ALUMINUM ELECTROLYTIC 6.3V to 100V NEV, NEH SERIES SUBMINIATURE (NEV: Radial Lead, NEH: Axial Leads) MECHANICAL SPECIFICATIONS Lead Solderability: The NEV and NEH series subminiature aluminum electrolytic capacitors are especially suitable for applications requiring high capacitance, low cost, and very small size. In fact, you’ll find these capacitors in some of the most demanding applications, from precision medical electronics and automobiles to the newest personal computers and disk drives. They operate over a broad temperature range and are available in either blister pack or bulk. Meets the requirements of MIL - STD 202, Method 208 Marking: Consists of series type, nominal capacitance, rated voltage, temperature range, anode and/or cathode identification, vendor identification. Recommended Cleaning Solvents: Methanol, isopropanol ethanol, isobutanol, petroleum ether, propanol and/or commercial detergents. Halogenated hydrocarbon cleaning agents such as Freon (MF, TF, or TC), trichloroethylene, trichloroethane, or methylchloride are not recommended as they may damage the capacitor. RATINGS Capacitance Range: 0.1µf to 22,000µf Tolerance: ±20% Voltage Range: 6.3V to 100V CASE SIZE AND DIMENSIONS: PERFORMANCE SPECIFICATIONS Operating Temperature Range: - 40°C to +85°C ( - 40°F to +185°F) NEV SERIES Leakage Current: I ≤ 0.01CV + 3µA (measured after 3 minutes of applied voltage) Insulating Sleeve 18.0 Min I = Leakage Current (µA) C = Nominal Capacitance (µf) V = Rated Voltage (V) Capacitance Tolerance (M): ±20% measured at +20°C (+68°F), 120HZ Dissipation Factor: measured at +20°C (+68°F),120HZ Rated Voltage 6.3 10 16 25 35 50 - 80 100 0.1µf to 1000µf 0.24 0.2 0.17 0.15 0.12 0.10 0.08 1000µf to 22,000µf A ±0.5 dØ DØ L L’ D’ Ø = D Ø + 0.5 Max 5.0 Min D’ Ø L’ = L + 1.0 Max at D Ø ≤ 8.0 L’ = L + 2.0 Max at D Ø ≥ 10.0 Values above plus 0.02 for each 1000µf Impedance Ratio at Low Temperature: 120HZ NEH SERIES (Insulating Bar = Negative) Comparison Z WV 6.3 10 16 25 35 50 - 100 Z @ - 25°C ( - 13°F)/ Z @ +20°C (+68°F) 4 3 2 2 2 2 L Insulating Sleeve dØ Z @ - 40°C ( - 40°F)/ Z @ +20°C (+68°F) 8 6 4 4 4 4 2.3 Max Surge Voltage: DØ DC Rated Voltage Surge Voltage 6.3 10 16 25 35 50 63 100 8 13 20 32 44 63 79 125 Load Life: 1000 ±12Hrs @ +85°C (+185°F), at rated voltage 35.0 Min D’ Ø = D Ø + 0.5 Max L’ 35.0 Min L’ = L + 1.0 Max at D Ø ≤ 8.0 D’ Ø L’ = L + 2.0 Max at D Ø ≥ 10.0 Leakage Current: Within values specified above Dissipation Factor: Within ±150% of specified value Capacitance Change Max: See Table Rated Voltage Capacitance Change Max 6.3V to 16V Within ±30% of the initial value 25V to 100V Within ±20% of the initial value Shelf Life: 1000 Hrs @ +85°C (+185°F), no voltage applied Leakage Current: Within ±200% of specified value Dissipation Factor: Within ±150% of specified value Capacitance Change Max: Within ±20% of initial value 2 ORDERING INFORMATION NEV 47 M 50 Series Capacitance Tolerance Voltage NTE Electronics, Inc. D Voice (800) 631 - 1250 (973) 748 - 5089 D FAX (973) 748 - 6224 D http://www.nteinc.com ALUMINUM ELECTROLYTIC 6.3V to 100V NEV, NEH SERIES NEV Series (Radial Type) Dimensions: Diameter (D Ø) x Length (L): mm WV Cap (µf) 6.3 10 16 25 35 0.10 50 63 100 5 x 11 5 x 11 0.22 5 x 11 5 x 11 5 x 11 0.33 5 x 11 5 x 11 5 x 11 0.47 5 x 11 5 x 11 5 x 11 0.56 5 x 11 5 x 11 5 x 11 5 x 11 5 x 11 0.15 5 x 11 5 x 11 0.68 5 x 11 1.0 1.5 5 x 11 5 x 11 2.2 5 x 11 5 x 11 5 x 11 3.3 5 x 11 5 x 11 5 x 11 4.7 5 x 11 5 x 11 5 x 11 6.8 5 x 11 5 x 11 6.3 x 11 5 x 11 5 x 11 6.3 x 11 10 15 5 x 11 5 x 11 6.3 