MATERIAL SAFETY DATA SHEET Finished Product Date-Issued: August, 2006 MSDS Ref. No: 35-91201 Date-Revised: Revision No: New MSDS 35-91201 Solar Guard™ Sunscreen Towel I. PRODUCT AND SUPPLIER INFORMATION PRODUCT NAME: 35-91201 MSDS number: 35-91201 Publication Date: Replaces: New Product Synonyms: Solar Guard™ Sunscreen Towel Chemical Family or Formula: B912 Marketer: NTE Electronics, Inc. 44 Farrand Street Bloomfield, NJ 07003 Product Information: 973-748-5089 Transportation Emergency: 973-748-5089 Phone: Fax: Website: Email: 973-748-5089 973-748-6224 www.nteinc.com [email protected] Note: The purpose of this MSDS is to provide safe handling, shipping and disposal information for users of the product. It is not intended to, nor does it, provide complete or extensive toxicological data on the product or its components. Users who require this information are referred to primary suppliers of the ingredients of interest. II. INGREDIENTS/IDENTITY INFORMATION Components (Chemical Identity, Common Name (s)) CAS No. OSHA PEL Ethanol 64-17-5 1000 ppm Octinoxate 5466-77-3 None Oxybenzone 131-57-7 None Octyl Salicylate 6969-49-9 None Homosalate 118-56-9 None ACGIH-TLV 1000 ppm None None None None Other limits Recommended % (Opt.) 60 – 100% 5 – 10% 3 – 7% 3 – 7% 1 – 5% Any substance listed as hazardous by the States of California, Florida, Illinois, Michigan, New Jersey, Ohio, Pennsylvania or Texas is described above if known present in regulated concentrations. III. HAZARDS IDENTIFICATION Route(s) of Entry Eyes? Inhalation? Yes No Skin? Ingestion? No No III. HAZARDS IDENTIFICATION (Cont’d) Acute Health Hazards – Warning. Flammable. For external use only. Keep away from heat, sparks, and flame when applying this product. Use with adequate ventilation. Avoid contact with eyes. Do not taste or swallow. Chronic Health Hazards – None Known Carcinogenicity: Chemical: OSHA NTP: IARC Monographs: None No No No Signs and Symptoms of Exposure – Redness, tearing, or burning in eyes. Redness, drying or irritation of skin. Medical Conditions Generally Aggravated by Exposure – Pre-existing skin conditions such as dermatitis may be adversely affected by this product. IV. EMERGENCY AND FIRST AID PROCEDURES: Eyes – Flush with plenty of water for at least 15 minutes lifting eyelids to insure complete removal. See a physician immediately. Indigestion – Not a likely exposure route. If a large quantity of liquid is swallowed, do not induce vomiting, call a physician or poison control center immediately. Inhalation – Unlikely route as liquid is impregnate on a towel, minimizing exposure via this route. If overexpoxed move into fresh air. If symptoms develop seek medical attention. Skin – None usually required. Material is designed for application on skin. If symptoms develop seek medical attention. V. FIRE FIGHTING MEASURES Flash Point, Concentrate (Method Used) Flammable Limits LEL UEL 62° F (PMCC) No Data No Data No Data Extinguishing Media – Use carbon dioxide, dry chemical, or alcohol foam. Special Fire Fighting Procedures – Water may be ineffective. Keep containers cool and vapors down with water spray. Prevent runoff from entering sewers and public waterways. Wear a SCBA in chemical fires. Hazardous Products of Combustion – Carbon dioxide, carbon monoxide, hydrogen sulfide, sulfur dioxide, smoke and soot. Unusual Fire and Explosion Hazards – Vapors are heavier than and may travel along the ground or may be moved by ventilation and ignited by pilot lights, other flames, sparks, heaters, electric motors, static charge, or other ignition sources at locations distant from material handling point. VI. ACCIDENTAL RELEASE MEASURES Small Spill – Wipe up small releases with a dry absorbent cloth or other absorbent material. Large Spill – Absorb liquid with vermiculite, absorbent cloth, or other absorbent material. Prevent material from entering sewers