5 4 3 2 1 Table of Contents 2 3 4 Revisions Notes Schematic - OSJTAG Schematic - MCU Rev Description Date A Original Release DATE Approved DESIGNER D D C C B B Microcontroller Solutions Group A A 6501 William Cannon Drive West Austin, TX 78735-8598 This document contains information proprietary to Freescale Semiconductor and shall not be used for engineering design, procurement or manufacture in whole or in part without the express written permission of Freescale Semiconductor. ICAP Classification: FCP: ____ FIUO: X PUBI: ____ Drawing Title: Designer: DESIGNER TRK-USB-MPC5602P 5 4 3 2 Drawn by: DRAWN_BY Page Title: Approved: APPROVER Size C Document Number Date: Thursday, October 06, 2011 TITLE PAGE Rev C SCH-27263 PDF: SPF-27263 Sheet 1 1 of 4 5 4 3 2 1 1. Unless Otherwise Specified: All resistors are in ohms, 5%, 1/16 Watt, Size 0402 All ceramic capacitors are in uF, 20%, 50V, Size 0402 All voltages are DC All polarized capacitors are Tantalum 2. Interrupted lines coded with the same letter or letter combinations are electrically connected. D D 3. Device type number is for reference only. The number varies with the manufacturer. 4. Special signal usage: _B Denotes - Active-Low Signal <> or [] Denotes - Vectored Signals 5. Interpret diagram in accordance with American National Standards Institute specifications, current revision, with the exception of logic block symbology. C C B B A A ICAP Classification: Drawing Title: FCP: ___ FIUO: X PUBI: ___ TRK-USB-MPC5602P Page Title: NOTES 5 4 3 2 Size C Document Number Date: Thursday, October 06, 2011 Rev C SCH-27263 PDF: SPF-27263 1 Sheet 2 of 4 5 4 3 2 1 P5V U8 NC7WZ04P6X D 1 JM15_PE7_OUT 2 R32 10k 3 JM34_PG2_OUT A1 GND JM15_PE7 5 VCC A2 D 6 Y1 Y2 4 VCC 2G 1Y 2A 8 7 6 5 JM34_PG2 VCC + U2 C1 4.7UF P5V A1 A2 A3 A4 R3 R5 10k 33 2 USB_PWR D1 A A 1 3 5 C JM30_PD1 2 4 6 HDR 2X3 1 C JM29_PD0 JM29_PD0 JM30_PD1 JM33_PD2 JM2_IRQ JM_~RESET JM_BKGD JM2_IRQ TGT_PWR D2 R2 1K R6 4.7K J2 R7 10k LED_GREEN 40 41 42 43 1 44 VCC VCC R1 1K JM40_PC0 JM41_PC1 JM42_PC2 JM43_PC3 JM1_PC4 JM44_PC5 