x 11 5 x 11 5 x 11 5 x 11 6.3 x 11 8 x 11.5 5 x 11 5 x 11 5 x 11 6.3 x 11 6.3 x 11 10 x 12.5 5 x 11 6.3 x 11 6.3 x 11 22 33 47 5 x 11 5 x 11 68 6.3 x 11 6.3 x 11 5 x 11 6.3 x 11 6.3 x 11 8 x 11 8 x 11 8 x 11.5 8.5 x 11 10 x 12 10 x 16 10 x 20 10 x 12.5 100 150 8 x 11.5 220 6.3 x 11 330 6.3 x 11 470 8 x 11 680 10 x 16 1000 1500 8 x 11.5 10 x 12.5 8 x 11.5 10 x 16 10 x 16 10 x 20 10 x 12.5 13 x 21 13 x 20 13 x 25 10 x 16 10 x 20 16 x 25 8 x 11.5 8 x 11.5 8 x 11.5 8 x 11.5 10 x 12.5 10 x 16 10 x 20 13 x 21 16 x 25 8 x 11.5 10 x 12.5 10 x 16 10 x 20 13 x 21 13 x 25 16 x 31.5 10 x 16 10 x 12.5 10 x 16 13 x 21 13 x 25 13 x 25 16 x 25 10 x 12.5 10 x 16 10 x 20 13 x 21 13 x 25 16 x 25 16 x 31.5 18 x 40 13 x 25 13 x 25 16 x 31.5 16 x 35.5 16 x 35.5 2200 13 x 21 13 x 21 13 x 25 16 x 25 16 x 31.5 18 x 36 18 x 40 3300 13 x 21 13 x 25 16 x 25 16 x 31.5 18 x 36 18 x 40 22 x 41 4700 16 x 25 16 x 25 16 x 31.5 18 x 36 18 x 40 22 x 41 6800 16 x 25 16 x 31.5 18 x 36 18 x 40 22 x 41 16 x 31.5 18 x 36 18 x 40 22 x 41 10000 22000 6.3 x 11 8 x 11.5 8 x 11.5 18 x 46 * These dimensions are for reference only, please consult the factory for actual size. NEV Series (Radial Type) Mechanical Specifications: mm Outside Diameter (D Ø) 5 6.3 8 10 13 16 18 22 Lead Spacing (A) 2 2.5 3.5 5 5 7.5 7.5 10 0.5 0.6 0.6 0.6 0.6 0.8 0.8 1.0 Lead Diameter (d Ø) * These dimensions are for reference only, please consult the factory for actual size. NTE Electronics, Inc. D Voice (800) 631 - 1250 (973) 748 - 5089 D FAX (973) 748 - 6224 D http://www.nteinc.com 3 ALUMINUM ELECTROLYTIC 6.3V to 100V NEV, NEH SERIES NEH Series (Axial Type) Dimensions: Diameter (D Ø) x Length (L): mm WV Cap (µf) 6.3 10 16 25 35 50 63 100 0.10 5 x 12.5 5 x 12.5 5 x 12.5 0.22 5 x 12.5 5 x 12.5 5 x 12.5 0.33 5 x 12.5 5 x 12.5 5 x 12.5 0.47 5 x 12.5 5 x 12.5 5 x 12.5 0.68 5 x 12.5 1.0 5 x 12.5 1.5 5 x 12.5 5 x 12.5 5 x 11 2.2 5 x 12.5 5 x 12.5 5 x 12.5 3.3 5 x 12.5 5 x 12.5 5 x 12.5 4.7 5 x 12.5 5 x 12.5 5 x 12.5 6.8 5 x 11 10 6.3 x 12.5 5 x 11 6.3 x 12.5 6.3 x 11 6.3 x 12.5 6.3 x 16 15 5 x 11 5 x 11 6.3 x 11 6.3 x 11 8 x 11.5 22 5 x 11 6.3 x 12.5 6.3 x 12.5 6.3 x 16 8 x 16 8 x 20 5 x 12 6.3 x 12.5 6.3 x 12.5 6.3 x 16 8 x 16 8 x 16 8 x 20 6.3 x 12.5 6.3 x 12.5 6.3 x 16 8 x 16 8 x 16 8 x 20 10 x 20 8 x 11.5 8 x 16 8 x 16 10 x 12.5 10 x 16 33 47 5 x 11 68 6.3 x 11 6.3 x 11 100 6.3 x 12.5 6.3 x 16 6.3 x 16 8 x 16 8 x 20 8 x 20 10 x 20 150 8 x 16 8 x 16 8 x 16 10 x 16 10 x 16 10 x 16 10 x 20 220 8 x 16 8 x 16 8 x 16 8 x 20 10 x 20 10 x 20 10 x 25 13 x 25 330 8 x 16 8 x 16 8 x 20 10 x 20 10 x 20 13 x 25 13 x 25 13 x 35 470 8 x 16 8 x 20 10 x 20 10 x 20 10 x 25 13 x 25 13 x 30 16 x 30 680 10 x 16 10 x 20 10 x 20 10 x 25 13 x 25 13 x 30 16 x 30 16 x 30 1000 10 x 20 10 x 20 13 x 25 13 x 25 13 x 30 16 x 30 16 x 30 18 x 40 1500 13 x 25 13 x 25 13 x 20 16 x 31.5 2200 10 x 25 13 x 25 13 x 30 16 x 25 16 x 30 18 x 40 22 x 40 3300 13 x 25 13 x 30 16 x 30 16 x 30 16 x 40 22 x 40 22 x 50 4700 16 x 30 16 x 30 16 x 40 18 x 40 22 x 40 22 x 50 6800 16 x 30 16 x 40 18 x 40 22 x 40 22 x 50 10000 16 x 30 18 x 40 22 x 40 22 x 50 22000 10 x 25 25 x 50 * These dimensions are for reference only, please consult the factory for actual size. NEH Series (Axial Type) Mechanical Specifications: mm Outside Diameter (D Ø) Lead Diameter (d Ø) 5 6.3 8 10 13 16 18 22 25 0.6 0.6 0.6 0.6 0.8 0.8 0.8 0.8 0.8 * These dimensions are for reference only, please consult the factory for actual size. 4 NTE Electronics, Inc. D Voice (800) 631 - 1250 (973) 748 - 5089 D FAX (973) 748 - 6224 D http://www.nteinc.com