miniature aluminum electrolytic capacitors

MINIATURE ALUMINUM ELECTROLYTIC CAPACITORS
LZ
Low Impedance, Long Life
Series
Low Impedance
Long Life
Solvent Proof
Operating temperature range of -40 ~ +105 C
Enabled high ripple current by a reduction of impedance at high frequency range
High reliability withstanding 10000 hours load life at 105 C
(6000 / 8000 hours for as specified below)
Complied to the RoHS directive
Item
Characteristics
Operating temperature range
-40 ~ +105 C
I = 0.01CV or 3 A whichever is greater (after 2 minutes)
I = 0.03CV or 4 A whichever is greater (after 1 minute)
20% at 120Hz, 20 C
Capacitance > 1000 F : tan increases by 0.02 for each 1000 F from below value.
Leakage current max.
Capacitance tolerance
Dissipation factor max.
(at 120Hz, 20 C)
Rated Voltage(V)
tan
6.3
0.22
10
0.19
16
0.16
Z-40 C / Z+20 C
3
Low temperature characteristics
(Impedance ratio at 120Hz)
25
0.14
35
0.12
50
0.10
Z-25 C / Z+20 C
2
After an application of DC bias voltage plus the rated AC ripple current for 10000 hours at 105 C.
The measurement shall meet the following limits. The DC voltage plus the peak AC voltage
combined must not exceed the rated voltage.
Less than specified value
Within 25% of initial value
Less than 200% of specified value
Leakage current
Capacitance change
tan
Load life
D
Life time
D 5, 6.3
6000 hours
D 8
8000 hours
D
10
10000 hours
After 1000 hours no load test, leakage current, capacitance and tan are same as load life value.
The measurement shall be performed at 20 C by the KS C IEC 60384 - 4
Shelf life (at 105 C)
Unit : mm
DRAWING
d0.05 Tinned copper-ply wire
D 0.5 max.
Insulating sleeve
P0.5
L
Safety vent
max.
15 min.
D
5
6.3
8
10
12.5
16
18
P
2.0
2.5
3.5
5.0
5.0
7.5
7.5
d
0.5
0.5
0.6
0.6
0.6
0.8
0.8
1.5
4 min.
2.0
6.3 up)
FREQUENCY COEFFICIENT OF PERMISSIBLE RIPPLE CURRENT
Frequency
120Hz
1kHz
10kHz
50kHz
100kHz
0.32
0.60
0.80
0.90
1.00
39 ~ 270
0.40
0.63
0.82
0.91
1.00
330 ~ 680
0.45
0.67
0.84
0.92
1.00
820 ~ 1800
0.50
0.70
0.86
0.93
1.00
0.60
0.75
0.88
0.94
1.00
F
~ 33
2200 ~
126
MINIATURE ALUMINUM ELECTROLYTIC CAPACITORS
LZ series
DIMENSIONS & MAXIMUM PERMISSIBLE RIPPLE CURRENT
WV
6.3
Item
Impedance
100kHz
(Ω)max.
DL
(mm)
F
10
Ripple
current
(mA rms)
105 C
100kHz
20 C
100kHz
(Ω)max.
DL
(mm)
16
Ripple
current
(mA rms)
105 C
100kHz
Impedance
20 C
47
100
150
220
330
470
5
5
6.3
6.3
6.3
8
11
11
11
11
11
11.5
0.600
0.600
0.300
0.300
0.300
0.140
300
345
345
345
540
540
5
5
6.3
6.3
8
8
11
11
11
11
11.5
11.5
0.600
0.600
0.300
0.300
0.250
0.200
300
345
345
345
608
630
680
10
12.5
0.105
945
10
12.5
0.105
945
820
10
12.5
0.105
945
1000
10
16
0.075
1250
1200
1500
1800
2200
2700
3300
3900
4700
5600
6800
8200
10
10
10
12.5
12.5
12.5
12.5
16
16
16
16
16
20
20
20
20
20
25
25
25
25
31.5
0.075
0.054
0.054
0.050
0.050
0.050
0.040
0.030
0.030
0.030
0.027
1500
1760
1760
1960
2250
2480
2480
3250
3570
3630
3700
10
8
10
10
10
10
10
10
12.5
12.5
12.5
16
16
16
16
18
16
20
12.5
16
20
16
20
20
20
25
25
25
25
25
31.5
35.5
0.075
0.105
0.105
0.075
0.054
0.075
0.054
0.054
0.050
0.040
0.040
0.030
0.030
0.030
0.027
0.025
945
945
945
1250
1650
1760
1760
1760
1960
2250
2480
2480
3250
3570
3630
3700
WV
25
Impedance
Item
DL
(mm)
(Ω)max.
