APC308 Rail to Rail Output CMOS Operating Amplifier Features Applications • • • • Operating Voltage Single Supply • • • • • • • 3V to 6V Low Input current 2pA Amplifiers Filters Analog circuit Rail to Rail Output Swing Push-Pull Output Driving High Output Current Drive Gereral Description 310mA The APC308 consists of two independent, high gain, CMOS operating amplifier, combining rail to rail output range with large output current. It provides a low input bias current 2pA. The output swing of the amplifier, guaranteed for loads down to 1kΩ and output current to an 10Ω load from a 5V power supply. APC308 designed to operating at 3V is especially well-suited for low voltage application. Bandwidth:7MHz Wide Temperature Range Available in 8 pin SOP ,DIP , TSSOP or MSOP Package Ordering Information )2+!& Package Code J : PDIP - 8 O : TSSO P - 8 Tem p. Range I : - 40 to 85 ° C Handling Code TU : Tube Handling Code Temp. Range Package Code K : SO P - 8 X : M SO P-8 TR : Tape & Reel Block Diagram O ut 1 Inverting Input 1 - + & V ,, % O ut 2 + - N on-inv erting Input 1 ! $ Inverting Input 2 V -- " # N on-inv erting Input 2 APC308 ANPEC reserves the right to make changes to improve reliability or manufacturability without notice, and advise customers to obtain the latest version of relevant information to verify before placing orders. Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 1 www.anpec.com.tw APC308 Absolute Maximum Ratings Symbol VDD TSC(O) TA TJ TSTG TS VESD Parameter Supply Voltage Output Short-circuit duration, at TA=25°C, PTOT=1W Operating Ambient Temperature range Maximum Junction Temperature Storage Temperature Range Soldering Temperature, 10 seconds Electrostatic Discharge Rating 7 20 -40 to 85 150 -65 to +150 260 -3000 to 3000*1 Unit V S °C °C °C °C V Note : *1. Human body model : C=100pF , R=1500Ω , 3 positive pulses plus 3 negative pulses Thermal Characteristics Symbol Parameter Value Unit RTHJA Thermal Resistance from Junction to Ambient in Free Air DIP-8 109 K/W SO-8 180 K/W TSSOP 220 K/W MSOP 220 K/W Electrical Characteristics VDD=5V , TA=25°C (unless otherwise noted) Symbol Parameter Condition Ta=25°C -25°C<Ta<75°C Vos Input Offset Voltage Ibias Input Bias Current Ta=25°C Vicm Input Common Mode Voltage Range Ta=25°C RIN Input Resistance Vo Output Voltage Swing Voh Output Voltage High Vol Output Voltage Low Output Current Source Output Current Sink CMRR Common Mode Rejection Ratio lout Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 Min. Typ. 4 5 Max. 10 2 0 pA VDD-0.8 5 0 RL=2kΩ RL=10kΩ, -25°C<Ta<75°C RL=10kΩ, -25°C<Ta<75°C Vo=4.5V Vo=0.5V 2 Unit mV mV V MΩ 5 V 5 V 0 V -310 370 -80 mA mA dB www.anpec.com.tw APC308 Electrical Characteristics Cont. VDD=5V , TA=25°C (unless otherwise noted) Symbol Parameter PSRR Supply Voltage Rejection Ratio Av GBW SR Icc Condition Vrr=100mVpp, fin=100HZ,RL=2kΩ Large Signal Voltage Gain Gain Bandwidth Product Slew Rate Supply Current Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 -25°C<Ta<75°C 2.4V<Vcc<6V, Ta=25°C 3 Min. Typ. Max. Unit -50 dB 85 7 5.6 2.0 dB MHz 4 V/µs mA 2.5 5 mA www.anpec.com.tw APC308 Typical Characteristics Supply Current vs Supply Voltage Supply Current vs Temperature VDD=5V 4 2 .0 3 .5 1 .8 Supply Current (mA) Supply Current (mA) No Load 3 2 .5 2 1 .5 1 0 .5 1 .6 1 .4 1 .2 1 .0 0 .8 0 .6 0 .4 0 .2 0 .0 0 0 1 2 3 4 5 6 -2 5 7 0 25 50 75 Temperature(°C) Supply voltage(V) Input Common Mode Voltage vs Supply Voltage Input Offset Voltage vs