MBR3020 THRU MBR30100 Features • • • • Metal of siliconrectifier, majonty carrier conducton Guard ring for transient protection Low power loss high efficiency High surge capacity, High current capability Maximum Ratings • • TO-3 Operating Temperature: -55°C to +150°C Storage Temperature: -55°C to +150°C MCC Part Number MBR3020 MBR3030 MBR3035 MBR3040 MBR3045 MBR3060 MBR3080 MBR30100 Maximum Recurrent Peak Reverse Voltage 20V 30V 35V 40V 45V 60V 80V 100V Maximum RMS Voltage Maximum DC Blocking Voltage A N E C K 14V 21V 24.5V 28V 31.5V 42V 56V 70V 20V 30V 35V 40V 45V 60V 80V 100V PIN 1: PIN 2: CASE: ANODE ANODE CATHODE U V IF(AV) 30 A TL =105°C IFSM 400A 8.3ms, half sine IR 1.0 mA TA = 25°C Typical Junction Capacitance CJ 200pF Measured at 1.0MHz, VR=4.0V IFM = 30.0A; TA = 25°C VF .63 V .75 V .84 V *Pulse Test: Pulse Width 300µsec, Duty Cycle 1% Web Site: WWW.PS-PFS.COM L H 2 1 G B Q Electrical Characteristics @ 25°C Unless Otherwise Specified Average Forward Current Peak Forward Surge Current Maximum Instantaneous Forward Voltage MBR3020-3045 MBR3060 MBR3080-30100 Maximum DC Reverse Current At Rated DC Blocking Voltage D DIM A B C D E G H K L N Q U V DIMENSIONS INCHES MM MIN MAX MIN MAX 1.550 REF 39.37 REF ----1.050 ----26.67 .250 .335 6.35 8.51 .038 .043 0.97 1.09 .055 .070 1.40 1.77 .430 BSC 10.92 BSC .215 BSC 5.46 BSC .440 .480 11.18 12.19 .665 BSC 16.89 BSC ----.830 ----21.08 .151 .165 3.84 4.19 1.187 BSC 30.15 BSC .131 1.88 3.33 4.77 MBR3020 thru MBR30100 Figure 1 Typical Forward Characteristics 200 Figure 2 Forward Derating Curve 100 30 60 40 25 20 25°C 20 Amps 10 6 15 Amps 4 10 2 5 1 Single Phase, Half Wave 60Hz Resistive or Inductive Load .6 0 .4 0 50 75 100 125 150 175 °C .2 .1 0.06 0.05 0.07 0.08 Average Forward Rectified Current - Amperes versus Ambient Temperature - °C 0.1 0.09 Volts Instantaneous Forward Current - Amperes versus Instantaneous Forward Voltage - Volts Figure 3 Junction Capacitance 1000 600 400 200 pF 100 TJ=25°C 60 40 20 10 .1 .2 .4 1 Volts 2 4 10 20 40 100 200 400 Junction Capacitance - pF versus Reverse Voltage - Volts Web Site: WWW.PS-PFS.COM 1000 MBR3020 thru MBR30100 Figure 4 Typical Reverse Characteristics Figure 5 Peak Forward Surge Current 400 1000 600 400 350 200 300 100 250 60 Amps 40 200 100 20 0 TA=125°C mAmps 10 1 4 6 8 10 20 40 60 80 100 Cycles 6 Peak Forward Surge Current - Amperes versus Number Of Cycles At 60Hz - Cycles 4 2 1 .6 .4 TA=25°C .2 .1 2 10 20 40 60 80 100 120 Volts Instantaneous Reverse Leakage Current - MicroAmperes versus Percent Of Rated Peak Reverse Voltage - Volts Web Site: WWW.PS-PFS.COM