PCI 350 TracewellPower 350 Watt CompactPCI Power Supply Features • 350 Watts in 6U x 8HP (two slots) x 160mm • Wide-range AC or 48 Volt DC input • Standard PCI voltages: 5V, 3.3V, ±12V • Four output-current options: 5V/40A 5V/50A 3.3V/50A 3.3V/60A 3.3V/25A 3.3V/25A 5V/20A 5V/20A 12V/9A 12V/9A 12V/9A 12V/9A -12V/2A -12V/2A -12V/2A -12V/2A • Power factor correction (PFC) • N+1 redundant and hot swap • Internal OR-ing diodes • Single-wire current sharing on 5V, 3.3V, +12V outputs • Fully shielded PCI 350 AC input power supply shown with optional low-profile handles • IEEE1101.10 compliant front panels • Ruggedized mechanical design • Optional high-profile cooling fins available on 48V input version Description • UL, cUL approved • CE mark The PCI 350 is a high-performance power supply • EMC approved for use in 6U CompactPCI computer, test and telecom • Two year warranty systems. The PCI 350 meets all of the requirements of the PICMG CompactPCI specification plus N+1 redundant and hot swap. High-density cooling fins are positioned directly in the airstream. All input and output connections are through the backplane. LED status indicators are located on the front panel. www.tracewellpower.com 1.800.811.1480 phone 614.847.9336 fax 614.847.9316 567 Enterprise Drive Westerville, Ohio 43081 PCI 350 TracewellPower 350 Watt CompactPCI Power Supply Specifications Output Voltage/Current Options ... 5V/40A, 3.3V/25A, +12V/9A, -12V/2A 5V/50A, 3.3V/25A, +12V/9A, -12V/2A 3.3V/50A, 5V/20A, +12V/9A, -12V/2A 3.3V/60A, 5V/20A, +12V/9A, -12V/2A Output Power........................................... DC Input: AC Input: Over-Voltage ............................................ Shutdown at 130% of nominal Vout. Recycle power to reset Over-Temperature................................. Shutdown upon internal heatsink temperatures exceeding limits. Recycle power to reset 350 Watts max 350 Watts max 105-264 Vac 300 Watts max 90-105 Vac Input Voltage/Current ......................... AC: 100-240 Vac (90-264 Vac tolerant range), 47-63Hz, 6 A max, single phase DC: 48 Vdc (40-72 Vdc tolerant range), 12 A max Power Factor............................................. 0.99 typical Current Limiting ..................................... All outputs protected against overload and short circuit. Straight-line current limiting, does not fold-back or latchup during startup or load transients. Automatic recovery Safety. .......................................................... UL, cUL, and CB report UL1950 and EN60950 EMC ............................................................... Emissions below EN55022 class A and EN61000-3-2, 3. Immunity to EN61000-4-2, 4, 5 Input Fuse. ................................................. Internal fusing included Inrush Current.......................................... AC: 40A max DC: 15A max Output Isolation...................................... All outputs and control signals are SELV circuits referenced to GND with reinforced insulation to the AC primary. GND should be connected to chassis ground in the system. Efficiency .................................................... DC input: 75% min AC input: 65% min Efficiency increases with line voltage Leakage Current ..................................... 1.0 mA max. at 240 Vac Holdup Time ............................................. 20 msec min. from input power failure until FAIL# signal drops, at full load and 90-264 Vac AC Fail Warning....................................... 5 msec min. continued operation after FAIL# signal drops Paralleling.................................................. Any number of power supplies can be operated in parallel and will share 3.3V/5V/+12V current to within 10%. Remote Sense must be used when paralleling with current sharing Redundant/Hot Swap........................... Full power N+1 redundant and hot-swap Remote Sense........................................... Compensates for up to 0.25V total distribution voltage drop on the 3.3V/5V/+12V outputs Line/Load Regulation........................... 1% max. over input range and 0-100% load except -12V output which is ±10% Minimum Load......................................... None required Dielectric Strength................................. AC: 2200 Vdc from input to chassis ground DC: 500 Vdc from input to chassis ground Indicators ................................................... Green LED indicating INPUT OK Red LED indicating a power supply FAULT Connector .................................................. Positronic part no. PCI38M400A1 Mating connector part no. PCI38F300A1 Cooling ........................................................ 