Temperature VDD=5V 7 6 6 5 VICM (V) VOS (mV) 5 4 3 4 3 2 2 1 1 0 0 -2 5 0 25 50 0 75 Temperature(°C) Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 1 2 3 4 5 6 7 Supply Voltage(V) 4 www.anpec.com.tw APC308 Typical Characteristics Output Swing vs Temperature Output Swing vs Supply Voltage RL=2kΩ VDD=5V, RL=2kΩ 8 6 7 5 Output Swing (V) Output Swing (V) 6 5 4 3 4 3 2 2 1 1 0 0 0 1 2 3 4 5 6 7 -2 5 Supply Voltage (V) 25 50 75 Temperature(°C) Output Current vs Output Swing Output Swing vs Load Resistance VDD=5V VDD=5V 1000 6 5 Output Swing (V) Output Swing (mA) 0 100 10 4 3 2 1 1 0 0 .1 0 1 2 3 4 5 10 6 Output Swing (V) Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 100 1k 10k Load Resistance (Ω) 5 www.anpec.com.tw APC308 Typical Characteristics Sink Current vs Output Voltage Source Current vs Output Voltage VDD=5V 500 500 450 450 400 400 Source Current (mA) Sink Current (mA) VDD=5V 350 300 250 200 150 100 350 300 250 200 150 100 50 50 0 0 0 .1 0 .2 0 .3 0 .4 0 .5 0 .6 0 .7 0 .8 0 .9 0 1 0 .1 0 .2 0 .3 0 .4 0 .5 0 .6 0 .7 0 .8 0 .9 1 Output Voltage Referred to Vdd(V) Output Voltage Referred to Ground (V) Large Signal Frequency Response Large Signal Voltage Gain vs Frequency VDD=5V VDD=5V, RL=2kΩ 6 +100 +90 5 Output Swing (V) +80 +70 Av (dB) 0 +60 +50 +40 +30 4 3 2 1 +20 +10 +0 10 100 1k 10k 100k 1M 0 10 10M 1k 10k 100k 1M 10M Frequency (Hz) Frequency (Hz) Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 100 6 www.anpec.com.tw APC308 Typical Characteristics CMRR vs Frequency VDD=5V,RL=10kΩ 100 +0 95 -10 90 -20 85 -30 CMRR (dB) Av (dB) Large Signal Voltage Gain vs Supply Voltage 80 75 70 -40 -50 -60 65 -70 60 -80 55 -90 50 1 2 3 4 -10 0 5 Supply Voltage (V) 100 1k 10k 100k Frequency (Hz) Voltage Follower Pulse Response PSRR vs Frequency +0 9 5 -10 8 4 7 3 6 2 5 1 4 0 3 -1 2 -2 1 -3 -30 -40 -50 -60 -70 -80 10 100 1k 10k 0 100k ! " # -4 Time (µs) Frequency (Hz) Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 Input Voltage (V) VDD=5V,RL=2kΩ Output Voltage (V) VDD=5V VRR=100mVpp/100Hz -20 PSRR (dB) 10 7 www.anpec.com.tw APC308 Typical Characteristics Voltage Follower Pulse Response 0 .5 0 .2 0 .4 0 .1 0 .3 0 0 .2 -0 .1 0 .1 -0 .2 0 -0 .3 - 0- 0. 4.4 -0 .1 -0 .2 Input Voltage (V) Output Voltage (V) VDD=5V,CL=270pF 0 1 2 3 4 -0 .5 Time (µs) Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 8 www.anpec.com.tw APC308 Packaging Information PDIP-8 pin ( Reference JEDEC Registration MS-001) D E1 E 1 A2 A 1 E3 A1 L e2 e1 e3 Dim A A1 A2 D e1 e2 e3 Mi l l im et er s Mi n . 0. 3 8 2. 9 2 9. 0 2 Mi n . 3. 6 8 10 . 16 0. 0 15 0. 1 15 0. 3 55 0. 5 6 1. 7 8 0. 0 14 0. 0 45 2. 5 4BSC 0. 3 6 1. 1 4 6. 1 0 2. 9 2 0° Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 Ma x . 0. 2 10 0. 1 45 0. 4 00 0. 1 00 BS C 7. 6 2 BSC 8. 2 6 E E1 E3 L φ 1 Inc he s Ma x . 5. 3 3 0. 0 22 0. 0 70 0. 3 00 BSC 0. 3 25 7. 1 1 10 . 92 3. 8 1 15° 9 0. 2 40 0. 1 15 0° 0. 2 80 0. 4 30 0. 1 50 15 ° www.anpec.com.tw APC308 Packaging Information E e1 0.015X45 SOP-8 pin ( Reference JEDEC Registration MS-012) H e2 D A1 A 1 L 0.004max. Dim A Mi ll im et er s Mi n. 1. 3 5 Inc he s Ma x . 1. 7 5 Mi n. 0. 0 53 Ma x . 0. 0 69 A1 0. 1 0 0. 2 5 0. 0 04 0. 0 10 D 4. 8 0 5. 0 0 0. 1 89 0. 1 97 E 3. 8 0 4. 0 0 0. 1 50 0. 1 57 H 5. 8 0 6. 2 0 0. 2 28 0. 2 44 L 0. 4 0 1. 2 7 0. 0 16 0. 0 50 e1 0. 3 3 0. 5 1 0. 0 13 0. 0 20 e2 φ 1 1. 2 7BSC 0° Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 0. 