RADIO MODULE MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Supports the follow parts: MTX-705 MTX-715 MTX-735 Y R A IN M I L E PR DATA SHEET Radios, Inc. April 14, 2006 Preliminary Data Sheet MTX-705/15/35 FSK/ASK TRANSMITTER MODULE The MTX-705/15/35 FSK/ASK transmitter is designed for applications in the 315 MHz, 433 MHz, or 868 MHz industrial-scientific-medical (ISM) band, according to the EN 300 220 telecommunications standard; but it can also be used in any other country with similar frequency bands. The MTX-705/15/35 transmitter consists of a fully integrated voltage-controlled oscilattor, a divide-by-32 divider, a phase-frequency detector and a charge pump. An internal loop filter determines the dynamic behavior of the PLL and suppresses reference spurious signals. A Colpitts crystal oscillator is used as the reference oscillator of a phaselocked loop synthesizer. The VCO’s output signal feeds the power amplifier. Y R A IN M I L E Typical Applications R P Key Features Fully integrated PLL-stabilized VCO Frequency range from 250-350MHz, 380450MHz, or 850-930MHz Single-ended RF output FSK through crystal pulling allows modulation from DC to 40 kbit/s High FSK deviation possible for wideband data transmission ASK achieved by on/off keying of internal power amplifier up to 40 kbit/s Very low standby current On-chip low voltage detector High over-all frequency accuracy FSK deviation and center frequency independently adjustable Adjustable output power range: -11 to +10 dBm Adjustable current consumption: 3.4 to 10.6 mA General digital data transmission Tire Pressure Monitoring System (TPMS) Remote Keyless Entry (RKE) Low-power telemetry Alarm and security systems Garage door openers Home automation PRODUCT ORDER INFORMATION Part Number MTX-705(D)(S) MTX-715(D)(S) MTX-735(D)(S) Description TH72005 FSK/ASK Module Transmitter TH72015 FSK/ASK Module Transmitter TH72035 FSK/ASK Module Transmitter Contact Information Radios, Inc. P.O. Box 1304 North Wales, PA 19454 Phone: 215-362-1899 Fax: 215-362-2214 Email: [email protected] -Page 2- MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Mechanical and Pin Diagram Pin Description Pin Num Pin Name Pin 1 Pin 2 Pin 3 Pin 4 Pin 5 Ant Gnd Gnd FSK-DATA ASK-DATA PRELIMINARY Description RF Output Ground Ground FSK Data Input ASK Data Input Pin Num Pin Name Pin 6 Pin 7 Pin 8 Pin 9 Pin 10 -Page 3- +VIN REG-EN +3.3V ENTX N/C Description Supply Voltage Regulator Enable Regulated Output Bandwidth Selection Bit 0 No Connect MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Electrical Limits Sym Parameters Min Absolute Maximum Ratings Supply Voltage Storage Temperature Range Lead Temperature Enable Input Voltage Operating Ratings Supply Voltage Enable Input Voltage Ambient operating temperature VDD VEN VEN TA Typ -20 -65 Max 20 150 Unit Notes -20 +20 V °C °C V 2.5 0 -40 16 TBD 125 V V °C 260 Electrical Characteristics This device is ESD sensitive. Do not operate or store near strong electrostatic fields. Use appropriate ESD precautions. All voltages are with respect to Ground. Parameters Operating Conditions Input Low Voltage Input High Voltage XOSC Frequency VCO Frequency FSK Deviation FSK Data Rate ASK Data Rate Operating Currents Standby Current Test Conditions Y R A IN M I L E PR ENTX, DATA pins ENTX, DATA pins MTX-705 MTX-715 MTX-735 MTX-705 MTX-715 MTX-735 MTX-705 MTX-715 MTX-735 NRZ NRZ Min 0.7VCC 9 11.9 26.6 290 380 850 ±2.5 ±2.5 ±2.5 ENTX=0, 85°C ENTX=0, 125°C Supply Current - MTX-705/15 Supply Current - MTX-735 0.2 7.3 9.4 Digital Pin Characteristics Input Low Voltage CMOS Input High Voltage CMOS Pull Down Current ENTX pin Low Level Input Current ENTX pin High Level Input Current DATA pins Pull Up Current DATA pins active Pull Up Current DATA pins standby ENTX, DATA pins ENTX, DATA pins ENTX=1 ENTX=0 FSK/ASK-DATA=1 FSK/ASK-DATA=0, ENTX=1 FSK/ASK-DATA=0, ENTX=0 FSK Switch Resistance MOS Switch On Resistance MOS Switch Off Resistance FSK-DATA=0, ENTX=1 FSK-DATA=1, ENTX=1 -Page 4- Typ 10.6 13.4 -0.3 0.7VCC 0.2 2 0.1 1.5 20 1 Max Unit 0.3VCC 10.9 14 29 350 450 930 ±30 ±40 ±60 40 40 V V MHz MHz MHz MHz MHz MHz kHz kHz kHz kbit/s kbit/s 200 4 13.3 17.3 nA µA mA mA 0.3VCC VCC+0.3 20 0.02 0.02 12 0.02 V V µA µA µA µA µA 60 Ohm MOhm MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Electrical Characteristics - CONT. Power Select Characteristics Power Select Current Power Select Voltage ENTX=1 ENTX=1 7 1.47 8.6 9.9 µA V Low Voltage