20 C
100kHz
F
6.3
11
0.300
345
100
6.3
11
0.300
345
120
150
6.3
8
11
11.5
0.300
0.250
180
8
11.5
0.200
0.054
1760
20
20
20
25
25
25
25
31.5
0.054
0.050
0.050
0.040
0.040
0.030
0.030
0.027
1960
1960
2250
2480
2900
3250
3570
3630
10
12.5
12.5
12.5
12.5
16
16
16
(Ω)max.
(mm)
20 C
100kHz
50
Ripple
current
(mA rms)
105 C
100kHz
Impedance
(Ω)max.
DL
(mm)
20 C
100kHz
Ripple
current
(mA rms)
105 C
100kHz
5
5
5
6.3
6.3
8
11
11
11
11
11
11.5
8
8
10
8
10
8
10
10
20
0.064
1580
10
20
0.064
1870
3.000
1.800
1.800
1.000
0.700
0.500
160
240
292
450
450
490
11.5
0.300
724
11.5
12.5
20
12.5
20
16
0.200
0.120
0.120
0.120
0.120
0.075
950
979
1200
1190
1370
1370
11.5
0.190
945
0.160
345
8
10
8
10
10
11.5
12.5
15
16
16
0.190
0.105
0.120
0.085
0.085
945
945
945
1250
1330
10
20
0.054
1500
10
20
0.064
2050
1330
8
10
10
20
16
20
0.095
0.085
0.054
1430
1600
1760
12.5
20
0.050
2050
1700
12.5
20
0.050
1960
12.5
25
0.040
2410
20
20
25
0.054
1850
1760
10
12.5
10
2250
12.5
25
0.040
2410
0.050
2300
12.5
25
0.040
2350
16
20
0.040
2730
2350
2480
2480
2900
2900
3250
3570
3630
12.5
16
16
16
25
20
25
25
0.040
0.040
0.030
0.030
2480
2900
3250
3570
16
25
0.036
3010
31.5
0.027
3630
12.5
0.105
945
12.5
15
12.5
0.105
0.105
0.105
945
1250
1250
2700
3300
20
8
10
8
10
2200
10
345
10
1000
1200
1500
1800
300
345
540
540
945
945
945
1250
1760
1250
345
345
330
10
16
0.075
8
10
10
20
20
16
0.075
0.054
0.075
10
20
0.054
20
20
20
20
20
20
30
25
25
31.5
0.054
0.050
0.050
0.050
0.040
0.040
0.040
0.030
0.030
0.027
10
12.5
12.5
12.5
16
16
12.5
16
16
16
0.600
0.300
0.300
0.200
0.200
0.105
0.105
0.075
0.054
0.075
345
345
345
500
540
540
945
270
820
11
11
11
11.5
11.5
12.5
20
16
20
20
0.450
0.450
0.450
0.350
0.300
0.250
0.250
11.5
680
5
6.3
6.3
8
8
10
8
10
10
8
11
11
11
11
11.5
11.5
11.5
8
560
Impedance
DL
20 C
6.3
6.3
6.3
6.3
8
8
8
220
470
(mm)
16
MINIATURE TYPES
10
22
33
47
56
68
390
(Ω)max.
DL
35
Ripple
current
(mA rms)
105 C
100kHz
100kHz
Ripple
current
(mA rms)
105 C
100kHz
Impedance
127