PTB0/MISO2/ADP0 PTB1/MOSI2/ADP1 PTB2/SPSCK2/ADP2 PTB3/SS2/ADP3 PTB4/KBIP4/ADP4 PTB5/KBIP5/ADP5 29 30 33 2 3 36 C6 0.1uF 8 9 10 11 12 13 14 15 JM8_PE0 JM9_PE1 JM10_PE2 JM11_PE3 JM12_PE4 JM13_PE5 JM14_PE6 JM15_PE7_OUT 4 5 6 7 JM4_PF0 JM5_PF1 JM6_PF4 JM7_PF5 1 2 3 4 R39 4.7K JM14_PE6 JM11_PE3 MCU_TDI 1G 1A 2Y GND MCU_TCK JM13_PE5 SN74LVC2G125 P5V U7 PTF0/TPM1CH2 PTF1/TPM1CH3 PTF4/TPM2CH0 PTF5/TPM2CH1 PTD0/ADP8/ACMP+ PTD1/ADP9/ACMPPTD2/KBIP2/ACMPO IRQ/TPMCLK RESET BKGD/MS VCC HDR 1X2 TH J3 MC9S08JM60CLD C11 PORT_RXD 1 2 3 4 JM26_PB3 PORT_RXD PTG0/KBIP0 PTG1/KBIP1 PTG2/KBIP6 PTG3/KBIP7 PTG4/XTAL PTG5/EXTAL VUSB33 USBDN USBDP 21 22 34 35 37 38 JM21_PG0 JM22_PG1 JM34_PG2_OUT JM35_PG3 JM37_PG4 JM38_PG5 20 18 19 VUSB33 USBDN USBDP R8 10M Y1 4MHz 1G 1A 2Y GND 8 7 6 5 VCC 2G 1Y 2A MCU_TMS JM8_PE0 SN74LVC2G125 18PF C P5V U6 C10 1 2 3 4 JM10_PE2 18PF 1G 1A 2Y GND 8 7 6 5 VCC 2G 1Y 2A MCU_JCOMP SN74LVC2G125 + C2 10UF C3 0.1uF P5V_ENABLED U5A 1 14 2 LED_YELLOW PTC0/SCL PTC1/SDA PTC2 PTC3/TxD2 PTC4 PTC5/RxD2 P5V U10 PTE0/TxD1 PTE1/RxD1 PTE2/TPM1CH0 PTE3/TPM1CH1 PTE4/MISO1 PTE5/MOSI1 PTE6/SPSCK1 PTE7/SS1 2 1 JM1_PC4 SP0503B C VCC 23 24 25 26 27 28 R4 33 2 U1 3 USBDN USBDP 4 FB1 26OHM JM23_PB0 JM24_PB1 JM25_PB2 JM26_PB3 JM27_PB4 JM28_PB5 1 C5 0.1uF 31 16 C4 0.01UF S1 VSSAD/VREFL VSS1 VSSOSC V C7 0.01UF 32 17 39 D- 1 D+ VDDAD/VREFH VDD1 26OHM J4 G C8 0.1uF 2 USB_TYPE_A_MALE S2 + C9 10UF VCC FB2 1 VCC 2 MCU_TDO 3 R28 10k DNI R30 10k R36 10k Board Rev JM42_PC2 R35 100K DNI Board ID JM27_PB4 JM41_PC1 JM25_PB2 74HCT125 U5B 4 R27 10k DNI JM12_PE4 GND 7 VCC 5 MCU_RESET 6 JM33_PD2 JM40_PC0 B B 74HCT125 R29 10k R31 10k DNI R33 3.3K R34 0 P5V U5C 10 R25 10k R20 10k R23 10k R21 10k C35 0.1uF C36 0.01UF 9 MCU_RDY R17 10k 8 P5V JM24_PB1 4 7 6 ENA J5 FLGA ENB FLGB IN OUTA GND OUTB 2 JM22_PG1 3 JM21_PG0 8 P5V_ENABLED JM43_PC3 74HCT125 U9 JM23_PB0 1 MCU_TDI MCU_TDO MCU_TCK MCU_RESET 5 MCU_RDY 1 3 5 7 9 11 13 MCU_TDI MCU_TDO MCU_TCK MCU_RESET MCU_RDY MIC2026-1YM P5V 2 4 6 8 10 12 14 R24 10k MCU_TMS MCU_JCOMP MCU_TMS PORT_TXD U5D 13 VCC R22 10k 12 PORT_TXD 