Order this document by XBRP400100CTL/D SEMICONDUCTOR TECHNICAL DATA POWERTAP II Package . . . employing the Schottky Barrier principle in a large area metal–to–silicon power diode. State–of–the–art geometry features epitaxial construction with oxide passivation and metal overlay contact. Ideally suited for low voltage, high frequency switching power supplies, free wheeling diode and polarity protection diodes. SCHOTTKY BARRIER RECTIFIER 400 AMPERES 100 VOLTS • Highly Stable Oxide Passivated Junction • Guardring for Stress Protection • Matched Dual Die Construction; May be Paralleled for High Current Output • Low Forward Voltage 1 Mechanical Characteristics: • Case: Epoxy, Molded with Metal Heatsink Base 3 • Weight: 80 grams (approximately) • Finish: All External Surfaces Corrosion Resistant • Base Plate Torques: See procedure given in the Package Outline Section • Top Terminal Torque: 25–40 lb–in max. • Shipped 25 units per foam • Marking: XBRP400100CTL 2 D CASE 357C–03 POWERTAP II MAXIMUM RATINGS Rating Peak Repetitive Reverse Voltage Working Peak Reverse Voltage DC Blocking Voltage Symbol Value Unit VRRM VRWM VR 100 V Average Rectified Forward Current (At Rated VR, TC = 100°C) Per Leg Per Package IO 200 400 A Peak Repetitive Forward Current (At Rated VR, Square Wave, 20 kHz, TC = 100°C) Per Package IFRM 400 A Non–Repetitive Peak Surge Current (Surge applied at rated load conditions, halfwave, single phase, 60 Hz) Per Package IFSM 2500 A Tstg, TC Storage / Operating Case Temperature TJ *55 to +150 *55 to +150 dv/dt 1000 V/µs RθJC 0.45 °C/W Operating Junction Temperature Voltage Rate of Change (Rated VR, TJ = 25°C) °C °C THERMAL CHARACTERISTICS Thermal Resistance — Junction–to–Case Per Leg ELECTRICAL CHARACTERISTICS Rating Symbol Maximum Instantaneous Forward Voltage (1) Per Leg VF (IF = 200 A) (IF = 400 A) Maximum Instantaneous Reverse Current (1) Per Leg (VR = 100 V) (VR = 50 V) (1) Pulse Test: Pulse Width v 380 µs, Duty Cycle v 2%. IR Value Unit TJ = 25°C TJ = °C 0.83 (target) 0.97 (target) TBD TBD TJ = 25°C TJ = °C 6.0 TBD TBD TBD V mA This document contains information on a product under development. Motorola reserves the right to change or discontinue this product without notice. POWERTAP II and SWITCHMODE are trademarks of Motorola, Inc. Device Rectifier Motorola, Inc. 1997 Data 1 XBRP400100CTL PACKAGE DIMENSIONS –A– W 0.25 (0.010) R G M T A M B M N –B– Q H 2 PL 0.25 (0.010) F –T– C E U NOTES: 1. DIMENSIONING AND TOLERANCING PER ANSI Y14.5M, 1982. 2. CONTROLLING DIMENSION: INCH. 3. TERMINAL PENETRATION: 5.97 (0.235) MAXIMUM. M T A M SEATING PLANE V B M DIM A B C E F G H N Q R U V W INCHES MIN MAX 3.450 3.635 0.700 0.810 0.615 0.640 0.120 0.130 0.435 0.445 1.370 1.380 0.007 0.030 1/4–20UNC–2B 0.270 0.285 31.50 BSC 0.600 0.630 0.330 0.375 0.170 0.190 MILLIMETERS MIN MAX 87.63 92.33 17.78 20.57 15.53 16.26 3.05 3.30 11.05 11.30 34.80 35.05 0.18 0.76 1/4–20UNC–2B 6.86 7.32 80.01 BSC 15.24 16.00 8.39 9.52 4.32 4.82 CASE 357C–03 ISSUE C Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty, representation or guarantee regarding the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and specifically disclaims any and all liability, including without limitation consequential or incidental damages. “Typical” parameters which may be provided in Motorola data sheets and/or specifications can and do vary in different applications and actual performance may vary over time. All operating parameters, including “Typicals” must be validated for each customer application by customer’s technical experts. Motorola does not convey any license under its patent rights nor the rights of others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal Opportunity/Affirmative Action Employer. Mfax is a trademark of Motorola, Inc. How to reach us: USA / EUROPE / Locations Not Listed: Motorola Literature Distribution; P.O. Box 5405, Denver, Colorado 80217. 1–303–675–2140 or 1–800–441–2447 JAPAN: Nippon Motorola Ltd.: SPD, Strategic Planning Office, 4–32–1, Nishi–Gotanda, Shinagawa–ku, Tokyo 141, Japan. 81–3–5487–8488 Customer Focus Center: 1–800–521–6274 Mfax: [email protected] – TOUCHTONE 1–602–244–6609 ASIA/PACIFIC: Motorola Semiconductors H.K. Ltd.; 8B Tai Ping Industrial Park, Motorola Fax Back System – US & Canada ONLY 1–800–774–1848 51 Ting Kok Road, Tai Po, N.T., Hong Kong. 852–26629298 – http://sps.motorola.com/mfax/ HOME PAGE: http://motorola.com/sps/ 2 ◊ XBRP400100CTL/D Rectifier Device Data