15 cfm/400 lfm forced air required through power supply cooling fins and enclosure Operating Temperature...................... -20°C to 50°C operating temperature with specified air flow. Derate output power with reduced airflow conditions (consult factory) Storage Temperature........................... -40°C to 85°C Shock/Vibration...................................... Ruggedized construction Ripple/Noise ............................................. 50 mV max. for all outputs, peak-to-peak, DC to 20 MHz with coaxial probe and 0.1uF/22uF capacitors at the connector Overshoot/Undershoot ....................... None at turn-on or turn-off Turn-on Time ............................................ 1 sec max. from power up. All output voltages come up within 10 msec of each other. Note: Specifications subject to change without notice PCI 350 Status Indications Condition EN# low, Inputs/Outputs OK INH# signal low INH# high, EN# high Inhibit switch depressed Low AC or DC input Internal over-temperature Output under-voltage Output over-voltage Ouput short circuit Power Supply On/Off Input OK LED Fault LED FAIL # ON OFF OFF OFF OFF OFF OFF** OFF** OFF** ON ON ON ON OFF ON ON ON ON OFF ON ON ON ON* ON ON ON ON OPEN LOW LOW LOW LOW LOW LOW LOW LOW * If the input is below approx. 20 V, the FAULT LED will not illuminate ** Typically, only the ouptut exhibiting the fault conditions will be off www.tracewellpower.com 1.800.811.1480 phone 614.847.9336 fax 614.847.9316 567 Enterprise Drive Westerville, Ohio 43081 PCI 350 TracewellPower 350 Watt CompactPCI Power Supply Output Power vs Temperature and Airflow 350 300 400 LFM 300 LFM 250 Ouput Power (Watts) 200 LFM 200 100 LFM 150 100 50 0 20 30 40 50 60 70 Ambient Temp (°C) Note: LFM is the airflow in feet per minute through the power supply fins and enclosure Connector Pinout Pin # Signal Pin # Signal Description 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 +5V +5V +5V +5V GND GND GND GND GND GND GND GND +3.3V +3.3V +3.3V +3.3V GND +12V RSVD RSVD -12V GND GND 24 25 26 27 28 29 +5S EN# -SENSE +3.3S RSVD DEG# 30 31 32 33 34 35 36 37 38 +12S INH# +5l +3.3I +12I FAIL# CGND N L Remote sense for +5V oputput Connect to GND to enable power supply Remote sense return for +3.3V, + 5V, +12V outputs Remote sense for +3.3V output RESERVED Open collector, low output when power supply is within 10° C of shutting down due to over-temperature Remote sense for +12V output Connect to GND to inhibit power supply Connect to paralleled power supply for +5V current sharing Connect to paralleled power supply for +3.3V current sharing Connect to paralleled power supply for +12V current sharing Open collector, low output when power supply has failed Chassis ground Neutral (AC) or 48V return (DC) Line (AC) or -48V (DC) www.tracewellpower.com 1.800.811.1480 phone 614.847.9336 fax 614.847.9316 567 Enterprise Drive 38 37 36 34 35 33 32 31 30 28 29 27 25 26 24 22 23 21 19 20 17 18 15 16 13 14 11 12 9 10 7 8 5 6 3 4 1 2 Westerville, Ohio 43081 PCI 350 TracewellPower 350 Watt CompactPCI Power Supply Dimensions AC and 48V Input Versions TracewellPower CompactPCI POWER SUPPLY 10.309 261.85mm 9.187 233.35mm INPUT OK FAULT 1.588 40.34mm Optional High-Profile Cooling Fin Version (48V input only) 6.768 171.91mm TracewellPower CompactPCI POWER SUPPLY 10.309 261.85mm 9.187 233.35mm INPUT OK FAULT 1.588 40.34mm 6.768 171.91mm CompactPCI™ is a trademark of the PCI Industrial Computer Manufacturer’s Group www.tracewellpower.com 1.800.811.1480 phone 614.847.9336 fax 614.847.9316 567 Enterprise Drive Westerville, Ohio 43081 PCI 350 TracewellPower 350 Watt CompactPCI Power Supply Backplane Connector Location Power backplanes are available for both the AC and 48V power supplies: 2-slot (for one power supply) and 4-slot (for two power supplies). Consult factory for details. AC and 48V Input Versions 0.517 13.14mm 0.680 17.27mm BACKPLANE POWER CONNECTOR LOCATION VIEWED FROM THE FRONT OF THE CAGE Optional High-Profile Cooling Fin Version (48V input only) 0.204 5.18mm 0.680 17.27mm BACKPLANE POWER CONNECTOR LOCATION VIEWED FROM THE FRONT OF THE CAGE 0.688 17.48mm 0.375 9.53mm 5.485 139.32mm 5.485 139.32mm Note: Please reference Section 4 (Mechanical Requirements) of the CompactPCI Specification PICMG 2.0 R2.1 Configuration PCI350 - __ __ __ __ Example: PCI350-AC01SL www.tracewellpower.com 1.800.811.1480 S L T N Standard handles Low-profile handles Mounting screws only (no handles) No handles or mounting screws S N Standard front panel No front panel 01 02 03 04 5V/40A, 3.3V/25A, 12V/9A, -12V/2A 5V/50A, 3.3V/25A, 12V/9A, -12V/2A 3.3V/50A, 5V/20A, 12V/9A, -12V/2A 3.3V/60A, 5V/20A, 12V/9A, -12V/2A AC 48 48H Wide range AC input 48V DC input 48V DC input with high-profile cooling fins AC version with 01 output configuration, standard front panel and low profile handles phone 614.847.9336 fax 614.847.9316 567 Enterprise Drive Westerville, Ohio 43081