5mm LED CBI® Circuit Board Indicator Bi-level 4.45 [.175] 6.0 [.235] 552-0xxx PART NO. 10.9 [.430] COLOR* HIGH EFFICIENCY, LED TYPE 02 CATHODE I.D. 6.35 [.250] 12.52 [.493] CATHODE Red Cathode for Red/Green Bi-Color Yellow Cathode for Yellow/Green Bi-Color 3.2 [.125] 3.68 [.145] 552-0211 552-0222 552-0233 552-0277 Red Green Yellow Orange 2.54 [.100] .508 [.020] RECOMMENDED P.C. BOARD LAYOUT 2.54 [.100] 2.54 [.100] 5.6 [.220] 1.1 [.043] Top LED 2.54 [.100] Dimensions in mm [inches] INTEGRAL RESISTOR 5 VOLTS, LED TYPE 03 552-0311 552-0322 552-0333 Red Green Yellow Standard Polarity shown in drawing: Cathode right INTEGRAL RESISTOR 12 VOLTS, LED TYPE 04 Features 552-0422 552-0433 • Multiple CBIs form horizontal LED arrays on 6.35mm (0.250”) center-lines. • • • • • High Contrast, UL 94 V-0 rated, black housing Oxygen index: 32% Polymer content: PBT, 0.710 g Housing stand-offs facilitate PCB cleaning Solderability per MIL-STD-202F, method 208F • LEDs are safe for direct viewing per IEC 825-1, EN-60825-1 Custom Combinations NEW NEW Green Yellow BI-COLOR, LED TYPE 07 552-0711 552-0744 Red/Green Yellow/Green SUPER BRIGHT, LED TYPE 08 552-0811 552-0822 552-0833 Red Green Yellow LOW CURRENT, LED TYPE 09 • Contact factory for information on custom color combinations and ganged arrays Tolerance note: As noted, otherwise: 552-0911 552-0922 552-0933 Red Green Yellow • LED Protrusion: ±0.04 mm [±0.016] • CBI Housing: ±0.02mm[±0.008] PART NUMBER ORDERING CODE Top Position Bottom Position 5 5 2 – 0 x x x – 0 1 0 Series To order any of the 552-0xxx part numbers with Reverse Polarity (Cathode Left), please add -010 to the part numbers shown above. LED Type Reverse Polarity Option 1) Cathode Left Color 0) Blank 1) Red or Red/Green Bi-Color 2) Green 3) Yellow 4) Yellow/Green Bi-Color 7) Orange –010 Ordering Code Suffix required ONLY for Reverse Polarity Option 6-36 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 552-0xxx Typical Operating Characteristics (TA=25°C) HIGH EFFICIENCY See LED data sheet for additional information See page 6-55 and 6-56 for Reference Only LED Drive Circuit Examples. See page 6-58 for Pin Out Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet Page # 552-0211 Red 650 7 2.2 10 50° 5HD-9269 6-49 552-0222 552-0233 Green Yellow 563 585 10 6.3 2.1 2.1 10 10 65° 50° 5HD-9270-5 5HD-9271-5 6-49 6-49 552-0277 Orange 600 7 1.9 10 60° 521-9704 6-43 Page # INTEGRAL RESISTOR, 5 VOLTS Part Number Color Peak Wavelength nm IV mcd Test Voltage Forward Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet 552-0311 552-0322 552-0333 Red Green Yellow 655 565 583 2 8 8 5 5 5 13 12 10 60° 60° 60° 5RD-9422 5RD-9423 521-9284 6-52 6-52 6-41 INTEGRAL RESISTOR, 12 VOLTS Part Number Color Peak Wavelength nm IV mcd Test Voltage Forward Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet Page # 552-0422 552-0433 Green Yellow 565 583 4 4 12 12 13 13 60° 60° 5RD-9378 5RD-9379 6-52 6-52 Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet Page # 552-0711 552-0744 Red/Green Yellow/Green 660/565 585/565 90/40 8.7/8.7 1.8/2.1 2.1/2.1 20 20 60° 50° 521-9651 521-9724 6-46 6-46 BI-COLOR SUPER BRIGHT Part Number Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet