P8SG-xxxxE/Z(Hxx)LF PM5-SERIES Rev.11-2008 1.5 Watt Regulated DIP24 Plastic Case 1 - 6 kV DC I/O Isolation Single and Dual Output Continuous Short Circuit Prot. Full SMD Technology Mainzer Straße 151–153 D-55299 Nackenheim Tel. +49 6135 7026-0 Fax: +49 6135 931070 www.peak-electronics.de [email protected] The PM5 series P8SG-xxxxE/Z(Hxx)LF is a family of cost effective 1.5 W single and dual output DC/DC converters. These converters are encapsulated in an ultra miniature DIP24 case. High performance features: 1000VDC, optional up to 6000VDC input/output isolation, high efficiency operation, output voltage accuracy of ±2% maximum, input range of ±10% tolerance and low output ripple and noise. All specifications typical at Ta=25°C, nominal input voltage and full load unless otherwise specified Input Specifications Voltage Range Input Filter Input Reflected Ripple Current¹ ± 10% Pi Type 35 mA pk-pk Output Specifications Voltage Accuracy Short Circuit Protection Line Regulation Load Regulation (0% - 100%) Ripple and Noise (20Mhz bandwidth) Temperature Coefficient ± 2% Indefinite (automatic recovery) ± 0.5% ± 0.5% (3.3Vout Models: ± 1.5%) 75 mV pk-pk ± 0.02% / °C General Specifications Efficiency I/O Isolation Voltage (3 sec.) I/O Isolation Capacity I/O Isolation Resistance Switching Frequency (typical) Humidity Reliability Calculated MTBF (MIL-HDBK-217F) See Table 1000 VDC (up to 6000 VDC optional)* 60 pF, typ. 1000 M Ohm 40 kHz (Single out); 350 kHz (Dual out) 95% rel H > 3.072 Mhrs Physical Specifications Case Material Potting Material Weight Non Conductive Black Plastic (UL94V-0 rated) Epoxy (UL94V-0 rated) ~ 12.5g, typ. Environment Specifications Operating Temperature Maximum Case Temperature Storage Temperature Cooling RoHS Conform -40 to +85°C (ambient) 100°C -40 to +125°C Free Air Convection Soldering 260°C, max. (1.5mm from case 10s.) PM5-Series – P8SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 1/3 Selection Guide Single/Dual Output ) ) m A) (mA ad (mA ad ( ) o d L a C ) o L F)² D C Lo ull d (u (VD Full No e (V nt F ) a t t g e e o n n a r % g t L r ( l e e rr rr y l ta or Cu Vo t Cu put Cu t Vo ienc acit put put In p u In p u In O ut O ut E ffic Cap Order # SINGLE OUTPUT P8SG-053R3ELF P8SG-0505ELF P8SG-0509ELF P8SG-0512ELF P8SG-0515ELF P8SG-0524ELF P8SG-123R3ELF P8SG-1205ELF P8SG-1209ELF P8SG-1212ELF P8SG-1215ELF P8SG-1224ELF P8SG-243R3ELF P8SG-2405ELF P8SG-2409ELF P8SG-2412ELF P8SG-2415ELF P8SG-2424ELF DUAL OUTPUT P8SG-053R3ZLF P8SG-0505ZLF P8SG-0509ZLF P8SG-0512ZLF P8SG-0515ZLF P8SG-0524ZLF P8SG-123R3ZLF P8SG-1205ZLF P8SG-1209ZLF P8SG-1212ZLF P8SG-1215ZLF P8SG-1224ZLF P8SG-243R3ZLF P8SG-2405ZLF P8SG-2409ZLF P8SG-2412ZLF P8SG-2415ZLF P8SG-2424ZLF 5 5 5 5 5 5 12 12 12 12 12 12 24 24 24 24 24 24 50 50 50 50 50 50 40 40 40 40 40 40 35 35 35 35 35 35 517 454 468 441 441 461 203 189 186 178 195 201 103 100 97 93 94 94 3.3 5 9 12 15 24 3.3 5 9 12 15 24 3.3 5 9 12 15 24 400 300 167 125 100 62 400 300 167 125 100 62 400 300 167 125 100 62 51 66 64 68 68 65 54 66 67 70 64 62 53 62 64 67 66 66 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 220 5 5 5 5 5 5 12 12 12 12 12 12 24 24 24 24 24 24 50 50 50 50 50 50 35 35 35 35 35 35 15 15 15 15 15 15 440 461 447 428 447 454 171 183 178 166 173 176 83 89 85 80 83 84 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 3.3 ±5 ±9 ± 12 ± 15 ± 24 ± 200 ± 150 ± 83 ± 63 ± 50 ± 31 ± 200 ± 150 ± 83 ± 63 ± 50 ± 31 ± 200 ± 150 ± 83 ± 63 ± 50 ± 31 60 65 67 70 67 66 64 68 70 75 72 71 66 70 73 78 75 74 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 ± 1000 ± 1000 ± 470 ± 470 ± 470 ± 220 If you need other specifications, please enquire. *OPTIONS: H30 = 3000 VDC ISOLATION H40 = 4000 VDC ISOLATION H52 = 5200 VDC ISOLATION H60 = 6000 VDC ISOLATION For other I/O Isolation please see table on the left hand side and add “Hxx” before LF (P8SG-2412EH60LF for 6KV) PM5-Series – P8SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 2/3 0.25 (0.01) 20.32 (0.80) 15.24 (0.60) Package / Pinning / Derating # 1 2 3 10 11 12 13 14 15 22 23 24 SINGLE +Vin N.C. N.C. - Vout +Vout - Vin - Vin +Vout - Vout N.C. N.C. +Vin PIN CONNECTIONS DUAL SINGLE ≥3KV +Vin +Vin - Vout +Vin Common Omitted Common Omitted +Vout Omitted - Vin - Vout - Vin +Vout +Vout Omitted Common Omitted Common Omitted - Vout - Vin +Vin - Vin DUAL ≥3KV +Vin +Vin Omitted Common Common Omitted - Vout Omitted + Vout Omitted - Vin - Vin App Notes: ¹ = Measured Input reflected ripple current with a simulated source inductance of 12uH. ² = Tested by minimal Vin and constant resistive load. PM5-Series – P8SG-xxxxE/Z(Hxx)LF – Single and Dual Output – DIP24 - Plastic Case Specification can change without a notice – We accept no liability for any inaccuracy or printing errors. Page 3/3