA) "Low" CS Bias Current (µA) Figure 25A. “High” CS Bias Current vs. Temperature 1.00 14 VBS Floating Supply Voltage (V) Temperature (°C) -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 28. VBS Undervoltage (-) vs. Temperature www.irf.com IR2125(S) & (PbF) 11.0 10.0 10.0 VCC Undervoltage Lockout - (V) VCC Undervoltage Lockout + (V) 11.0 Max. Typ. 9.0 Min. 8.0 9.0 Max. Typ. 8.0 Min. 7.0 7.0 6.0 6.0 -50 -25 0 25 50 75 100 -50 125 -25 0 250 250 200 200 150 Max. Typ. Min. 50 0 150 100 125 Max. Typ. 100 Min. 50 -25 0 25 50 75 100 125 10 12 14 16 18 20 VCC Logic Supply Voltage (V) Temperature (°C) Figure 31A. ERR Timing Charge Current vs. Temperature Figure 31B. ERR Timing Charge Current vs. Voltage 25.0 25.0 20.0 ERR Pull-Up Current (mA) 20.0 ERR Pull-Up Current (mA) 75 0 -50 Typ. 15.0 10.0 50 Figure 30. VCC Undervoltage (-) vs. Temperature ERR Timing Charge Current (µA) ERR Timing Charge Current (µA) Figure 29. VCC Undervoltage (+) vs. Temperature 100 25 Temperature (°C) Temperature (°C) Min. 15.0 Typ. 10.0 Min. 5.0 5.0 0.0 0.0 -50 -25 0 25 50 75 100 125 10 12 14 16 18 20 Temperature (°C) VCC Logic Supply Voltage (V) Figure 32A. ERR Pull-Up Current vs. Temperature Figure 32B. ERR Pull-Up Current vs. Voltage www.irf.com 13 IR2125(S) & (PbF) 50 50 40 ERR Pull-Down Current (mA) ERR Pull-Down Current (mA) 40 Typ. 30 20 Min. 30 Typ. 20 Max. 10 10 0 0 -50 -25 0 25 50 75 100 125 10 12 14 16 18 20 Temperature (°C) VCC Logic Supply Voltage (V) Figure 33A. ERR Pull-Down Current vs.Temperature Figure 33B. ERR Pull-Down Current vs. Voltage 2.50 2.50 2.00 Typ. Output Source Current (A) Output Source Current (A) 2.00 1.50 Min. 1.00 0.50 1.50 1.00 Typ. Min. 0.50 0.00 0.00 -50 -25 0 25 50 75 100 125 10 12 Figure 34A. Output Source Current vs. Temperature 18 20 5.00 4.00 Typ. Output Sink Current (A) Output Sink Current (A) 16 Figure 34B. Output Source Current vs. Voltage 5.00 4.00 14 VBS Floating Supply Voltage (V) Temperature (°C) 3.00 Min. 2.00 3.00 Typ. 2.00 Min. 1.00 1.00 0.00 0.00 -50 -25 0 25 50 75 100 125 Temperature (°C) Figure 35A. Output Sink Current vs.Temperature 14 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Figure 35B. Output Sink Current vs. Voltage www.irf.com 300 300 250 250 Turn-Off Delay Time (ns) Turn-On Delay Time (ns) IR2125(S) & (PbF) 200 150 100 50 Max . 200 150 100 Typ. 50 0 0 0 2 4 6 8 0 10 12 14 16 18 20 2 4 Input Voltage (V) 6 8 10 12 14 16 18 20 Input Voltage (V) Figure 36A. Turn-On Time vs. Input Voltage Figure 36B. Turn-Off Time vs. Input Voltage 0.00 VS Offset Supply Voltage (V) -3.00 Typ. -6.00 -9.00 -12.00 -15.00 10 12 14 16 18 20 VBS Floating Supply Voltage (V) Figure 37. Maximum VS Negative Offset vs. Supply Voltage www.irf.com 15 IR2125(S) & (PbF) Case outlines 8-Lead PDIP 16-Lead SOIC (wide body) 16 01-6014 01-3003 01 (MS-001AB) 01 6015 01-3014 03 (MS-013AA) www.irf.com IR2125(S) & (PbF) LEADFREE PART MARKING INFORMATION Part number Date code IRxxxxxx YWW? Pin 1 Identifier ? P MARKING CODE Lead Free Released Non-Lead Free Released IR logo ?XXXX Lot Code (Prod mode - 4 digit SPN code) Assembly site code Per SCOP 200-002 ORDER INFORMATION Basic Part (Non-Lead Free) 8-Lead PDIP IR2125 order IR2125 16-Lead SOIC IR2125S order IR2125S Leadfree Part 8-Lead PDIP IR2125 order IR2125PbF 16-Lead SOIC IR2125S order IR2125SPbF IR WORLD HEADQUARTERS: 233 Kansas St., El Segundo, California 90245 Tel: (310) 252-7105 This product has been qualified per industrial level Data and specifications subject to change without notice. 9/12/2004 www.irf.com 17