11 JM9_PE1 MCU_JCOMP HDR 2X7 74HCT125 R38 10k R37 10k A A ICAP Classification: Drawing Title: FCP: ___ FIUO: X PUBI: ___ TRK-USB-MPC5602P Page Title: Schematic - OSJTAG 5 4 3 2 Size C Document Number Date: Thursday, October 06, 2011 Rev C SCH-27263 PDF: SPF-27263 1 Sheet 3 of 4 5 4 FB6 P5V VDDA 1 3 P5V P5V 2 P5V 1 P5V 2 C16 0.1uF 26OHM + C45 10UF C26 0.1uF C18 470pF C31 0.1uF C27 470pF C23 0.1uF C32 470pF C22 470pF C46 0.01UF FB5 1 D 2 P1_2V P1_2V P1_2V P1_2V D P3_3V P5V 26OHM VSSA + C12 10UF C13 0.22uF + C25 10UF C24 0.22uF + C34 10UF C33 0.22uF + C21 10UF P5V P3_3V C20 0.22uF J1A P5V C28 0.1uF 2 4 BCTRL 1 P5V Q2 BCP68 C B 3 J6 C19 470pF PORT_TXD P5V C17 0.1uF C29 0.1uF P1_2V P5V 1 2 C30 470pF P5V PORT_RXD VDDA HDR_1X3 0.1uF R11 0 MMBT3904LT1G 1 JM1_PC4 10k R13 Q1 C39 0.1uF 2 JM1_PC4 10k 3 R9 C15 MCU_RESET MCU_RESET 1 VSS_HV_OSC 10PF Y2 8MHz MCU_JCOMP B[0]/CAN0_TXD/ETIMER1_ETC[2]/SSCM_DEBUG[0]/IRQ15 B[1]/CAN0_RXD/ETIMER1_ETC[3]/SSCM_DEBUG[1]/IRQ16 B[2]/LIN0_TXD/SSCM_DEBUG[2]/IRQ17 B[3]/LIN0_RXD/SSCM_DEBUG[3] B[6]/CLKOUT/DSPI2_CS2/IRQ18 BCTRL C[10]/DSPI2_CS2/FLEXPWM0_FAULT[1]/FLEXPWM0_A[3] C[11]/ETIMER0_ETC[4]/DSPI2_CS2/DSPI3_CS0 C[12]/ETIMER0_ETC[5]/DSPI2_CS3/DSPI3_CS1 C[13]/ETIMER1_ETC[1]/CTU0_EXT_IN/FLEXPWM0_EXT-SYNC C[14]/ETIMER1_ETC[2]/CTU0_EXT_TGR C[15]/FLEXRAY0_CA_TR_EN/ETIMER1_ETC[0]/FLEXPWM0_A[1]/CTU0_EXT_IN/FLEXPWM0_EXT-SYNC C[6]/DSPI0_SOUT/FLEXPWM0_B[1]/SSCM_DEBUG[6]/IRQ24 C[8]/DSPI1_CS1/FLEXPWM0_FAULT[2]/DSPI0_CS6 C[9]/DSPI2_CS3/FLEXPWM0_FAULT[2]/FLEXPWM0_X[3] D[0]/FLEXRAY0_CA_TX/ETIMER1_ETC[1]/FLEXPWM0_B[1] D[10]/FLEXPWM0_A[0]/DSPI3_CS0 D[11]/FLEXPWM0_B[0]/DSPI3_CS1/DSPI3_SCK D[12]/FLEXPWM0_X[1]/LIN1_RXD D[13]/FLEXPWM0_A[1]/DSPI3_CS2/DSPI3_SOUT D[14]/FLEXPWM0_B[1]/DSPI3_CS3/DSPI3_SIN D[2]/FLEXRAY0_CB_RX/ETIMER1_ETC[3]/FLEXPWM0_X[3] D[3]/FLEXRAY0_CB_TX/ETIMER1_ETC[4]/FLEXPWM0_A[3] D[4]/FLEXRAY0_CB_TR_EN/ETIMER1_ETC[5]/FLEXPWM0_B[3] DSPI0_CS2/DSPI3_SCK/FLEXPWM0_FAULT[1]/D[6] DSPI0_CS3/FCU0_F[0]/DSPI3_SOUT/D[5] DSPI1_CS2/FLEXPWM0_FAULT[3]/DSPI0_CS5/D[8] DSPI1_CS3/FCU0_F[1]/DSPI3_SIN/DSPI0_CS4/D[7] IRQ20/ADC1_AN[2]/B[15] IRQ21/DSPI0_CS1/ETIMER1_ETC[4]/LIN1_TXD/C[3] IRQ22/SSCM_DEBUG[4]/DSPI0_CS0/FLEXPWM0_X[1]/C[4] IRQ23/SSCM_DEBUG[5]/DSPI0_SCK/FLEXPWM0_FAULT[3]/C[5] IRQ5/DSPI1_CS0/ETIMER1_ETC[5]/DSPI0_CS7/A[5] IRQ6/DSPI1_SCK/A[6] IRQ7/DSPI1_SOUT/A[7] IRQ8/DSPI1_SIN/A[8] MCU_JCOMP 