Page # 552-0811 Red 650 34 2.1 20 50° 5SD-9441 6-53 552-0822 552-0833 Green Yellow 563 585 34 34 2.2 2.2 20 20 50° 50° 5SD-9456 5SD-9455 6-53 6-53 Color Peak Wavelength nm IV mcd VF Volts Test Current (mA) Viewing Angle 2Θ Θ½ LED Data sheet Page # 552-0911 Red 635 2 1.8 2 50° 521-9320 6-42 552-0922 552-0933 Green Yellow 565 583 1.8 1.8 1.8 1.9 2 2 50° 50° 521-9327 521-9321 6-42 6-42 LOW CURRENT Part Number Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-37 6 5mm Discrete LED Integral Resistor, 5 Volts Diffused 9.19 [.362] 8.43 [.332] .76 [.030] 521-9183, -9284 PART NO. 521-9183 521-9284 5.84 [.230] .64 [.025] LED COLOR Red Yellow 2.54 [.100] 5.08 [.200] 4.57 [.180] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow ABSOLUTE MAXIMUM RATINGS (TA=25°C) -9183 -9284 Forward Voltage (V) Derating (V/°C) From 50°C 7.5 .071 7.5 .071 Operating Temperature (°C) -40/+85 -40/+85 Storage Temperature (°C) -55/+100 -55/+100 Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Luminous Intensity (mcd) Min. VF = 5V Typical Red Yellow -9183 2 8 -9284 2 8 Peak Wavelength (nm) λ Peak Typical 635 583 Viewing Angle (2Θ ½) Typical 60° 60° Forward Current (I) VF = 5V Typical Max 10 15 10 15 Min. 5 5 Reverse Voltage (V), IR=100µA 6 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-41 5mm Discrete LED Low Current, 2mA Diffused 8.81 [.347] .76 [.030] 521-9320, -9321, -9327 PART NO. 521-9320 521-9321 521-9327 5.84 [.230] .46 [.018] 2.54 [.100] 4.83 [.190] 1.0 [.040] MAX 25.1 [1.00] MIN 1.27 [.050] 1.0 [.040] MAX COLOR Red Yellow Green CATHODE MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow Green -9320 -9321 -9327 Power Dssipation (mW) Derating (mA/°C) From 92°C 27 1 36 1 24 1 Forward Current (mA) 7 7 7 Peak Current (mA) Pulse width = 10 µs 500 500 500 Operating Temperature (°C) -55/+100 -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red Yellow Green -9320 -9321 -9327 Luminous Intensity (mcd) IF=2mA Min. Typical 1.2 2 1.2 1.8 1.2 1.8 Peak Wavelength (nm) λ Peak Typical 635 583 565 Viewing Angle (2Θ ½) Typical 50° 50° 50° Forward Voltage (V) IF=2mA Typical Max. 1.8 2.2 1.9 2.7 1.8 2.2 Reverse Voltage (V), IR=50µA Min. 5 5 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-42 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 5mm Discrete LED High Efficiency Diffused 8.81 [.347] .76 [.030] 521-9246, -9248, -9250, -9704 PART NO. 521-9246 521-9248 521-9250 521-9704 5.84 [.230] .46 [.018] 2.54 [.100] 4.83 [.190] 1.0 [.040] MAX 1.27 [.050] COLOR Red Yellow Green Orange CATHODE 25.1 [1.00] MIN MOUNTING CLIP: 515-0004 located on page 6-48 Dimensions in mm [inches] Red Yellow Green Orange ABSOLUTE MAXIMUM RATINGS (TA=25°C) -9246 -9248 -9250 -9704 Power Dissipation (mW) Derating (mW/°C) From 25°C 1. (mA/°C) From 50°C 135 1.8 85 1.6 135 1.8 135 .51 Forward Current (mA) 25 20 25 30 Peak Current (mA) 500 500 500 500 Operating Temperature (°C) -55/+100 -55/+100 -20/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 -55/+100 Pulse width = 10µs Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red Yellow Green Orange -9246 -9248 -9250 -9704 Luminous Intensity (mcd) IF=10mA Min. Typical 4 7 4 8 4.2 5.2 4 7 Peak Wavelength (nm) λ Peak Typical 635 583 565 600 