3M™ Round, Shielded/Jacketed, Disc. Wire Cable 28 AWG Stranded, Twisted Pair, PO/PVC 3644X Series • Dual shielding provides 35 db average shielding effectiveness • Wires are color coded for easy identification • Meets external wiring requirements of National Electrical Code, Article 725 (CL2) • UL listed for US and Canadian markets • Please contact your 3M sales representative for variations not described in this specification. • See Regulatory Information Appendix (RIA) for chemical compliance information (RIA E1 & C1 apply) Date Modified: May 13, 2009 TS-0826-B Sheet 1 of 3 Physical Jacket Material: Polyvinyl Chloride (PVC) Color: Beige Primary Material: Polyolefin (PO) Marking: Standard: (UL) CL2 75C 30 AWG 3M XX C AWM IIA/B 80C 150V FT1 EU <50V (where XX may be NU or NW) Conductors: 28 AWG 7 × 36 [ 7 × 0.127 ] Tinned Stranded Copper Shielding: 0.001 [ 0.03 ] Thick Aluminum/Polyester Film Foil and 90% Coverage Tinned Copper Braid Electrical Voltage Rating: USA: N.E.C. 725 CL2 Canada: 150V EU: <50V Insulation Resistance: (Primary Cable) > 1 × 1010 Ω/10 ft. [ 3 m ] Balanced Characteristic Impedance: Unbalanced 63 Ω Capacitance: 24.2 pF/ft [ 79.4 pF/m ] 100 Ω 15.3 pF/ft [ 50.2 pF/m ] Inductance: 0.10 μH/ft [ 0.33 μH/m ] 0.15 μH/ft [ 0.49 μH/m ] Propagation Delay: 1.54 ns/ft [ 5.05 ns/m ] 1.54 ns/ft [ 5.05 ns/m ] 66% Velocity of Propagation: 66% Note: Unbalanced is measured between ground-signal-ground conductors, with shield grounded. Balanced is measured between signal conductors within a pair, with the shield floating. Environmental Temperature Rating: USA: CL2: 75°C Max Flammability Rating: USA: N.E.C. 725, CL2 Canada: 80°C Canada: FT1 UL File No.: E118773, Power Limited Circuit Cable; CL2 3 Interconnect Solutions http://www.3M.com/interconnects/ 3M is a trademark of 3M Company. For technical, sales or ordering information call 800-225-5373 3M™ Round, Shielded/Jacketed, Disc. Wire Cable 28 AWG Stranded, Twisted Pair, PO/PVC 3644X Series C Film Foil Foam Polypropylene Tape Cable: Twisted Pair .026 Min [ 0.66 ] PVC Jacket .026 ± .001 [ 0.66 ] Braid Filler (Mfgr Option) 28 AWG 7 × 36 [ 7 × 0.127 ] Tinned Stranded Copper Conductors Dim A Discrete Wire Detail Film Foil Foam Polypropylene Tape Number of Conductors 3M Part Number Dimension A ± .02 14 (7 Pair) 3644X/14 .22 [ 5.6 ] 16 (8 Pair) 3644x/16 .23 [ 5.8 ] 20 (10 Pair) 3644X/20 .24 [ 6.1 ] 24 (12 pair) 3644X/24 .25 [ 6.4 ] 26 (13 Pair) 3644X/26 .25 [ 6.4 ] 30 (15 Pair) 3644X/30 .27 [ 6.9 ] 36 (18 Pair) 3644X/36 .29 [ 7.4 ] 40 (20 Pair) 3644X/40 .30 [ 7.6 ] 50 (25 Pair) 3644X/50 .32 [ 8.1 ] 68 (34 Pair) 3644X/68 .37 [ 9.4 ] 80 (40 Pair) 3644X/80 .39 [ 9.9 ] 100 (50 Pair) 3644X/100 .44 [11.2 ] 3 Interconnect Solutions http://www.3M.com/interconnects/ Inch [mm] Tolerance Unless Noted Inch .0 .00 .000 ±.1 ±.05 ±.010 [ ] Dimensions for Reference Only TS-0826-B Sheet 2 of 3 3M is a trademark of 3M Company. For technical, sales or ordering information call 800-225-5373 3M™ Round, Shielded/Jacketed, Disc. Wire Cable 28 AWG Stranded, Twisted Pair, PO/PVC Pair Cond 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 1 3 5 7 9 11 13 15 17 19 21 23 25 27 29 31 33 35 37 39 41 43 45 47 49 51 53 55 57 59 61 63 65 67 69 71 73 75 77 79 81 83 85 87 89 91 93 95 97 99 Pair Identification 1st Conductor Cond Solid Band White Tan 2 White Brown 4 White Pink 6 White Orange 8 White Yellow 10 White Green 12 White Blue 14 White Violet 16 White Gray 18 Tan Brown 20 Tan Pink 22 Tan Orange 24 Tan Yellow 26 Tan Green 28 Tan Blue 30 Tan Violet 32 Tan Gray 34 Brown Pink 36 Brown Orange 38 Brown Yellow 40 Brown Green 42 Brown Blue 44 Brown Violet 46 Brown Gray 48 Pink Orange 50 Pink Yellow 52 Pink Green 54 Pink Blue 56 Pink Violet 58 Pink Gray 60 Orange Yellow 62 Orange Green 64 Orange Blue 66 Orange Violet 68 Orange Gray 70 Yellow Green 72 Yellow Blue 74 Yellow Violet 76 Yellow Gray 78 Green Blue 80 Green Violet 82 Green Gray 84 Blue Violet 86 Blue Gray 88 Violet Gray 90 White 92 Gray 94 Blue 96 Violet 98 Green 100 3644X Series 2nd Conductor Solid Band Tan White Brown White Pink White Orange White Yellow White Green White Blue White Violet White Gray White Brown Tan Pink Tan Orange Tan Yellow Tan Green Tan Blue Tan Violet Tan Gray Tan Pink Brown Orange Brown Yellow Brown Green Brown Blue Brown Violet Brown Gray Brown Orange Pink Yellow Pink Green Pink Blue Pink Violet Pink Gray Pink Yellow Orange Green Orange Blue Orange Violet Orange Gray Orange Green Yellow Blue Yellow Violet Yellow Gray Yellow Blue Green Violet Green Gray Green Violet Blue Gray Blue Gray Violet Tan Brown Pink Orange Yellow - Ordering Information 3644X / XX XX Note: Standard length 20 through 68 conductors is 300 feet per roll. Standard length of 80 and 100 conductor cables is 200 feet per roll. 3 Interconnect Solutions http://www.3M.com/interconnects/ Jacket Color Options: A = "Special" Black Jacket B = "Standard" Beige Jacket Blank = Standard SF = Splice Free Number of Conductors (See Table) TS-0826-B Sheet 3 of 3 3M is a trademark of 3M Company. For technical, sales or ordering information call 800-225-5373 Regulatory Information Appendix 3M Electronic Solutions Division/Interconnect EUROPE Appendix E1: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product is RoHS Compliant 2005/95/EC. “RoHS Compliant 2005/95/EC” means that the product or part (“Product”) does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. Appendix E2: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product contains lead in the compliant pin area in excess of the maximum concentration value allowed but is compliant by exemption under EU Commission Decision 2005/747/EC. “RoHS Compliant 2005/95/EC” means that the product or part (“Product”) does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. Appendix E3: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment as amended by Commission Decision 2005/618/EC. This product contains lead in the solder tail area in excess of the maximum concentration value allowed. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. Appendix E4: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical & Electronic Equipment, as amended by EU Commission Decision 2005/618/EC, as amended by EU Commission Decision 2005/717/EC, as amended by EU Court of Justice Decision 2008/C 116/04 This product contains decaBDE in the insulating material in excess of the maximum concentration allowed for finished products subject to EU RoHS that are placed on the EU market after June 30, 2008. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. RIA-2217B-E Appendix E5: European Union RoHS Directive 2002/95/EC, Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic Equipment, as amended by EU Commission Decision 2005/618/EC. This product contains lead in excess of the maximum concentration value allowed but is compliant by exemption under Item 6 of the Annex to the Directive. “RoHS Compliant 2005/95/EC” means that the product or part (“Product”) does not contain any of the substances in excess of the maximum concentration values in EU Directive 2002/95/EC, as amended by Commission Decision 2005/618/EC, unless the substance is in an application that is exempt under EU RoHS. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. CHINA Appendix C1: China RoHS Electronic Industry Standard of the People’s Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does not contain any of the following substances in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the Warranty stated below. Appendix C2: China RoHS Electronic Industry Standard of the People’s Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. The numerical reference in the symbol above should not be construed as a representation regarding the product’s life or an extension of a product warranty. The product warranty is stated below. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the product Warranty stated below. RIA-2217B-E Appendix C3: China RoHS Electronic Industry Standard of the People’s Republic of China, SJ/T11363-2006, Requirements for Concentration Limits for Certain Hazardous Substances in Electronic Information Products. This symbol, per Marking for the Control of Pollution Caused by Electronic Information Products, SJ/T11364-2006, means that the product or part does contain a substance, as detailed in the chart below, in excess of the following maximum concentration values in any homogeneous material: (a) 0.1% (by weight) for lead, mercury, hexavalent chromium, polybrominated biphenyls or polybrominated diphenyl ethers (excluding decaBDE); or (b) 0.01% (by weight) for cadmium. Unless otherwise stated by 3M in writing, this information represents 3M’s best knowledge and belief based upon information provided by third party suppliers to 3M. The numerical reference in the symbol above should not be construed as a representation regarding the product’s life or an extension of a product warranty. The product warranty is stated below. In the event any product is proven not to conform with 3M’s Regulatory Information Appendix, then 3M’s entire liability and Buyer’s exclusive remedy will be in accordance with the product Warranty stated below. Important Notice All statements, technical information, and recommendations related to 3M’s products are based on information believed to be reliable, but the accuracy or completeness is not guaranteed. Before using this product, you must evaluate it and determine if it is suitable for your intended application. You assume all risks and liability associated with such use. Any statements related to the product which are not contained in 3M’s current publications, or any contrary statements contained on your purchase order shall have no force or effect unless expressly agreed upon, in writing, by an authorized officer of 3M. Warranty; Limited Remedy; Limited Liability. This product will be free from defects in material and manufacture for a period of one (1) year from the time of purchase. 3M MAKES NO OTHER WARRANTIES INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. If this product is defective within the warranty period stated above, your exclusive remedy shall be, at 3M’s option, to replace or repair the 3M product or refund the purchase price of the 3M product. Except where prohibited by law, 3M will not be liable for any indirect, special, incidental or consequential loss or damage arising from this 3M product, regardless of the legal theory asserted. 3 3M Electronics Solutions Division 6801 River Place Blvd. Austin, TX 78726-9000 U.S.A. 1-800-225-5373 www.3m.com/interconnects Please recycle. Printed in USA. © 3M 2008. All rights reserved. RIA-2217B-E 3M is a trademark of 3M Company.