2 R26 10k VSSA 10PF 1 B 76 77 79 80 96 47 78 55 56 71 72 85 98 91 84 86 53 54 70 67 73 97 89 90 23 22 21 26 43 10 5 7 8 2 4 6 CAN0_TXD CAN0_RXD TXD RXD IRQ18_PTB6 BCTRL FLEXPWM0_A3 ETIMER0_ETC4 ETIMER0_ETC5 ETIMER1_ETC1 GPIO_PTA4 GPIO_PTA9 GPIO_PTB9 ADC1_AN5 ADC1_AN4 ADC1_AN1 ADC1_AN0 ETIMER1_ETC0 DSPI0_SOUT DSPI1_CS1 FLEXPWM0_X3 GPIO_PTD0 FLEXPWM0_A0 FLEXPWM0_B0 FLEXPWM0_X1 FLEXPWM0_A1 FLEXPWM0_B1 PD2 PD3 FLEXPWM0_B3 PD6 PD5 GPIO_PTD8 PD7 IRQ20_PTB15 DSPI0_CS1 DSPI0_CS0 DSPI0_SCK DSPI1_CS0 DSPI1_SCK DSPI1_SOUT DSPI1_SIN ETIMER0_ETC3 ETIMER0_ETC2 GPIO_PTB10 FLEXPWM0_X3 FLEXPWM0_B3 FLEXPWM0_A3 FLEXPWM0_X1 CAN0_RXD CAN0_TXD DSPI0_SIN DSPI0_SOUT DSPI0_CS0 DSPI0_CS1 DSPI0_SCK GPIO_PTB11 IRQ20_PTB15 IRQ18_PTB6 IRQ14_PTA15 IRQ13_PTA14 IRQ12_PTA13 IRQ11_PTA12 IRQ10_PTA11 IRQ9_PTA10 PPC5604PEFF0MLL Replace with PPC5602PEF0MLL VSS_HV_OSC C14 VSS_HV_OSC A[0]/ETIMER0_ETC[0]/DSPI2_SCK/FCU0_F[0]/IRQ0 A[1]/ETIMER0_ETC[1]/DSPI2_SOUT/FCU0_F[1]/SSCM/IRQ1 A[10]/DSPI2_CS0/FLEXPWM0_B[0]/FLEXPWM0_X[2]/IRQ9 A[11]/DSPI2_SCK/FLEXPWM0_A[0]/FLEXPWM0_A[2]/IRQ10 A[12]/DSPI2_SOUT/FLEXPWM0_A[2]/FLEXPWM0_B[2]/IRQ11 A[13]/DSPI2_SIN/FLEXPWM0_B[2]/FLEXPWM0_FAULT[0]/IRQ12 A[14]/SAFETYPORT0_TXD/ETIMER1_ETC[4]/IRQ13 A[15]/SAFETYPORT0_RXD/ETIMER1_ETC[5]/IRQ14 A[2]/ETIMER0_ETC[2]/DSPI2_SIN/FLEXPWM0_A[3]/ABS[0]/IRQ2 A[3]/ETIMER0_ETC[3]/DSPI2_CS0/FLEXPWM0_B[3]/ABS[1]/IRQ3 A[4]/ETIMER1_ETC[0]/DSPI2_CS1/ETIMER0_ETC[4]/FAB/IRQ4 A[9]/DSPI2_CS1/FLEXPWM0_FAULT[0]/FLEXPWM0_B[3] ADC0_AN[0]/LIN0_RXD/B[7] ADC0_AN[1]/ETIMER0_ETC[5]/B[8] ADC0_AN[2]/C[1] ADC0_AN[3]/C[2] ADC0_AN[4]/E[1] ADC0_AN[5]/E[2] ADC0-ADC1_AN[11]/B[9] ADC0-ADC1_AN[12]/B[10] ADC0-ADC1_AN[13]/B[11] ADC0-ADC1_AN[14]/B[12] ADC1_AN[0]/LIN1_RXD/B[13] ADC1_AN[1]/ETIMER0_ETC[4]/B[14] ADC1_AN[3]/C[0] ADC1_AN[4]/D[15] ADC1_AN[5]/E[0] FLEXPWM0_X[0]/LIN1_TXD/D[9] FLEXRAY0_CA_RX/ETIMER1_ETC[2]/CTU0_EXT_TRG/D[1] SSCM_DEBUG[7]/DSPI0_SIN/FLEXPWM0_A[1]/C[7] JTAG0_TCK