DP500IP Series 7 2 0 - 8 2 8 W A T T S H I G H S U R G E A C / D C S U P P LY FEATURES • • • • • • • • • • • 720W - 828W Water Resistant IP67 Very high transient robustness High Surge Current Ideal for Motors and Pumps Extensive protection Very low standby power No Inrush Current Active PFC High Operating temperature Chassis Mounting SPECIFICATIONS INPUT OPERATING Input voltage range 85 - 276Vac Frequency 45-65Hz Power factor Input Current > 0.98 T10A / 250V Internal Additional external fuse is not necessary Max 3.5A @ 230Vac at nominal load Transient voltage Varistor (4.5kA/120J) Input Fuse protection Inrush current Signals Green LED 'DC OK' Blinking, DC not ok Efficiency 93% Isolation Input/Output + Chassis 3kVac Output/Chassis: 500Vdc MTBF >1,000,000h, IEC1709 (SN 29 500) STANDARDS No inrush current, (active regulated limitation) OUTPUT Electrical safety EN60950, EN50178, GOST EMC EN55011 Class B, EN61000-6-2 Current Harmonics EN61000-3-2 Output voltage 12Vdc, 13.8Vdc, 24Vdc, See Selection Table HF-Emission EN55011 Class B Immunity EN61000-6-2 Output current See Selection Table Insulation voltage EN60950 Output current See Selection Table MECHANICAL Current Limiting 150% for 5s power boost Dimensions 185 x 56 x 134mm , See Technical Illustrations Typ. < 2W Degree of protection IP67 Start with capacitive loading No limit Input Connector Cable without connector plug (length 1m), 3-pole (L, N, PE) Conductor cross section 1,5 mm² (AWG16) Voltage Tolerance +/-1% over range Turn on delay < 1 sec Ripple and Noise <150mVpp Output Connector Line regulation <0.2% (typ.0.02%) Cable without connector plug (length 1m), @ 24V 2-pole - black (GND), white (+) Ø AWG 12 (3,3mm²) @ 12V 2-pole - black (GND), red (+) Ø 6mm² Load regulation <0.5% Rise Time <50ms No load power consumption ENVIRONMENTAL 1 Operating temperature -25˚C...+85˚C (55...85˚C:Derating 1.5%/˚C) Humidity 100% Over temperature Protective shut down, self reset after cool down Cooling Cooling via contact to mounting surface Max altitude 4000m Formation of ice Allowed Doc. No. DP500IP Series Rev.A 23-9-15 DP500IP Series 7 2 0 - 8 2 8 W A T T S H I G H S U R G E A C / D C S U P P LY SELECTION TABLE MODEL NUMBER OUTPUT VOLTAGE OUTPUT CURRENT PEAK CURRENT POWER DP500IP-12 12VDC 40A 60A 720W DP500IP-13.8 13.8VDC 40A 60A 828W DP500IP-24 24VDC 20A 30A 720W TECHNICAL ILLUSTRATIONS Doc. No. DP500IP Series Rev.A 23-9-15 Powering Progress – www.powerbox.com.au 2