SURFACE MOUNT VOLTAGE CONTROLLED CRYSTAL OSCILLATOR SERIES VX83 ACMOS FEATURES FREQUENCY TO 160.00 MHz CUSTOM SPECIFICATIONS AVAILABLE ENABLE DISABLE OPTION SPECIFICATIONS FREQUENCY RANGE 30.01 MHz TO 160.00 MHz FREQUENCY STABILITY OVER TEMPERATURE RANGE (REF. TO25°C) ±10 PPM TO ±50 PPM MAX AT VC = 2.5 VDC AND VCC = +5.0 VDC (SEE TABLE 1) OPERATING TEMPERATURE RANGE 0°C TO +50°C 0°C TO +70°C -40°C TO +85°C AT VC = +2.5 VDC AND VCC = +5.0VDC AND STANDARD LOAD STORAGE TEMPERATURE RANGE -40°C TO +90°C OUTPUT WAVEFORM ACMOS (SEE TABLE 2) LOAD 30 pF SUPPLY VOLTAGE +5 VDC ±5% (3.3 VDC AVAILABLE) SUPPLY CURRENT 50 mA MAX AT VC = +2.5 VDC, VCC = +5.0 VDC AND STANDARD LOAD AT 25°C ABSOLUTE PULL RANGE ±50 PPM TO ±100 PPM MIN OVER CONTROL VOLTAGE RANGE AT VCC = +5.0 V AND STANDARD LOAD AT 25°C (SEE TABLE 1) NOMINAL CONTROL VOLTAGE (VC) +2.5 VDC SETTABILITY AT Vfo † +2.5 VDC ±0.5 VDC CONTROL VOLTAGE RANGE +0.5 TO +4.5 VDC LINEARITY ±10% MAX SYMMETRY NORMAL: 40/60 % TIGHT: 45/55 % (OPTION) SLOPE POSITIVE MODULATION FREQUENCY BANDWIDTH 10 KHz (-3dB) MIN INPUT IMPEDANCE 10 KOHM MIN ABSOLUTE VOLTAGE RANGE -0.5 TO +7.0 VDC FOR VCC AND VC (NON DESTRUCTIVE) ENABLE/DISABLE FUNCTION CONTROL PIN 2: HIGH OR OPEN (+2.O VDC MIN) OUTPUT PIN 4: ENABLED CONTROL PIN 2: LOW OR GROUND (+0.8 VDC MAX) OUTPUT PIN 4: DISABLED (HIGH Z) PHASE NOISE (TYPICAL) SEE GRAPH FOR PHASE NOISE CHARACTERISTICS † Vfo IS THE CONTROL VOLTAGE AT WHICH THE OUTPUT FREQUENCY IS EQUAL TO THE NOMINAL FREQUENCY Fo AT 25 C ABSOLUTE PULL RANGE (APR) IS THE MINIMUM GUARANTEED FREQUENCY SHIFT FROM Fo OVER VARIATIONS IN TEMPERATURE, AGING, POWER SUPPLY, AND LOAD. TEMPERATURE RANGE DESIGNATIONS OUTPUT AND LOAD CHARACTERISTICS TABLE 1 TABLE 2 CODE TEMPERATURE RANGE TEMPERATURE STABILITY APR A 0°C TO +50°C ± 10 PPM ± 50 PPM B 0°C TO +50°C ± 15 PPM ± 50 PPM C 0°C TO +50°C ± 15 PPM ± 50 PPM D 0°C TO +50°C ± 20 PPM ± 75 PPM E 0°C TO +50°C ± 25 PPM ± 75 PPM MIL-STD-202, METHID 213, CONDITION E THERMAL SHOCK MIL-STD-883, METHOD 1011, CONDITION A RANDOM VIBRATION MIL-STD-883, METHOD 2007, CONDITION A ± 50 PPM GROSS LEAK 100% LEAK TESTED IN DEIONIZED WATER LEAK RATE LESS THAN 0.05 PPM ATM x cc/s OF HELIUM 0°C TO +50°C ± 35 PPM ± 100PPM G 0°C TO +70°C ± 10 PPM ± 50 PPM 0°C TO +70°C ± 20 PPM MECHANICAL CHARACTERISTICS MECHANICAL SHOCK F H ACMOS TO DRIVE 3 GATES AT TTL LEVELS SYMMETRY: 