JTAG0_TDI JTAG0_TDO JTAG0_TMS NMI RESET EXTAL XTAL VSS_HV_AD0 VSS_HV_AD1 VSS_HV_FL VSS_HV_IO1 VSS_HV_IO2 VSS_HV_IO3 VSS_HV_OSC VSS_LV_COR0 VSS_LV_COR1 VSS_LV_COR2 VSS_LV_COR3 VSS_LV_REGCOR D3 RED LED R10 10k 3 C40 A P5V 4 C 2 SW1 51 52 81 82 83 95 99 100 57 64 75 94 29 31 28 30 27 32 35 36 37 38 42 44 45 41 46 15 3 9 60 58 61 59 1 20 19 18 ETIMER0_ETC0 ETIMER0_ETC1 IRQ9_PTA10 IRQ10_PTA11 IRQ11_PTA12 IRQ12_PTA13 IRQ13_PTA14 IRQ14_PTA15 ETIMER0_ETC2 ETIMER0_ETC3 GPIO_PTA4 GPIO_PTA9 ADC0_AN0 ADC0_AN1 GPIO_PTC1 GPIO_PTC2 ADC0_AN4 ADC0_AN5 GPIO_PTB9 GPIO_PTB10 GPIO_PTB11 GPIO_PTB12 ADC1_AN0 ADC1_AN1 GPIO_PTC0 ADC1_AN4 ADC1_AN5 GPIO_PTD9 GPIO_PTD1 DSPI0_SIN MCU_TCK MCU_TCK MCU_TDI MCU_TDI MCU_TDO MCU_TDO MCU_TMS MCU_TMS VPP_TEST VDD_LV_REGCOR VDD_LV_COR3 VDD_LV_COR2 VDD_LV_COR1 VDD_LV_COR0 VDD_HV_REG VDD_HV_OSC VDD_HV_IO3 VDD_HV_IO2 VDD_HV_IO1 VDD_HV_FL VDD_HV_AD1 VDD_HV_AD0 74 48 25 92 65 12 50 16 87 63 13 69 39 33 U3 34 40 68 14 62 88 17 11 66 93 24 49 R14 1K LIGHT TOUCH PUSH BUTTON PORT_RXD 1 2 RXD 3 LIN0_RXD C44 0.1uF P5V DSPI1_SCK DSPI1_CS1 DSPI1_CS0 DSPI1_SOUT DSPI1_SIN HDR_1X3 J7 Replace with real P1_2V/FCL_POWER C43 0.01UF 26OHM P1_2V 1 1 2 3 E FB4 C PORT_TXD TXD LIN0_TXD FB3 26OHM P5V LIGHT TOUCH PUSH BUTTON D5 A C PD5 1 LED_YELLOW R19 1K D6 A C 2 R15 1K PD6 2 SW2 C41 4 P5V R16 10k 3 B1 B2 B3 B4 B5 B6 B7 B8 B9 B10 B11 B12 B13 B14 B15 B16 B17 B18 B19 B20 B21 B22 B23 B24 B25 B26 B27 B28 B29 B30 B31 B32 B33 B34 B35 B36 B37 B38 B39 B40 B41 B42 B43 B44 B45 B46 B47 B48 B49 B50 B51 B52 B53 B54 B55 B56 B57 B58 B59 B60 B61 B62 B63 B64 B65 B66 B67 B68 B69 B70 B71 B72 B73 B74 B75 B76 B77 B78 B79 B80 B81 B82 5V_1 5V_2 GND_1 GND_9 3.3V_1 3.3V_4 ELE_PS_SENSE_1 3.3V_5 GND_2 GND_10 GND_3 GND_11 SDHC_CLK/SPI1_CLK SCL0 SDHC_D3/SPI1_CS1 SDA0 SDHC_D3/SPI1_CS0 GPIO9/CTS1 SDHC_CMD/SPI1_MOSI GPIO8/SDHC_D2 SDHC_D0/SPI1_MISO GPIO7/SD_WP_DET ETH_COL_1 ETH_RXER_1 ETH_TXCLK_1 ETH_TXEN_1 ETH_TXER_1 ETH_TXD3_1 ETH_TXD2_1 ETH_TXD1_1 