Viewing Angle (2Θ ½) Typical 60° 60° 60° 60° Forward Voltage (V) IF=10mA Typical Max. 2.2 3 2.2 3 2.3 3 1.9 2.4 Reverse Voltage (V), IR=100µA Min. 5 5 5 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-43 6 5mm Discrete LED Bi-Color Non-Tinted, Diffused 8.64[.340] 1.50 [.059] MAX 521-9651, -9724 5.59 [.220] 0.51 [.020] 5.00 [.197] 2.54 [.100] 22.1 [.87] MIN. 1.00 [.04] Dimensions in mm [inches] PART NO. LED COLOR 521-9651 Red/Green 521-9724 Yellow/Green CATHODE GREEN, RED/GREEN BI-COLOR 521-9651 CATHODE YELLOW, YELLOW/GREEN BI-COLOR 521-9724 MOUNTING CLIP: 515-0005 located on page 6-48 Red/Green Yellow/Green -9651 -9724 100/100 60/100 40/30 .5/.4 20/30 .25/.40 200/120 80/120 Operating Temperature (°C) -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 50°C Peak Current (mA) Pulse width = 100 µs Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red/Green Yellow/Green -9651 -9724 Luminous Intensity (mcd) IF=20mA Min. Typical 29/12.6 90/40 2.5/2.5 8.7/8.7 Peak Wavelength (nm) λ Peak Typical 660/565 585/565 Viewing Angle (2Θ ½) Typical 60° 50° Forward Voltage (V) Typical 1.8/2.1 2.1/2.1 Max. 2.4/2.8 2.8/2.8 IF=20mA Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-46 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 5mm Discrete LED Super Bright, Water Clear Non-Tinted, Non-Diffused 8.81 [.347] 1.0 [.040] MAX 521-9464,-9465,-9466 5.84 [.230] 4.83 [.190] 2.54 [.100] 25.35 [.998] MIN 1.27 [.050] TYP CATHODE .46 [.018] SQ. Dimensions in mm [inches] ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Derating (mW/°C) From 25°C 1. From 50 °C PART NO. COLOR 521-9464 521-9465 521-9466 Red Green Yellow MOUNTING CLIP: 515-0004 located on page 6-48 Red Green Yellow -9464 -9465 -9466 135 1.8 135 1.8 85 1.61 Forward Current (mA) 30 30 20 Peak Current (mA) Pulse width = 10 µs 500 500 500 Operating Temperature (°C) -55/+100 -20/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 Soldering Temperature 260 °C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red Green Yellow -9464 -9465 -9466 Luminous Intensity (mcd) IF=20mA Min. Typical 80 125 80 120 80 140 Peak Wavelength (nm) λ Peak Typical 635 565 583 Viewing Angle (2Θ ½) Typical 24° 24° 24° Forward Voltage (V) IF=20mA Typical Max. 2.2 3 2.3 3 2.2 3 Reverse Voltage (V), IR=100µA Min. 5 5 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-47 6 5mm High Efficiency Diffused 5HD-xxxx TYPE *5HD-9269 *5HD-9270-2 *5HD-9270-5 *5HD-9271-2 *5HD-9271-5 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25°C) COLOR Red Green Green Yellow Yellow Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 60 1 .66 140 75 1 .66 200 60 1 .66 Forward Current (mA) Derating (mA/°C) From 25°C 20 40 .6 25 60 .8 20 Peak Current (mA) 60 500 60 1000 60 Operating Temperature (°C) -25/+85 -55/+100 -25/+85 -55/+100 -25/+85 Storage Temperature (°C) -30/+100 -55/+100 -30/+100 -55/+100 -30/+100 Power Dissipation (mW) Derating (mW/°C) From 50°C 1. From 40°C Pulse width = 1µs Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red Green Green Yellow Yellow -9269 -9270-2 -9270-5 -9271-2 -9271-5 Luminous Intensity (mcd) IF=10mA Min. Typical 2.2 7 4 32 3.6 10 4 10 2.2 6.3 Peak Wavelength (nm) λ Peak Typical 650 565 563 590 585 