Telefon: +49 (0)6135 931069 Telefax: +49 (0)6135 931070 www.peak-electronics.de [email protected] PD10NG-XXXXZ2:1H30 3KV ISOLATED 2W REGULATED DUAL OUTPUT SIP8 Electrical Specifications (Typical at + 25℃ , nominal input voltage, rated output current unless otherwise specified) Input Specifions Voltage range Filter 4.5-9, 9-18, 18-36 and 36-72 VDC Wide lnput Capacitor type lsolation Specifications Rated voltage Resistance Capacitance 3000 VDC ＞1 GΩ 72PF Output Specifications Voltage accuracy Ripple and noise (at 20 MHz BW) Short circuit protection Line voltage regulation Load voltage regulation Temperature coefficient +/−2 %, typ. 100 mV p-p, max. Continuous, auto restart +/−0.2 % typ. +/−0.5 % typ. load = 10 ~ 100% +/−0.02 % / ℃ General Specifications Efficiency Switching frequency Continuous, auto restart 75 KHz, typ. Environmental Specifications Operating temperature (ambient) Storage temperature Humidity Cooling − 40 ℃ to + 80 ℃ − 55 ℃ to + 125 ℃ Up to 90 %, non condensing Free air convection Physical Characteristics Dimensions SIP Case material 21.80 x 9.20 x 11.10 mm Non conductive black plastic Samples of Partnumbers PART NO. INPUT VOLTAGE (VDC) INPUT CURRENT NO LOAD (mA) INPUT CURRENT FULL LOAD (mA) OUTPUT VOLTAGE (VDC) OUTPUT CURRENT (max.mA) EFFICIENCY FULL LOAD (% TYP.) PD10NG-053R3Z2:1H30 PD10NG-0505Z2:1H30 PD10NG-0509Z2:1H30 PD10NG-0512Z2:1H30 PD10NG-0515Z2:1H30 PD10NG-0524Z2:1H30 PD10NG-123R3Z2:1H30 PD10NG-1205Z2:1H30 PD10NG-1209Z2:1H30 PD10NG-1212Z2:1H30 PD10NG-1215Z2:1H30 PD10NG-1224Z2:1H30 PD10NG-243R3Z2:1H30 PD10NG-2405Z2:1H30 PD10NG-2409Z2:1H30 PD10NG-2412Z2:1H30 PD10NG-2415Z2:1H30 PD10NG-2424Z2:1H30 PD10NG-483R3Z2:1H30 PD10NG-4805Z2:1H30 PD10NG-4809Z2:1H30 PD10NG-4812Z2:1H30 PD10NG-4815Z2:1H30 PD10NG-4824Z2:1H30 4.5 - 9 4.5 - 9 4.5 - 9 4.5 - 9 4.5 - 9 4.5 - 9 9 - 18 9 - 18 9 - 18 9 - 18 9 - 18 9 - 18 18 - 36 18 - 36 18 - 36 18 - 36 18 - 36 18 - 36 36 - 72 36 - 72 36 - 72 36 - 72 36 - 72 36 - 72 41 37 37 35 35 35 24 23 22 22 22 22 12 12 12 12 12 11 8 6 7 6 6 6 487 473 467 442 442 442 237 227 213 213 213 213 117 109 108 109 107 106 58 54 53 52 52 52 +/− 3.3 +/− 5 +/− 9 +/− 12 +/− 15 +/− 24 +/− 3.3 +/− 5 +/− 9 +/− 12 +/− 15 +/− 24 +/− 3.3 +/− 5 +/− 9 +/− 12 +/− 15 +/− 24 +/− 3.3 +/− 5 +/− 9 +/− 12 +/− 15 +/− 24 ± 303 ± 200 ± 111 ± 83 ± 67 ± 42 ± 303 ± 200 ± 111 ± 83 ± 67 ± 42 ±303 ± 200 ±111 ± 83 ± 67 ± 42 ± 303 ± 200 ± 111 ± 83 ± 67 ±42 68 70 71 75 75 75 70 73 76 78 78 78 71 76 77 76 77 78 72 77 78 80 80 80 PD10NG-XXXXZ2:1H30 3KV ISOLATED 2W REGULATED DUAL OUTPUT SIP8 Dimensions 21,8 PEAK Modelcode 1 2 3 5 9,2 6 7 8 11,10 0.25± 0.05 3.20 typ. 0.50± 0.05 2.0± 0.50 3.10 typ. 0.50± 0.05 Recommended footprint details 2.54 typ. 2,54 XX.X± 0.5m/m XX.XX± 0.25m/m Unit : mm 1.0φ＋0.15 /－0 2,54 Derating Graph and Pinning Output Temperature Derating Graph Ambient Temperature C 2.00W Safe Operating Area Pin Connection # Dual 1 − V Input 2 + V Input 3 Ctrl 4 Omitted 5 NE 6 + V Output 7 − V Output 8 －40 0 40 80 100 Com Control input can be left open (3) No external connection allowed (5) PD10NG-XXXXZ2:1H30 3KV ISOLATED 2W REGULATED DUAL OUTPUT SIP8 External capacitance: Pin 3 (CTRL) These converters will work with without external capacitors but they are necessary in order to guarantee the full line load range. All parts have been tested using the following recommended values. Control pin (ON/OFF) Output starts at low or open and stops when high. Voltage applied via a limiting resistor and switching diode. The converter is in a low power mode during the high level phase. + Vout + Vin ＋ Cin ＋ Converter - Vin ＋ Connection example Cout 1 Com Cout 2 - Vout MCU 1K 1N4148 CONVERTER Vcc-5V PIN 3 Cin 10uF/100V, low ESR. Cout 1/ Cout 2 100uF/25V, low ESR. Pin 5 (NE) This pin is used internally and must have have no external connection. Application Notes Pin 3: The outside control connection. This pin provides the converter output ON/OFF, and the control common is referred to negative input. Pin 5: This pin belongs to the secondary side. It just avoids someone to reverses the primary and secondary. Specification can be changed without notice. REV: 1 / 03.2003 Copyright PEAK electronics GmbH