RoHS BRIDGE RECTIFIER KBPC25005(W) Thru KBPC2510(W) 25.0 Amps METAL 1.13(28.8) 1.11(28.2) .488(12.4) .409(10.4) FEATURES • UL Recognized • Current 25 Amps • Voltage Range 50V ~ 1000V • Glass passivated chip junction • High surge forward current capability • KBPC available in 15A, 25A, 35A, 50A • Electrically isolated metal case for .751(19.1) .673(17.1) 1.134(28.8) 1.110(28.2) Hole for No.10 Screw .193"（4.9）diam. 1.13(28.8) Hole for 1.11(28.2) No.10 Screw .681(17.3) .193"（4.9）diam. .602(15.3) 1.134(28.8) 1.110(28.2) .681(17.3) .602(15.3) .751(19.1) .673(17.1) .751(19.1) .673(17.1) .598(15.2) .519(13.2) .087(2.4) DIA .102(2.6) .033(0.85) .029(0.75) .251(6.4) .244(6.2) 1.200 (30.5)MIN. maximum heat dissipation .846 (21.5)MIN. .441(11.2) .425(10.8) .441(11.2) .425(10.8) MECHANICAL DATA Suffix W (For Wire Leads) • Mounted in the bridge encapsulation • Mounting through hole for No. 10 screw • Mounting Torque: recommend 5Kg • cm • Polarity: As marked No Suffix (For 0.25” Terminals) Dimensions in inches and millimeters MAXIMUM RATINGS & ELECTRICAL CHARACTERISTICS (TA = 25°C Unless otherwise noted) Symbol KBPC25 005 KBPC25 01 KBPC25 02 KBPC25 04 KBPC25 06 KBPC25 08 KBPC25 10 Unit Maximum Repetitive Peak Reverse Voltage VRRM 50 100 200 400 600 800 1000 V Maximum RMS Voltage VRMS 35 70 140 280 420 560 700 V Maximum DC Blocking Voltage VDC 50 100 200 400 600 800 1000 V Parameter Maximum Average Forward Rectified Current @ Tc = 55˚C (With Heat Sink) I O (AV) 25 A Peak Forward Surge Current 8.3ms single Half SineWave Superimposed on Rated Load (JEDEC Method) I FSM 400 A Forward Voltage (Per Element) @ IF = 7.5A VFM 1.1 V I t Rating for fusing ( t < 8.3ms) (Note 1) 2 I t 375 A S Dielectric Strength (AC 1 minute) Vdis 2.5 KV Maximum DC Reverse Current at rated DC Blocking Voltage I RRM 10 A Typical Thermal Resistance (Note 2) R 0JC 2.3 ˚C / W TJ -55 ~ +150 ˚C TSTG -55 ~ +150 ˚C 2 Operating Temperature Range Storage Temperature Range 2 Note: 1. Measured at non-repetitive, for greater than 1ms and less than 8.3ms. 2. Device mounted on 300mm x 300mm x 1.6mm Cu Plate Heatsink. Page 1 of 2 RFE International • Tel:(949) 833-1988 • Fax:(949) 833-1788 • E-Mail [email protected] ????? 2014.05.13 RoHS BRIDGE RECTIFIER KBPC25005(W) Thru KBPC2510(W) 25.0 Amps RATING & CHARACTERISTIC CURVES FIG.1-MAXIMUM CURRENT DERATING CURVE FIG.2-MAXIMUM NON-REPETITIVE FORWARD SURGE CURRENT 25 1 20 1 10 IFSM 400 PEAK FORWARD SURGE CURRENT (A) AVERAGE FORWARD CURRENT (A) 30 Sine Wave 8.3ms 8.3ms 1 cycle Non-Repetitive TA = 25°C 1 200 1 0 1 2 5 10 20 50 100 1 0 0 50 10 150 Case Temperature (V) NUMBER OF CYCLES AT 60Hz FIG.4-TYPICAL REVERSE CHARACTERISTICS 60 40 100 1 TJ = 125°C 20 INSTANTANEOUS REVERSE CURRENT (uA) INSTANTANEOUS FORWARD SURGE CURRENT (A) FIG.3-TYPICAL INSTANTANEOUS FORWARD CHARACTERISTICS TA = 25°C 10 1 5.0 1 1.0 1 0.5 10 1.0 0.1 TJ = 25°C 0.2 1 0.1 1 0.4 0.6 0.8 1.0 1.2 1.4 0.01 0 20 40 60 80 100 INSTANTANEOUS FORWARD VOLTAGE (V) PERCENT OF RATED PEAK REVERSE VOLTAGE (%) Page 1 of 2 RFE International • Tel:(949) 833-1988 • Fax:(949) 833-1788 • E-Mail [email protected] ????? 2014.05.13