SAFETY DATA SHEET Loctite Corporation Super Lube Oil with Teflon (Aerosol) 0209001 1.00 IE EA 07.10.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe This safety data sheet has been prepared in accordance with the requirements of EC Directive 88/379/EEC and 91/155/EEC (and other related directives) and provides information relating to the safe handling and use of the product. This safety data sheet has been prepared in accordance with the requirements of EC Directive 88/379/EEC and 91/155/EEC (and other related directives) and provides information relating to the safe handling and use of the product. 1. 2. PRODUCT AND COMPANY INFORMATION Product Code Trade Name Manufacturer/Supplier Address 0209001 Phone Number Fax Number Emergency Phone Number 01 707 358800 Loctite UK Watchmead, Welwyn Garden City, Herts., AL7IJB. 01 707 358900 +353-1-4599301/+353-1-87-2629625/+353-1-4046444 COMPOSITION / INFORMATION ON INGREDIENTS Nature 3. Super Lube Oil with Teflon (Aerosol) Lubricant Hazardous Components in Product for EC Component Name Concentration R Phrases Classification N-Heptane 30.00 - 60.00 R11 F HAZARD IDENTIFICATION This product is highly flammable. Solvent will have a defatting action on the skin making it more susceptible to dermatitis and sensitisation. Inhalation of vapours may cause headaches or dizziness. 4. FIRST AID MEASURES First Aid - Inhalation Remove affected person to fresh air, and if still feeling unwell seek medical attention. First Aid - Skin Wash with plenty of soap and water. If irritation persists, seek medical advice. First Aid - Eyes Flush eyes with plenty of water for at least 15 minutes. If irritation persists seek medical attention. First Aid - Ingestion Rinse mouth with water then give plenty of water to drink. Do not induce vomiting. 5. FIRE FIGHTING MEASURES Non flammable product (flash point is greater than 150°C (CC)). If product is involved in fire extinguish with dry powder, foam or carbon dioxide. Wear self contained breathing apparatus. MSDS_IE Page 1 of 4 SAFETY DATA SHEET Loctite Corporation Super Lube Oil with Teflon (Aerosol) 0209001 1.00 IE EA 07.10.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 6. ACCIDENTAL RELEASE MEASURES Contain spillage, and absorb onto an inert absorbent such as sand or multisorb and place in a sealed container for supervised disposal. Wash spillage site thoroughly with detergent and water. Try to prevent the material from entering drains or water courses. 7. HANDLING AND STORAGE Handling Good industrial hygiene practices should be observed. In circumstances where there is a potential for prolonged or repeated skin contact, the use of disposable gloves (polyethylene, natural rubber or equivalent ester-resistant material) is recommended. Storage Keep in a cool, well-ventilated area. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Occupational exposure limits N-Heptane UK EH40: OES 400ppm 8h TWA. ACGIH: TLV 400ppm (1640mg/m3) 8h TWA. ACGIH: STEL 500ppm (2050mg/m3) 15min TWA. Good industrial hygiene practices should be observed. In circumstances where there is a potential for prolonged or repeated skin contact, the use of disposable gloves (polyethylene, natural rubber or equivalent ester-resistant material) is recommended. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical State Colour Odour pH Boiling Range/Point (°C) Flash Point (CC) (°C) Specific Gravity Solubility in Water (kg/m³) Solubility in Acetone Vapour Pressure (mmHg @25°C) Explosion Limits (%) 10. Aerosol. White. Characteristic. Not applicable. No data. <0 Data not available. Insoluble. Not listed. No data. No data. STABILITY AND REACTIVITY Stable under normal conditions. MSDS_IE Page 2 of 4 SAFETY DATA SHEET Loctite Corporation Super Lube Oil with Teflon (Aerosol) 0209001 1.00 IE EA 07.10.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 11. TOXICOLOGICAL INFORMATION Inhalation Due to the low volatility of the product there are no hazards associated with inhalation under normal conditions of use. Skin Solvent may remove essential oils from the skin making it susceptible to attack from other chemicals. Eyes May cause mild irritation to the eyes. May cause mild irritation to the eyes. Ingestion This product is considered to be of low toxicity having an acute oral LD50 (rat) >2000mg/kg by analogy to other similar products. 12. ECOLOGICAL INFORMATION Keep away from drains and open waters. 13. DISPOSAL CONSIDERATIONS Dispose of in accordance with local and national regulations. Standard procedures for 'water insoluble' non-toxic chemicals recommended. 14. TRANSPORT INFORMATION UN Number Air (IATA) Sea (IMO) Road (ADR)/Rail (RID) 15. Aerosols, flammable, n.o.s., Class 2.1, flammable gas. Aerosol, Class 2.1 EmS 2-13 MFAG 620. Gas, compressed, Class 2, Aerosol. REGULATORY INFORMATION Contains Labelling Information MSDS_IE 1950 N/A Highly flammable R phrases S phrases R11 Highly flammable. Voluntary Labelling Pressurised container: protect from sunlight and do not expose to temperatures exceeding +50°C. Do not pierce or burn, even after use. Do not spray on a naked flame or any incandescent material. S2 Keep out of the reach of children. S16 Keep away from sources of ignition - No Smoking. S23 Do not breathe vapour. S24/25 Avoid contact with skin and eyes. S33 Take precautionary measures against static discharges. S51 Use only in well ventilated areas. Page 3 of 4 SAFETY DATA SHEET Loctite Corporation Super Lube Oil with Teflon (Aerosol) 0209001 1.00 IE EA 07.10.1998 MSDS_IE Environmental Health & Safety Affairs Health & Regulatory Affairs - Europe 16. OTHER INFORMATION MSDS first issued 7 October 1998 Prepared by: Caroline Walsh MSc Health & Regulatory Affairs - Europe Further Information may be obtained from:Loctite Corporation, Health and Regulatory Affairs - Europe, Tallaght Business Park, Whitestown, Dublin 24, Ireland. Tel: +353-1-4046444. Fax: +353-1-4510806. The information in this safety data sheet was obtained from reputable sources and to the best of our knowledge is accurate and current at the mentioned date. Neither Loctite nor its subsidiary companies accept any liability arising out of the use of the information provided here or the use, application or processing of the product(s) described herein. Attention of users is drawn to the possible hazards from improper use of the product(s). MSDS_IE Page 4 of 4