P14SG-xxxxE/Z(Hxx)LF PM5-SERIES Rev.11-2008 3 Watt Regulated DIP24 Plastic Case 1 - 6 kV DC I/O Isolation Single and Dual Output Continuous Short Circuit Prot. Full SMD Technology Mainzer Straße 151–153 D-55299 Nackenheim Tel. +49 6135 7026-0 Fax: +49 6135 931070 www.peak-electronics.de [email protected] The PM5 series P14SG-xxxxE/Z(Hxx)LF is a family of cost effective 3 W single and dual output DC/DC converters. These converters are encapsulated in an ultra miniature DIP24 case. High performance features: 1000VDC, optional up to 6000VDC input/output isolation, high efficiency operation, output voltage accuracy of ±2% maximum, input range of ±10% tolerance and low output ripple and noise. All specifications typical at Ta=25°C, nominal input voltage and full load unless otherwise specified Input Specifications Voltage Range Input Filter Input Reflected Ripple Current¹ ± 10% Pi Type 35 mA pk-pk Output Specifications Voltage Accuracy Short Circuit Protection Line Regulation Load Regulation (0% - 100%) Ripple and Noise (20Mhz bandwidth) Temperature Coefficient ± 2% Indefinite (automatic recovery) ± 0.5% ± 0.5% (3.3Vout Models: ± 1.5%) 75 mV pk-pk ± 0.02% / °C General Specifications Efficiency I/O Isolation Voltage (3 sec.) I/O Isolation Capacity I/O Isolation Resistance Switching Frequency (typical) Humidity Reliability Calculated MTBF (MIL-HDBK-217F) See Table 1000 VDC (up to 6000 VDC optional)* 60 pF, typ. 1000 M Ohm 40 kHz (Single out); 250 kHz (Dual out) 95% rel H > 3.072 Mhrs Physical Specifications Case Material Potting Material Weight Non Conductive Black Plastic (UL94V-0 rated) Epoxy (UL94V-0 rated) ~ 12.5g, typ. Environment Specifications Operating Temperature Maximum Case Temperature Storage Temperature Cooling RoHS Conform -40 to +85°C (ambient) 100°C -40 to +125°C Free Air Convection Soldering 260°C, max. (1.5mm from case 10s.) PM5-Series – P14SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 1/3 Selection Guide Single/Dual Output Order # SINGLE OUTPUT P14SG-053R3ELF P14SG-0505ELF P14SG-0509ELF P14SG-0512ELF P14SG-0515ELF P14SG-0524ELF P14SG-123R3ELF P14SG-1205ELF P14SG-1209ELF P14SG-1212ELF P14SG-1215ELF P14SG-1224ELF P14SG-243R3ELF P14SG-2405ELF P14SG-2409ELF P14SG-2412ELF P14SG-2415ELF P14SG-2424ELF DUAL OUTPUT P14SG-053R3ZLF P14SG-0505ZLF P14SG-0509ZLF P14SG-0512ZLF P14SG-0515ZLF P14SG-0524ZLF P14SG-123R3ZLF P14SG-1205ZLF P14SG-1209ZLF P14SG-1212ZLF P14SG-1215ZLF P14SG-1224ZLF P14SG-243R3ZLF P14SG-2405ZLF P14SG-2409ZLF P14SG-2412ZLF P14SG-2415ZLF P14SG-2424ZLF ) ) A) mA (mA ad (m ad ( ) d o ² L a C ) o l o l L D C L u uF) (VD e (V Full No ) nt F ad ( g t t e e o a n n r % g t L r ( l e e a rr rr y lt or Vo Cu t Cu put Cu t Vo ienc acit pu t put Inpu Inpu In Out Out Effic Cap 5 5 5 5 5 5 12 12 12 12 12 12 24 24 24 24 24 24 120 120 120 120 120 120 50 50 50 50 50 50 25 25 25 25 25 25 720 923 882 845 845 937 284 384 357 352 342 367 142 192 181 173 173 178 3.3 5 9 12 15 24 3.3 5 9 12 15 24 3.3 5 9 12 15 24 600 600 333 250 200 125 600 600 333 250 200 125 600 600 333 250 200 125 55 65 68 71 71 64 58 65 70 71 73 68 58 65 69 72 72 70 470 470 470 470 470 470 470 470 470 470 470 470 470 470 470 470 470 470 5 5 5 5 5 5 12 12 12 12 12 12 24 24 24 24 24 24 30 30 40 40 40 60 15 15 25 25 25 25 15 15 15 15 15 25 825 909 882 857 857 869 326 333 320 312 320 328 157 162 160 156 160 164 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 400 ± 300 ± 167 ± 125 ± 100 ± 63 ± 400 ± 300 ± 167 ± 125 ± 100 ± 63 ± 400 ± 300 ± 167 ± 125 ± 100 ± 63 64 66 68 70 70 69 68 75 78 80 78 76 70 77 78 80 78 76 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 If you need other specifications, please enquire. *OPTIONS: H30 = 3000 VDC ISOLATION H40 = 4000 VDC ISOLATION H52 = 5200 VDC ISOLATION H60 = 6000 VDC ISOLATION For other I/O Isolation please see table on the left hand side and add “Hxx” before LF (P14SG-2412EH60LF for 6KV) PM5-Series – P14SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 2/3 0.25 (0.01) 20.32 (0.80) 15.24 (0.60) Package / Pinning / Derating # 1 2 3 10 11 12 13 14 15 22 23 24 SINGLE +Vin N.C. N.C. - Vout +Vout - Vin - Vin +Vout - Vout N.C. N.C. +Vin PIN CONNECTIONS DUAL SINGLE ≥3KV +Vin +Vin - Vout +Vin Common Omitted Common Omitted +Vout Omitted - Vin - Vout - Vin +Vout +Vout Omitted Common Omitted Common Omitted - Vout - Vin +Vin - Vin DUAL ≥3KV +Vin +Vin Omitted Common Common Omitted - Vout Omitted + Vout Omitted - Vin - Vin App Notes: ¹ = Measured Input reflected ripple current with a simulated source inductance of 12uH. ² = Tested by minimal Vin and constant resistive load. PM5-Series – P14SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 3/3