Detection Characteristic Low Voltage Detect Threshold ENTX=1 1.75 1.85 1.95 V -83 -54 dBm dBm dBm dBc/Hz dBm -36 -30 dBm dBm 1.2 ms ±3 ±10 ppm ppm 0.4 0.18 V V V 0.01 -1 µA -2 µA 5 20 25 µA µA CW Spectrum Characteristics Output Power MTX-705 Output Power MTX-715 Output Power MTX-735 Phase Noise Spurious Emissions According to EN 300 220-1 (2000.09) table 13 Start-up Parameters Start-up Time ENTX=1 ENTX=1 ENTX=1 @ 200kHz offset 47MHz< f <74MHz 87.5MHz< f <118MHz 174MHz< f <230MHz 470MHz< f <862MHz, B=100kHz f < 1GHz, B=100kHz f > 1GHz, B=1MHz 7.6 7.1 6.7 -88 from standby to transmit mode 0.8 Y R A IN M I L E PR Frequency Stability Frequency Stability vs. Supply Voltage Frequency Stability vs. Temperature crystal at constant temperature ENABLE Input Enable Input Logic-Low Voltage(VIL) Enable Input Logic-High Voltage(VIH) Enable Input Current regulator shutdown regulator enabled 2.0 VIL </= 0.4V VIL </= 0.18V VIH = 2.0V 2 VIH = 2.0V Note 1. Exceeding the absolute maximum rating may damage the device. Note 2. The device is not guaranteed to function outside its operating rating. Note 3. Devices are ESD sensitive. Handling precautions recommended. Human body model, 1.5k in series with 100pF. -Page 5- MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Product Warranty and Disclaimer Information: Radios, Inc. is dedicated to providing its customers with the best possible products, and is continually working on improving the quality and function of its entire product line. Therefore, Radios, Inc. reserves the right to make changes to the design, specifications, or manufacturing of its products without notice. The information contained in this data sheet is believed to be complete, accurate, and reliable as of the time of publication. Because product specifications are based on representative lot samples, however, values can vary from lot to lot and are not guaranteed. Radios, Inc. does not assume any liability or responsibility arising from the application or use of any product described herein, and makes no guarantee, warranty, or representation regarding the suitability or legality of any product for use in a specific application. Radios, Inc. does not assume any liability for any infringement of patents or other rights of third parties which may result from the use of its products. No product sold by Radios, Inc. is intended for use in a life critical application, or an application where the safety of property is at risk. The user assumes full and complete responsibility for any use of Radios, Inc.’s products in an application where the safety of life or property is at stake. A product can be returned directly to Radios, Inc. for evaluation. All returns must have a valid RMA number attached. RMA numbers can be obtained by calling customer service at Radios, Inc. If a product is found to be defective and is returned within 90 days of purchase, Radios, Inc. may repair or replace, at its option, said defective product. This warranty does not apply to products which have been disassembled, modified, or subjected to conditions exceeding the application specifications. Under no conditions will Radios, Inc. be responsible for losses arising from the use or failure of a device in any application or for losses arising from failure to meet delivery requirements, other than the repair, replacement, or refund limited to the original product purchase price. No other warranties, express, implied, or statutory, including warranty of fitness for a particular purpose, apply. -Page 6- MTX-705/15/35 FSK/ASK TRANSMITTER MODULE Technical Support: Radios Inc. is committed to providing its customers with excellent technical support and the resources necessary to assist its customers with their product development. Customers have several options to obtain assistance. First, any questions or concerns can be e-mailed to Radios Inc. at [email protected]. We monitor our e-mail daily, and will respond to all questions promptly. Additionally, to speak directly to a technical support representative, customers may call Radios Inc. at 215-362-1899. Copyright: Radios Inc. reserves the right to all proprietary or commercial information contained in this data sheet. This data sheet is protected by copyright, and any unauthorized copying, reproduction, or dissemination is strictly prohibited without the prior written approval of Radios Inc. Editorial Information: Last Updated (Date) April 14, 2006PRELIMINARY -Page 7-