DC-DC PCB MOUNTED CONVERTERS & POWER MODULES MAH 36 Series 182 2 5 W AT T S - D C / D C S I N G L E & M U LT I O U T P U T FEATURES • • • • • • • 4:1 Input range Efficiency to 84% 200 kHz switching frequency 500 VDC isolation Six-sided shield metal case Remote ON/OFF control Regulated output SPECIFICATIONS TECHNICAL ILLUSTRATION INPUT Nominal voltage 12V, 24V, 48V. Voltage range 9-36V, 18-72V. Isolation 500VDC. Filter PI-type OUTPUT Power 25W and 30W. Regulation Line:Single, dual ±0.2%, triple ±1.0% Load:Single, dual ±1.0%, triple ±5.0%. 25% min load is required to meet specification. Load transient response <480µs. Setting accuracy Single:±1%. Dual:+output ±1%, -output ±3%. Triple:5V ±1%, 12/15V ±5%, -5V ±2%. Ripple and noise Max. 75 mVp-p. Short circuit protection Fold-back. Approx 80% of output current at short circuit. Temp coefficient ±0.02 %/°C. Efficiency 77% to 85%. ENVIRONMENTAL Operating temperature -25°C to +71°C. Storage temperature -55°C to +105°C. Cooling Convection. GENERAL MTTF 200 000 hours at 25°C ambient. Switching frequency Min. 250 kHz. Equivalent capacitance 1000 pF. Case Black coated copper with non-conductive base. Dimensions (H x W x L) 21.1 x 65.0 x 76.2 mm. Weight 180g. Doc. No. PBC9 Rev.C 28-4-11 MAH 36 Series SELECTION TABLE POWERBOX ARTICLE NUMBER INPUT VOLTAGE VDC OUTPUT VOLTAGE VDC OUTPUT CURRENT MA INPUT CURRENT NO LOAD MA INPUT CURRENT FULL LOAD MA MAH 36 003 9-36 5 5000 20 1350 MAH 36 006 9-36 12 2500 20 1560 MAH 36 009 9-36 15 2000 20 1560 MAH 36 012 9-36 ±12 1250 25 1560 MAH 36 015 9-36 ±15 1000 25 1560 MAH 36 018 9-36 5/±12 3000/625 25 1650 MAH 36 021 9-36 5/±15 3000/500 25 1650 MAH 36 024 9-36 +5/+12/-5 3000/600/1000 25 1450 MAH 36 027 18-72 5 5000 15 670 MAH 36 030 18-72 12 2500 15 770 MAH 36 033 18-72 15 2000 15 770 MAH 36 036 18-72 ±12 1250 20 750 MAH 36 039 18-72 ±15 1000 20 750 MAH 36 042 18-72 5/±12 3000/625 20 790 MAH 36 045 18-72 5/±15 3000/500 20 780 MAH 36 048 18-72 +5/+12/-5 3000/600/1000 20 725 PIN CONNECTION SINGLE OUTPUT DUAL OUTPUT TRIPLE OUTPUT 1 +V Input +V Input +V Input 2 - V Input -V Input -V Input 3 +Sense +V Output +V Output PIN 4 Output trim Common Common 5 -Sense -V Output -V Output 6 +V Output NP +5V Output 7 -V Output NP NP 8 NP = No pin. Doc. No. PBC9 Rev.C 28-4-11 Remote On/Off Control REMOTE ON/OFF CONTROL Logic compatibility CMOS or open collector TTL Output-On >5.5VDC or open circuit Output-Off <1.8VDC Shutdown idle current 10mA Input resistance 100K ohms (Ein 0 to 9VDC) Control common Referenced to input minus EXTERNAL OUTPUT TRIMMING Output may optionally be externally trimmed (±10%) with a fixed resistor or an external trimpot as shown. Powering Progress – www.powerbox.com.au DC-DC PCB MOUNTED CONVERTERS & POWER MODULES 2 5 W AT T S - D C / D C S I N G L E & M U LT I O U T P U T 183