5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Features • High speed 1Mbit/s • High isolation voltage between input and output (Viso=3750 Vrms ) • High CMR 15KV/us at VCM=1500V (ELM453) • Guaranteed performance from 0°C to 70°C • Wide operating temperature range of -40°C to 85°C • Pb free and RoHS and Halogen free compliant • cUL approved (No. E214129) • VDE approved (No. 40028116) • SEMKO approved • NEMKO approved Schematic • DEMKO approved • FIMKO approved Description The ELM452 and ELM453 devices each consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by Pin Configuration reducing the base-collector capacitance of the input transistor. 1. Anode The devices are packaged in industry standard 5pin SOP packages and are suitable for surface mounting. 3. Cathode 4. Gnd 5. Vout Applications 6. VCC • Line receivers • Field bus communication and control. • Power transistor isolation in motor drives • Replacement for low speed phototransistor photo couplers • High speed logic ground isolation • Analog signal ground isolation Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 1 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Absolute Maximum Ratings (Ta=25°C unless otherwise noted) Parameter Symbol Rating Unit Forward current IF 25 mA Peak forward current (50% duty, 1ms P.W) IFP 50 mA Peak transient current (≤1µs P.W,300pps) IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 3750 V rms Operating temperature TOPR -40 ~ +85 °C Storage temperature TSTG -55 ~ +125 °C TSOL 260 °C Input Output Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1 & 3 are shorted together, and pins 4, 5 & 6 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 2 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Electrical Characteristics (TA=0 to 70°C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.45 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10µA ∆VF/∆TA - -1.6 - mV/°C IF =16mA Symbol Min. Typ.* Max. Unit - 0.001 0.5 - 0.001 1 - - 50 - 100 200 - 0.05 1 Temperature coefficient of forward voltage Conditions Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current IOH ICCL ICCH IF=0mA, VO=VCC=5.5V, TA=25°C µA - 2 Min. Typ.* Max. 20 - 50 15 - - - - 0.4 - - 0.5 IF=0mA, VO=VCC=15V, TA=25°C IF=0mA, VO=VCC=15V µA IF=16mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25°C µA - Conditions IF=0mA, VO=Open, VCC=15V Transfer Characteristics Parameter Current Transfer Ratio Logic Low Output Voltage Everlight Electronics Co., Ltd. Document No DPC-0000113 ： Symbol CTR % VOL Conditions IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25°C IF = 16mA ,VO = 0.5V, VCC=4.5V IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25°C V 3 Rev.1 Unit IF = 16mA ,IO = 2.4mA, VCC=4.5V http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Switching Characteristics (TA=0 to 70°C unless specified otherwise, Vcc=5V) Parameter Symbol Propagation Delay Time to (*3) Logic Low (Fig.8) TPHL Propagation Delay Time to (*3) Logic High (Fig.8) Common Mode Transient Immunity at (*4) Logic High (Fig.9) Common Mode Transient Immunity at (*4) Logic Low (Fig.9) ELM452 Typ.* Max. - 0.4 0.8 Unit µs - - 1.0 - 0.35 0.8 - - 1.0 5,000 - - CMH Conditions IF=16mA, RL=1.9KΩ, TA=25°C IF=16mA, RL=1.9KΩ µs IF=16mA, RL=1.9KΩ, TA=25°C IF=16mA, RL=1.9KΩ IF = 0mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C V/µs ELM453 15,000 - - IF = 0mA , VCM=1500Vp-p, RL=1.9KΩ, TA =25°C ELM452 5,000 - - IF = 16mA , VCM=10Vp-p, RL=1.9KΩ, TA =25°C CML ELM453 Everlight Electronics Co., Ltd. Document No DPC-0000113 ： TPLH Min. V/µs 15,000 - 4 Rev.1 - IF = 16mA , VCM=1500Vp-p, RL=1.9KΩ, TA=25°C http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 5 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Figure 9 Switching Time Test Circuit & Waveform Figure 10 Transient Immunity Test Circuit & Waveform Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 6 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). Order Information Part Number ELM45X(Z)-V Note X Z V = Part No. (2 or 3) = Tape and reel option (TA, TB or none) = VDE (optional) Option Description Packing quantity None Standard 100 units per tube -V Standard + VDE 100 units per tube (TA) TA tape & reel option 3000 units per reel (TB) TB tape & reel option 3000 units per reel (TA)-V TA tape & reel option + VDE 3000 units per reel (TB)-V TB tape & reel option + VDE 3000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 7 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Package Drawing (Dimensions in mm) Recommended pad layout for surface mount leadform Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 8 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Device Marking EL M453 YWWV Notes EL denotes EVERLOGHT M453 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 9 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A0 A1 B0 D0 D1 E F Dimension(mm) 6.2±0.1 4.1±0.1 5.28±0.1 1.5±0.1 1.5±0.3 1.75±0.1 5.5±0.1 Dimension No. Po P1 P2 t W K0 K1 Dimension(mm) 4.0±0.1 8.0±0.1 2.0±0.1 0.4±0.1 3.7±0.1 0.3±0.1 Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 10 Rev.1 12.0+0.3/ -0.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series Solder Reflow Temperature Profile 260 °C (peak) >255 °C (30s Max) 217°°C 1-3 °C/Sec Max 200°°C 60 – 100 Sec 150°°C 60 – 120 Sec 1-3 °C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 11 Rev.1 http://www.everlight.com October 6, 2011 5 PIN SOP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER ELM45X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don’t reproduce or cause anyone to reproduce them without EVERLIGHT’s consent. Everlight Electronics Co., Ltd. Document No DPC-0000113 ： 12 Rev.1 http://www.everlight.com October 6, 2011