40/60% TO 60/40% AT 50% LEVEL ACMOS - 30 pF (VC/VE83) VOH: +2.9 VDC MIN VOL: +0.33 VDC MAX RISE/FALL TIME: 3 ns WITH 30 pF LOAD (20% TO 80%) I 0°C TO +70°C ± 20 PPM ± 50 PPM HERMETIC SEAL J 0°C TO +70°C ± 25 PPM ± 50 PPM SOLDERING CONDITIONS 240° C ±5 s MAXIMUM FOR 10 s MECHANICAL SURFACE MOUNT, 6 PIN PER OUTLINE DRAWING K 0°C TO +70°C ± 35 PPM ± 75 PPM L 0°C TO +70°C ± 50 PPM ± 100 PPM M -40°C TO +85°C ± 20 PPM ± 50 PPM N -40°C TO +85°C ± 30 PPM ± 50 PPM O -40°C TO +85°C ± 25 PPM ± 75 PPM P -40°C TO +85°C ± 35 PPM ± 75 PPM Q -40°C TO +85°C ± 50 PPM ± 100 PPM Raltron Electronics Corporation 10651 NW 19th St. Miami, Florida 33172 U.S.A. Tel: 305-593-6033 Fax: 305-594-3973 e-mail: [email protected] Internet: http://www.raltron.com Powered by ICminer.com Electronic-Library Service CopyRight 2003 SURFACE MOUNT VOLTAGE CONTROLLED CRYSTAL OSCILLATOR SERIES VX83 ACMOS OUTLINE DRAWING 2.54 .100 3 .46 TYP .018 TYP 7.61 ± .20 .300 ± .008 3 GND 4 OUTPUT 5 N/C† 6 VCC PIN FUNCTION 1 V CONT 2 E/D 3 GND 4 OUTPUT 5 N/C† 6 VCC † PIN MAY BE USED INTERNALLY COOLING 4.0 ± 0.1 .157 ± .004 11.70 .461 150 °C 2.0 ± 0.1 .079 ± .004 PREHEATING 25 °C 120s MAX 12 .00 .472 TIME (SECONDS) -90 4.8 .189 PACKAGING 330 mm REEL DIAMETER, 24 mm TAPE WIDTH, 12 mm PITCH QUANTITY: 1000 PIECES PER REEL PHASE NOISE CHARACTERISTICS 0 -10 -20 -30 -40 -50 -55 -60 -70 -80 -90 -100 10 Hz 24 ± 0.1 .945 ± .004 1.5 ± 0.1DIA .059 ± .004 DIA 10 s 1.75 ± 0.1 .069 ± .004 REFLOW 240 °C TEMPERATURE N/C CARRIER TAPE DIMENSIONS SOLDER REFLOW PROFILE dBc VC 2 VE83 SOLDER PATTERN 2.54 TYP .100 TYP FUNCTION 1 1.02 .040 .76 .030 4.70 MAX 2 VC83 2.54 .100 7.62 .300 8.88 .350 MARKING LABEL 1 1 PIN CONNECTION 2.54 .100 PIN .185 MAX 9.77 MAX .385 MAX 13.96 .550 6 5 4 -86 -90 -95 100 Hz 1 KHz 10 KHz 100 KHz Offset from carrier PART NUMBERING SYSTEM OUTPUT (TABLE 2) SERIES VC8 VE8 3 ACMOS CODE (TABLE 1) FREQUENCY - A THROUGH Q SYMMETRY - IN MHz T: TIGHT EXAMPLES: VC83J-139M00 ACMOS OUTPUT, ±25 PPM OVER 0° C TO +70° C MINIMUM APR ±75 PPM, 139.00 MHz VE83P-52M4216 ENABLE/DISABLE TTL OUTPUT, ±35 PPM OVER -40° C TO +85° C MINIMUM APR ±75 PPM, 52.4216 MHz Raltron Electronics Corporation 10651 NW 19th St. Miami, Florida 33172 U.S.A. Tel: 305-593-6033 Fax: 305-594-3973 e-mail: [email protected] Internet: http://www.raltron.com Powered by ICminer.com Electronic-Library Service CopyRight 2003