ETH_TXD0_1 GPIO1/RTS1 GPIO2/SDHC_D1 GPIO3 CLKIN0 CLKOUT1 GND_4 AN7 AN6 AN5 AN4 GND_5 DAC1 TMR3 TMR2 GPIO4 3.3V_2 PWM7 PWM6 PWM5 PWM4 CANRX0 CANTX0 1WIRE SPI0_MISO/IO1 SPI0_MOSI/IO0 SPI0_CS0 SPI0_CS1 SPI0_CLK GND_6 SCL1 SDA1 GPIO5/SPI0_HOLD/IO3 USB0_DP_PDOWN USB0_DM_PDOWN IRQ_H IRQ_G IRQ_F IRQ_E IRQ_D IRQ_C IRQ_B IRQ_A EBI_ALE/EBI_CS1 EBI_CS0 GND_7 EBI_AD15 EBI_AD16 EBI_AD17 EBI_AD18 EBI_AD19 EBI_R/W EBI_OE EBI_D7 EBI_D6 EBI_D5 EBI_D4 EBI_D3 EBI_D2 EBI_D1 EBI_D0 GND_8 3.3V_3 ETH_CRS ETH_MDC_1 ETH_MDIO_1 ETH_RXCLK_1 ETH_RXDV_1 ETH_RXD3_1 ETH_RXD2_1 ETH_RXD1_1 ETH_RXD0_1 SSI_MCLK SSI_BCLK SSI_FS SSI_RXD SSI_TXD GND_12 AN3 AN2 AN1 AN0 GND_13 DAC0 TMR1 TMR0 GPIO6 3.3V_6 PWM3 PWM2 PWM1 PWM0 RXD0 TXD0 RXD1 TXD1 VSSA VDDA VREFA1 VREFA2 GND_14 GPIO14 GPIO15 GPIO16 GPIO17 USB0_DM USB0_DP USB0_ID USB0_VBUS TMR7 TMR6 TMR5 TMR4 RSTIN RSTOUT CLKOUT0 GND_15 EBI_AD14 EBI_AD13 EBI_AD12 EBI_AD11 EBI_AD10 EBI_AD9 EBI_AD8 EBI_AD7 EBI_AD6 EBI_AD5 EBI_AD4 EBI_AD3 EBI_AD2 EBI_AD1 EBI_AD0 GND_16 3.3V_7 GPIO_PTC2 GPIO_PTC1 GPIO_PTC0 A12 A13 A14 A15 A16 A17 A18 A19 A20 A21 A22 A23 A24 A25 A26 A27 A28 A29 A30 A31 A32 A33 A34 A35 A36 A37 A38 A39 A40 A41 A42 A43 A44 A45 A46 A47 A48 A49 A50 A51 A52 A53 A54 A55 A56 A57 A58 A59 A60 A61 A62 A63 A64 A65 A66 A67 A68 A69 A70 A71 A72 A73 A74 A75 A76 A77 A78 A79 A80 A81 A82 ADC0_AN5 ADC0_AN4 ADC0_AN1 ADC0_AN0 C ETIMER0_ETC1 ETIMER0_ETC0 GPIO_PTB12 FLEXPWM0_B1 FLEXPWM0_A1 FLEXPWM0_B0 FLEXPWM0_A0 LIN0_RXD LIN0_TXD VDDA VSSA GPIO_PTD0 GPIO_PTD1 GPIO_PTD8 GPIO_PTD9 ETIMER1_ETC1 ETIMER1_ETC0 ETIMER0_ETC5 ETIMER0_ETC4 MCU_RESET B PD2 LED_GREEN PCI EXPRESS TOWER SYSTEM R12 1K A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 PRIMARY 0.1uF D7 A C PD7 LIGHT TOUCH PUSH BUTTON LED ORANGE 1 P5V SW3 4 P5V U4 1 +VS GND C38 0.1uF 2 LM61 LM61CIM3/NOPB ADC0_AN5 3 2 C42 3 R18 10k VO PD3 0.1uF C37 1UF A A ICAP Classification: Drawing Title: FCP: ___ FIUO: X PUBI: ___ TRK-USB-MPC5602P Page Title: Schematic - MCU 5 4 3 2 Size C Document Number Date: Thursday, October 06, 2011 Rev C SCH-27263 PDF: SPF-27263 1 Sheet 4 of 4