or drains. Ventilate area and block traffic. Transfer contaminated material into suitable container for proper disposal. VII. HANDLING AND STORAGE Handling – Do not allow towel contact with eyes. For external use only. Not for use around the mouth or eyes for an extended period of time. Do not smoke while using. Do not contaminate water, food or feed by use or storage. Follow label directions carefully Storage – Store in a cool well ventilated area. Keep away from heat sources. Keep out of reach of children. VIII. EXPOSURE CONTROLS/ PERSONAL PROTECTION Eye Protection – None necessary. Do not allow towel to directly contact eyes. Skin Protection – Not necessary. Product is designed for direct skin use. Respirator Protection – Not usually necessary. Use with adequate ventilation. Use NIOSH/MSHA approved respirator if PELs or TLVs are exceeded. Engineering Controls – Ventilation not usually necessary but should be provided in the event of overexposure. IX. PHYSICAL AND CHEMICAL DATA Appearance and Odor: Clear yellow liquid with an alcohol and perfume odor saturated on towel. PH 6.7 + 0.5 Specific Gravity (70°F) 0.856 Boiling Point: 180°F Melting Point: No Data Evaporation Rate (Butyl Acetate = 1) >1 Vapor Pressure (mm-Hg @ 70°F) No Data Vapor Density (AIR = 1) >1 Solubility in Water Complete Volatile Organic Compounds (VOCs) 633.35 grams per liter 73.99% by weight X. STABILITY AND REACTIVITY Hazardous Polymerization – This product will not undergo hazardous polymerization. Hazardous Decomposition or Byproducts – Carbon Dioxide, carbon monoxide, hydrogen sulfide, sulfur dioxide, and soot. Chemical Stability – Stable Incompatibility (Materials to Avoid) – Acetaldehyde, acids, chlorine, ethylene, oxide, isocyanates, strong oxidizers. XI. TOXICOLOGICAL INFORMATION Ethanol: XII. Inhalation LC50: 20000 ppm/10H, rat Irritation eye: 50mg/24H Severe, rabbit Acute Oral: LD50 7060 mg/kg, rat ECOLOGICAL INFORMATION Ethanol: XIII. Soil: readily biodegrades, quickly evaporates, leaches, into groundwater. Water: readily biodegrades evaporates at a moderate extent. Does not bioaccumulate. Air: readily degrades by reaction with photochemically hydroxyl radicals, readily removed by dry and wet deposition, has a half-life between 1 and 10 days. DISPOSAL CONSIDERATION Disposal Method – Dispose of in accordance with all applicable local, state, and federal regulations. RCRA Waste information - If this product becomes a waste, it would not be a hazardous waste (D001) as defined by RCRA (40 CFR 261). However, the waste should be properly characterized to evaluate whether its composition has been modified prior to disposal. XIV. TRANSPORATION INFORMATION DOT information – 49 CFR 172.101 Proper Shipping Description: Not Regulated Hazard Class: None Identification Number: None Packing Group: None Water Transportation: Proper Shipping Description: Not Regulated Hazard Class: None Identification Number: None Packing Group: None Air Transportation: Proper Shipping Description: Not Regulated Hazard Class: None Identification Number: None Packing Group: None Marine Pollutants: None XV. REGULATORY INFORMATION US Federal Regulations TSCA (Toxic Substances Control Act) Status All ingredients are on the TSCA inventory or are not required to be listed on the TSCAA inventory. CERCLA RQ – 40 CFR 302.4 (a) None listed SARA 313 Components – 40 CFR 372.65 None State and Local Regulations: California Proposition 65 WARNING! This product contains trace chemicals known to the State of California to cause cancer, and/or birth defects or other reproductive harm. XVI. ADDITIONAL INFORMATION The information is furnished without warranty or implied, except that is accurate to the best of our knowledge. The data on this sheet relates only to the specific material designed herein. NTE Electronics, Inc. assumes no legal responsibility for use or reliance upon these data.