5 0BSC 8° 10 0° 8° www.anpec.com.tw APC308 Packaging Information TSSOP e 8 7 2x E/2 E1 ( 2) E GAUGE PLANE S 1 2 e/2 0.25 D L A2 A b Dim A A1 A2 b D e E E1 L L1 R R1 S φ1 φ2 φ3 1 (L1) ( 3) A1 Min. 0.00 0.80 0.19 2.9 4.30 0.45 Millimeters 0.65 BSC 6.40 BSC 0.09 0.09 0.2 0° Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 1.0 REF 12° REF 12° REF Max. 1.2 0.15 1.05 0.30 3.1 0.000 0.031 0.007 0.114 4.50 0.75 0.169 0.018 8° 0.004 0.004 0.008 0° 11 Min. Inches 0.026 BSC 0.252 BSC 0.039REF 12° REF 12° REF Max. 0.047 0.006 0.041 0.012 0.122 0.177 0.030 8° www.anpec.com.tw APC308 Packaging Information MSOP e1 E E1 e1 L1 A1 Dim A1 A2 A3 e e1 E E1 L1 L2 A3 Min. 0.06 0.25 2.90 4.8 2.90 Millimeters 0.86 TYP 0.65 TYP 0.25 REF 0.0375 REF Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 A2 L2 Max. 0.15 Min. 0.002 0.4 0.01 3.1 5.0 3.1 0.114 0.189 0.169 12 Inches Max. 0.006 0.34 TYP 0.0256TYP 0.039REF 0.953 REF 0.0126 0.124 0.197 0.177 www.anpec.com.tw APC308 Physical Specifications Terminal Material Lead Solderability Packaging Solder-Plated Copper (Solder Material : 90/10 or 63/37 SnPb Meets EIA Specification RSI86-91, ANSI/J-STD-002 Category 3. 2500 devices per reel Reflow Condition (IR/Convection or VPR Reflow) temperature Reference JEDEC Standard J-STD-020A APRIL 1999 Peak temperature 183°C Pre-heat temperature Time Classification Reflow Profiles Convection or IR/ Convection Average ramp-up rate(183°C to Peak) 3°C/second max. 120 seconds max Preheat temperature 125 ± 25°C) 60 150 seconds Temperature maintained above 183°C 10 20 seconds Time within 5°C of actual peak temperature Peak temperature range 220 +5/-0°C or 235 +5/-0°C Ramp-down rate 6 °C /second max. 6 minutes max. Time 25°C to peak temperature VPR 10 °C /second max. 60 seconds 215-219°C or 235 +5/-0°C 10 °C /second max. Package Reflow Conditions pkg. thickness ≥ 2.5mm and all bgas Convection 220 +5/-0 °C VPR 215-219 °C IR/Convection 220 +5/-0 °C pkg. thickness < 2.5mm and pkg. volume ≥ 350 mm³ Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 13 pkg. thickness < 2.5mm and pkg. volume < 350mm³ Convection 235 +5/-0 °C VPR 235 +5/-0 °C IR/Convection 235 +5/-0 °C www.anpec.com.tw APC308 Reliability test program Test item SOLDERABILITY HOLT PCT TST ESD Latch-Up Method MIL-STD-883D-2003 MIL-STD-883D-1005.7 JESD-22-B, A102 MIL-STD-883D-1011.9 MIL-STD-883D-3015.7 JESD 78 Description 245°C , 5 SEC 1000 Hrs Bias @ 125 °C 168 Hrs, 100 % RH , 121°C -65°C ~ 150°C, 200 Cycles VHBM > 2KV, VMM > 200V 10ms , IJH > 100mA Carrier Tape & Reel Dimensions t Po E W D P P1 Bo F Ao Ko D1 T2 J C A B T1 Application A B SOP- 8 330 ± 1 62 ± 1.5 TSSOP- 8 330 ± 1 62 ± 1.5 Application F D C 12.75 +0.1 5 12.75 ±0.1 5 D1 J T1 2 + 0.5 12.4 + 0.2 2 + 0.5 12.4 + 0.2 Po P1 SOP- 8 5.5 ± 0.1 1.55 ± 0.1 1.5+0.25 4.0 ± 0.1 2.0 ± 0.1 TSSOP- 8 5.5 ± 0. 1.5 + 0.1 1.5 + 0.1 4.0 ± 0.1 2.0 ± 0.1 Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 14 T2 W P E 12 + 0.3 2 ± 0.2 8.0 ± 0.1 1.75 ± 0.1 - 0.1 12 + 0.3 2 ± 0.2 8.0 ± 0.1 1.75 ± 0.1 - 0.1 Ao Bo Ko t 0.3 6.4 ± 0.1 5.2 ± 0.1 2.1 ± 0.1 ±0.013 0.3 7.0 ± 0.1 3.6 ± 0.3 1.6 ± 0.1 ±0.013 (mm) www.anpec.com.tw APC308 Cover Tape Dimensions 12 9.3 Carrier Width Cover Tape Width (mm) Customer Service Anpec Electronics Corp. Head Office : 5F, No. 2 Li-Hsin Road, SBIP, Hsin-Chu, Taiwan, R.O.C. Tel : 886-3-5642000 Fax : 886-3-5642050 Taipei Branch : 7F, No. 137, Lane 235, Pac Chiao Rd., Hsin Tien City, Taipei Hsien, Taiwan, R. O. C. Tel : 886-2-89191368 Fax : 886-2-89191369 Copyright ANPEC Electronics Corp. Rev. A.1 - Oct., 2001 15 www.anpec.com.tw