UNISONIC TECHNOLOGIES CO., LTD UT136E Preliminary TRIAC TRIAC DESCRIPTION Passivated, sensitive gate triacs in a plastic envelope, suitable for surface mounting, intended for use in general purpose bidirectional switching and phase control applications, where high sensitivity is required in all four quadrants. SYMBOL ORDERING INFORMATION Ordering Number Lead Free Halogen Free UT136EL-x-TA3-T UT136EG-x-TA3-T UT136EL-x-TN3-R UT136EG-x-TN3-R UT136EL-x-TN3-T UT136EG-x-TN3-T www.unisonic.com.tw Copyright © 2011 Unisonic Technologies Co., Ltd Package TO-220 TO-252 TO-252 Pin Assignment 1 2 3 MT1 MT2 G MT1 MT2 G MT1 MT2 G Packing Tube Tape Reel Tube 1 of 3 QW-R401-017,F UT136E Preliminary TRIAC ABSOLUTE MAXIMUM RATINGS PARAMETER SYMBOL RATINGS UNIT UT136E-5 500 (Note 2) V Repetitive Peak Off-State Voltages UT136E-6 VDRM 600 (Note 2) V UT136E-8 800 V RMS On-State Current (full sine wave, TMB ≤107°C) IT(RMS) 4 A 25 A Non-Repetitive Peak On-State Current t =20ms ITSM (Full sine wave; TJ=25°C prior to surge) t =16.7ms 27 A I2t for fusing (t =10ms) I2t 3.1 A2 s 50 A/μs T2+ G+ Repetitive Rate of Rise ITM=6A, T2+ G50 A/μs of On-State Current IG=0.2A, dIT/dt T2- G50 A/μs After Triggering dIG/dt=0.2A/μs T2- G+ 10 A/μs Peak Gate Voltage VGM 5 V Peak Gate Current IGM 2 A Peak Gate Power PGM 5 W Average Gate Power (over any 20 ms period) PG(AV) 0.5 W Junction Temperature TJ 125 °C Storage Temperature TSTG -40 ~ +150 °C Note: 1. Absolute maximum ratings are those values beyond which the device could be permanently damaged. Absolute maximum ratings are stress ratings only and functional device operation is not implied. 2. Although not recommended, off-state voltages up to 800V may be applied without damage, but the traic may switch to the on-state. The rate of rise of current should not exceed 3A/μs. THERMAL DATA PARAMETER Junction to Ambient SYMBOL Pcb Mounted Junction to Mounting Base TO-220 TO-252 Full Cycle Half Cycle RATINGS 60 75 3.0 3.7 θJA θJB UNIT K/W K/W ELECTRICAL CHARACTERISTICS (TJ=25°C, unless otherwise specified) PARAMETER SYMBOL TEST CONDITIONS MIN TYP MAX UNIT STATIC T2+ G+ T2+ GT2- GT2- G+ T2+ G+ T2+ GT2- GT2- G+ Gate Trigger Current IGT VD=12V, IT=0.1A Latching Current IL VD=12V, IGT=0.1A Holding Current On-State Voltage IH VT Gate Trigger Voltage VGT VD=12V, IGT=0.1A IT=5A VD=12V, IT=0.1A VD=400V, IT=0.1A, TJ=125°C VD=VDRM(MAX), TJ=125°C Off-State Leakage Current DYNAMIC Critical Rate of Rise of Off-State Voltage Gate Controlled Turn-On Time ID dVD/dt tGT VDM=67%VDRM(max), TJ=125°C, exponential waveform; gate open circuit ITM=6A, VD=VDRM(MAX), IG=0.1A, dIG/dt=5A/μs UNISONIC TECHNOLOGIES CO., LTD www.unisonic.com.tw 0.25 2.5 4.0 5.0 11 3.0 10 2.5 4.0 2.2 1.4 0.7 0.4 0.1 10 10 10 25 15 20 15 20 15 1.7 1.5 0.5 mA mA mA mA mA mA mA mA mA V V V mA 50 V/μs 2 μs 2 of 3 QW-R401-017, F UT136E TRIAC TYPICAL CHARACTERISTICS IDRM vs. VDRM 8 IRRM vs. VRRM 5 4 IRRM (mA) 6 IDRM (µA) Preliminary 4 2 0 3 2 1 0 200 400 600 VDRM (V) 800 1000 0 0 200 400 600 800 VRRM (V) 1000 1200 IT vs. VT 6 5 4 3 2 1 0 0 500 1000 1500 VT (mV) 2000 2500 UTC assumes no responsibility for equipment failures that result from using products at values that exceed, even momentarily, rated values (such as maximum ratings, operating condition ranges, or other parameters) listed in products specifications of any and all UTC products described or contained herein. UTC products are not designed for use in life support appliances, devices or systems where malfunction of these products can be reasonably expected to result in personal injury. Reproduction in whole or in part is prohibited without the prior written consent of the copyright owner. The information presented in this document does not form part of any quotation or contract, is believed to be accurate and reliable and may be changed without notice. UNISONIC TECHNOLOGIES CO., LTD www.unisonic.com.tw 3 of 3 QW-R401-017, F