8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Schematic 1 8 2 7 3 6 4 5 Features •Compliance Halogen Free . (Br <900 ppm ,Cl <900 ppm , Br+Cl < 1500 ppm) • High speed 10Mbit/s • 10kV/μs minimum commone mode transient immunity at VCM= 1KV (HCPL0611) • Guaranteed performance from -40 to 85℃ • Wide operating temperature range of -40°C to 100°C • Logic gate output • High isolation voltage between input and output (Viso=3750 V rms ) • Compliance with EU REACH • Pb free and RoHS compliant. • UL and cUL approved(No. E214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved • DEMKO approved • FIMKO approved A 0.1μF bypass capacitor must be *3 connected between pins 8 and 5 Pin Configuration 1, No Connection 2, Anode 3, Cathode 4. No Connection 5, Gnd 6, Vout 7, VE 8, VCC Description The EL0600, EL0601 and EL0611 devices each consists of an infrared emitting diode optically coupled to a high speed integrated photo detector logic gate with a strobable output. The devices are packaged in an 8-pin small outline package which conforms to the standard SO8 footprint. Applications • Ground loop elimination • LSTTL to TTL, LSTTL or 5 volt CMOS • Line receiver, data transmission • Data multiplexing • Switching power supplies • Pulse transformer replacement • Computer peripheral interface • High speed logic ground isolation Revision :5 © 1 Copyright LifecyclePhase: Truth Table (Positive Logic) Input H L H L H L Enable H H L L NC NC Output L H H H L H Date:2014-06-25 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue Release No: DPC-0000088 Rev.5 10:35:13.0 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Absolute Maximum Ratings (Ta=25℃) Parameter Symbol Rating Unit Forward current IF 20 mA Enable input voltage Not exceed VCC by more than 500mV VE 5.5 V Reverse voltage VR 5 V Power dissipation PD 40 mW Power dissipation PC 85 mW Enable input current IE 5 mA Output current IO 50 mA Output voltage VO 7.0 V Output Power Dissipation PO 100 mW VISO 3750 V rms Operating temperature TOPR -40 ~ +100 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Input Output Isolation voltage *1 Soldering temperature *2 Notes: *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3 & 4 are shorted together, and pins 5, 6, 7 & 8 are shorted together. *2 For 10 seconds. Revision :5 2 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Electrical Characteristics (Ta=-40 to 85°C unless specified otherwise) Input Symbol Min. Typ. Max. Unit Forward voltage VF - 1.4 1.8 V IF = 10mA Reverse voltage VR 5.0 - - V IR = 10μA VF/TA - -1.8 - mV/°C IF =10mA CIN - 60 - pF VF=0, f=1MHz Symbol Min Typ. Max. Unit Condition ICCH - - 10 mA ICCL - - 13 mA IEH - - -1.6 mA VE=2.0V, VCC=5.5V IEL - - -1.6 mA VE=0.5V, VCC=5.5V VEH 2.0 - - V IF=10mA, VCC=5.5V VEL - - 0.8 V IF=10mA, VCC=5.5V Parameter Temperature coefficient of forward voltage Input capacitance Condition Output Parameter High level supply current Low level supply current High level enable current Low level enable current High level enable voltage Low level enable *4 voltage IF=10mA, VE=0.5V, VCC=5.5V IF=0mA, VE=0.5V, VCC=5.5V Transfer Characteristics (Ta=-40 to 85°C unless specified otherwise) Parameter HIGH Level Output Current LOW Level Output Current Input Threshold Current Revision :5 3 Copyright © LifecyclePhase: Symbol Min Typ. Max. Unit IOH - - 100 uA VOL - - 0.6 V IFT - - 5 mA Condition VCC=5.5V, VO=5.5V, IF=250μA, VE=2.0V VCC = 5.5V, IF=5mA, VE=2.0V,ICL=13mA VCC= 5.5V, VO=0.6V, VE =2.0V,IOL=13mA Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Switching Characteristics (Ta=-40 to 85°C, VCC=5V, IF=7.5mA unless specified otherwise) Parameter Propagation delay time to output High 5 level* (Fig.12) Propagation delay time to output Low 6 level* (Fig.12) Pulse width distortion Symbol Min Typ. Max. Unit Condition TPHL - 35 75 ns CL = 15pF, RL=350Ω, TA=25°C TPLH - 45 75 ns CL = 15pF, RL=350Ω, TA=25°C |Tphl – Tplh| - 10 35 ns CL = 15pF, RL=350Ω tr - 30 40 ns CL = 15pF, RL=350Ω tf - 10 20 ns CL = 15pF, RL=350Ω 7 Output rise time* (Fig.12) 8 Output fall time* (Fig.12) Switching Characteristics (Ta=-40 to 85°C, VCC=5V, IF=7.5mA unless specified otherwise) Symbol Min Typ. Max. Unit Condition tELH - 30 40 ns IF = 7.5mA , VEH=3.5V, CL = 15pF, RL=350Ω tEHL - 20 30 ns IF = 7.5mA , VEH=3.5V, CL = 15pF, RL=350Ω EL0600 - - - EL0601 5,000 - - Parameter Enable Propagation Delay Time to Output 9 High Level* (Fig.13) Enable Propagation Delay Time to Output 10 Low Level* (Fig.13) Common Mode Transient Immunity at Logic *11 High Common Mode Transient Immunity at Logic *12 Low Revision :5 4 Copyright © LifecyclePhase: V/µS CMH EL0611 10,000 - - EL0611 15,000 - - EL0600 - - - EL0601 5,000 V/µS CML EL0611 10,000 - - EL0611 15,000 - - IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=10Vp-p (Fig.14) IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=50Vp-p (Fig.14) IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=400Vp-p (Fig.14) IF = 7.5mA , VOH=2.0V, RL=350Ω, TA=25°C VCM=400Vp-p (Fig.15) IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=10Vp-p (Fig.14) IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=50Vp-p (Fig.14) IF = 0mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=400Vp-p (Fig.14) IF = 7.5mA , VOL=0.8V, RL=350Ω, TA=25°C VCM=400Vp-p (Fig.15) Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Typical Electro-Optical Characteristics Curves Revision :5 5 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Revision :5 6 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Fig. 12 Test circuit and waveforms for tPHL, tPLH, tr, and tf IF=3.75mA Input (IF) Ω IF=7.5mA tPHL tPLH Output (Vo) 1.5V 90% Output (Vo) Ω 10% tf tr Fig. 13 Test circuit and waveform for tEHLand tELH Ω 3.0V Input (VE) 1.5V tEHL tELH Output (Vo) 1.5V Revision :5 7 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Fig. 14 Test circuit Common mode Transient Immunity Ω Peak VCM 0V 5V Vo CMH Switching Pos. (A), IF=0 VO(Min) VO(Max) Switching Pos. (B), IF=7.5mA VCM CML 0.5V Fig. 15 Recommended drive circuit for EL0611 families for high-CMR μ Ω Revision :5 8 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Notes *3 The VCC supply must be bypassed by a 0.1μF capacitor or larger. This can be either a ceramic or solid tantalum capacitor with good high frequency characteristic and should be connected as close as possible to the package VCC and GND pins *4. Enable Input – No pull up resistor required as the device has an internal pull up resistor. *5. tPLH– Propagation delay is measured from the 3.75mA level on the HIGH to LOW transition of the input current pulse to the 1.5 V level on the LOW to HIGH transition of the output voltage pulse. *6. tPHL– Propagation delay is measured from the 3.75mA level on the LOW to HIGH transition of the input current pulse to the 1.5 V level on the HIGH to LOW transition of the output voltage pulse. *7. tr– Rise time is measured from the 90% to the 10% levels on the LOW to HIGH transition of the output pulse. *8. tf– Fall time is measured from the 10% to the 90% levels on the HIGH to LOW transition of the output pulse. *9. tELH– Enable input propagation delay is measured from the 1.5V level on the HIGH to LOW transition of the input voltage pulse to the 1.5V level on the LOW to HIGH transition of the output voltage pulse. *10. tEHL– Enable input propagation delay is measured from the 1.5V level on the LOW to HIGH transition of the input voltage pulse to the 1.5V level on the HIGH to LOW transition of the output voltage pulse. *11 CMH– The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the HIGH state (i.e., VOUT > 2.0V). *12 CML– The maximum tolerable rate of rise of the common mode voltage to ensure the output will remain in the LOW output state (i.e., VOUT < 0.8V). Order Information Part Number EL06XX(Z)-V Note X = Part no. ( X = 00, 01 or 11) Z = Tape and reel option (TA, TB or none). V = VDE (optional) Option None -V Standard Standard + VDE Packing quantity 100 units per tube 100 units per tube (TA) TA tape & reel option 2000 units per reel (TB) TB tape & reel option 2000 units per reel (TA)-V TA tape & reel option + VDE 2000 units per reel (TB)-V TB tape & reel option + VDE 2000 units per reel Revision :5 9 Copyright © LifecyclePhase: Description Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Package Dimension (Dimensions in mm) Recommended pad layout for surface mount leadform Revision :5 10 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Device Marking EL 0600 YWWV Notes EL 0600 Y WW V denotes EVERLIGHT denotes Device Number denotes 1 digit Year code denotes 2 digit Week code denotes VDE (optional) Revision :5 11 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Tape & Reel Packing Specifications Option TB Option TA Direction of feed from reel Direction of feed from reel Tape dimension Dimension No. A0 A1 B0 D0 D1 E F Dimension(mm) 6.2±0.1 4.1±0.1 5.28±0.1 1.5±0.1 1.5±0.3 1.75±0.1 5.5±0.1 Dimension No. Po P1 P2 t W K0 K1 Dimension(mm) 4.0±0.1 8.0±0.1 2.0±0.1 0.4±0.1 3.7±0.1 0.3±0.1 Revision :5 12 Copyright © LifecyclePhase: 12.0+0.3/ -0.1 Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series Precautions for Use 1. Soldering Condition 1.1 (A) Maximum Body Case Temperature Profile for evaluation of Reflow Profile Note: Reference: IPC/JEDEC J-STD-020D Preheat Temperature min (Tsmin) 150 °C Temperature max (Tsmax) 200°C Time (Tsmin to Tsmax) (ts) Average ramp-up rate (Tsmax to Tp) 60-120 seconds 3 °C/second max Other Liquidus Temperature (TL) 217 °C Time above Liquidus Temperature (t L) 60-100 sec Peak Temperature (TP) 260°C Time within 5 °C of Actual Peak Temperature: TP - 5°C 30 s Ramp- Down Rate from Peak Temperature 6°C /second max. Time 25°C to peak temperature Reflow times 8 minutes max. 3 times Revision :5 13 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever DATASHEET 8 PIN SOP HIGH SPEED 10MBit/s LOGIC GATE PHOTOCOUPLER EL06XX series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Revision :5 14 Copyright © LifecyclePhase: Release Date:2014-06-25 10:35:13.0 2010, Everlight All Rights Reserved. Release Date : May 13, 2013. Issue No:DPC-0000088 Rev.5 www.everlight.com Expired Period: Forever