Viewing Angle (2Θ ½) Typical 50° 50° 65° 70° 50° Forward Voltage (V) I F=10mA, *IF=20mA Typical Max. 2.2 2.5 2* 2.6* 2.1 3 2.4* 3* 2.1 3 Reverse Voltage (V), IR=100µA *IR=10µA Min. 5 5* 3* 5* 3 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-49 6 5mm General Purpose Diffused 5ND-xxxx TYPE COLOR *5ND-9672 *5ND-9673 *5ND-9674 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red Yellow Green Red Yellow Green -9672 -9673 -9674 Power Dissipation (mW) 80 60 100 Forward Current (mA) Derating (mA/°C) From 25°C 40 .5 20 .25 30 .4 Peak Current (mA) 200 80 120 Operating Temperature (°C) -55/+100 -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Pulse width = 10 µs Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red Yellow Green -9672 -9673 -9674 Luminous Intensity (mcd) IF=20mA Min. Typical 3.5 12.3 3.5 12.3 3.5 12.3 Peak Wavelength (nm) λ Peak Typical 635 585 565 Viewing Angle (2Θ ½) Typical 60° 60° 60° Forward Voltage (V) IF=20mA Typical Max. 2 2.8 2.1 2.8 2.1 2.8 Reverse Voltage (V), IR=100µA Min. 5 5 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-51 6 5mm Integral Resistor Diffused 5RD-xxxx TYPE *5RD-9378 *5RD-9379 *5RD-9422 *5RD-9423 * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. ABSOLUTE MAXIMUM RATINGS (TA=25°C) COLOR Green Yellow Red Green VOLTS 12 12 5 5 Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 15* 15 7.5 7.5 Operating Temperature (°C) -20/+85 -40/+85 -40/+85 -20/+85 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 -55/+100 Forward Voltage (V) *(TA=70°C) Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Green 12V Yellow 12V Red 5V Green 5V -9378 -9379 -9422 -9423 Luminous Intensity (mcd) VF=5V, *VF=12V Min. Typical 1.5* 4* 1.5* 4* 1 2 2 8 Peak Wavelength (nm) λ Peak Typical 565 583 655 565 Viewing Angle (2Θ ½) Typical 60° 60° 60° 60° Forward Current (mA), VF=5V *VF=12V Typical Max. 13* 20* 13* 20* 13 20 12 15 Reverse Voltage (V), IR=100µA Typical 5 5 5 5 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity 6-52 Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 5mm Super Bright LED Diffused 5SD-xxxx TYPE *5SD-9441 *5SD-9455 *5SD-9456 COLOR Red Yellow Green * NOT A VALID PART NUMBER. THIS SHEET IS FOR REFERENCE ONLY. Red -9441 Yellow -9455 Green -9456 75 75 75 25 .66* 25 .5 25 .5 60 60 60 Operating Temperature (°C) -55/+100 -55/+100 -55/+100 Storage Temperature (°C) -55/+100 -55/+100 -55/+100 ABSOLUTE MAXIMUM RATINGS (TA=25°C) Power Dissipation (mW) Forward Current (mA) Derating (mA/°C) From 50°C *(mW/°C) From 40°C Peak Current (mA) Pulse width = 1 ms Soldering Temperature 260°C, 5 seconds, 1.6 mm from case Solder Adherence per MIL-STD-202E, Method 208C OPERATING CHARACTERISTICS (TA=25°C) Red -9441 Yellow -9455 Green -9456 Luminous Intensity (mcd) IF=20mA Min. Typical 17 34 17 34 17 34 Peak Wavelength (nm) λ Peak Typical 650 585 563 Viewing Angle (2Θ ½) Typical 50° 50° 50° Forward Voltage (V) IF=20mA Typical Max. 2.1 2.55 2.2 3 2.2 3 Reverse Voltage (V), IR=10µA Min. 3 3 3 Θ is the off axis angle at which the luminous intensity is half the axial luminous intensity Dialight Corporation • 1501 Route 34 South • Farmingdale, NJ 07727 • TEL: (732) 919-3119 • FAX: (732) 751-5778 •www.dialight.com 6-53 6