BTCPower TM Broadband TelCom Power, Inc. Redefining “Current” Limits In Power Conversion 6C Series 25 ~ 30W DC-DC Converters Features • • • • • 25W Isolation Output 2:1 Input Range Six-Sided Shield Remote On/Off Control Efficiency To 85% Model Number 6C-01 6C-02 6C-03 6C-04 6C-05 6C-06 6C-07 6C-08 6C-09 6C-11 6C-12 6C-13 6C-14 6C-15 6C-16 6C-17 6C-18 6C-19 6C-21 6C-22 6C-23 6C-24 6C-25 6C-26 6C-27 6C-28 6C-29 Input Voltage 9-18 VDC 18-36 VDC 36-72 VDC Output Voltage Output Current Input Current No Load Full Load % Efficiency Case 5 VDC 12 VDC 15 VDC ±5 VDC ±12 VDC ±15 VDC 5/±12 VDC 5/±15 VDC 3.3 VDC 5000 mA 2500 mA 2000 mA ±2500 mA ±1250 mA ±1000 mA 3500/±310 mA 3500/±250 mA 5000 mA 30 30 30 35 35 35 35 35 30 mA mA mA mA mA mA mA mA mA 2675 mA 3050 mA 3050 mA 2675 mA 3050 mA 3050 mA 2640 mA 2640 mA 1860 mA 78 82 82 78 82 82 79 79 74 C 5 VDC 12 VDC 15 VDC ±5 VDC ±12 VDC ±15 VDC 5/±12 VDC 5/±15 VDC 3.3 VDC 5000 mA 2500 mA 2000 mA ±2500 mA ±1250 mA ±1000 mA 3500/±310 mA 3500/±250 mA 5000 mA 30 mA 30 mA 30 mA 30 mA 30 mA 30 mA 30 mA 30 mA 30 mA 1336 mA 1525 mA 1525 mA 1336 mA 1470 mA 1470 mA 1320 mA 1320 mA 920 mA 79 82 82 79 85 85 80 80 75 C 5 VDC 12 VDC 15 VDC ±5 VDC ±12 VDC ±15 VDC 5/±12 VDC 5/±15 VDC 3.3 VDC 5000 mA 2500 mA 2000 mA ±2500 mA ±1250 mA ±1000 mA 3500/±310 mA 3500/±250 mA 5000mA 20 20 20 25 25 25 25 25 20 660 mA 765 mA 765 mA 660 mA 735 mA 735 mA 655 mA 655 mA 460 mA 79 82 82 79 85 85 80 80 75 C mA mA mA mA mA mA mA mA mA Note: Nominal Input Voltage 12, 24 or 48VDC Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 6C Rev2 16-1-04 6C Series BTCPower 25-30W DC-DC Converters TM Specifications Input Specifications: Input Voltage Range…………….……12V……...………………..9-18V 24V……………………..18-36V 48V…………………......36-72V Input Filter………………………………………… ……………..Pi Type Output Specifications: Voltage Accuracy Single output………………………..…………………….+/- 2.0 % max. Daul + output……………………………………………..+/- 2.0 % max. Daul - output……………………………………………..+/- 3.0 % max. Triple, 5V………………………………………………….+/- 2.0 % max. 12V/15V…………………………………………..………+/- 5.0 % max. Voltage Balance ( Dual )………………………………...+/- 1.0 % max. External trim Adj. Range……………………………..…………+/- 10% Transient Response Single 25% Step Load Change…………………………….<500ìsec. Dual FL. 1/2L+/-1% Error Band…………………………….<500ìsec. Ripple & Noise, 20 MHz BW…………………….… 10mV RMS max. 75 mV p-p max. Temperature Coeffcient………………………… +/- 0.02 % / ºC max. Short Circuit Protection………………………………..……Continuous Line Regulation ¹ Single / Dual Output………….……..+/- 0.5 % max. Triple………………………….………..+/- 1.0% max. Load Regulation ² Single / Dual Output…………….….+/- 1.0 % max. Triple………………………..…………+/- 5.0 % max. General Specifications : Efficiency………………………………………………..……..see table Isolation Resistance…………………………………………..100Mohm Switching Frequency……………………………………..300 KHz, min. Case Grounding……………………………Capacity coupled to input Operating Temperature Range…………………………-25ºC ~ +71ºC Case Temperature………………………………………….100 ºC max. Cooling……………………………………………….Free air convection Storage Temperature Range……………………..…..-40 ºC ~ +100ºC Isolation Voltage………………………….………………..500VDC min. EMI/RFI…………………………………….....Six-sided continus shield Dimensions……………….……2” x 2” x 0.4 “(50.8 x 50.8 x 10.2 mm) Case Material……..Black Coated Copper with Non-conducted base Note: 1. 2. Measured from high lin to low line Measured from full load to ¼ load Triple output loading table Ouput (pin no.) 7 8&5 8&5 Voltage (V) 5 +12 or -12 +15 or -15 Amperes Min. (2) Nom. 0.5 3.5 0.1 0.31 0.1 0.25 Note: 1. Maximum total power from all outputs is limited to 25W but no output should be allowed to exceed its maximum current 2. Minmum current on each output is required to maintain specified regulation Outline Information and Pin-out Pin Connection Pin 1 2 3 4 5 6 7 8 Single No pin -Vin +Vin Trim -Vout +Vout No pin Dual Triple Remote On/Off Control No pin No pin -Vin -Vin +Vin +Vin Trim -Aux.out -Vout Common Common +5Vout +Vout +Aux.out Output may optionally be externally trimmed (+/-10%) with a fixed resistor or an external trimpot as shown. Remote On/Off Control Logic compatibility CMOS or Open collector TTL Ec-0n >5.5 Vdc or open circuit Ec-Off <1.8 Vdc Shutdown Idle current 10mA Input resistance 100K ohms (Ein 0Vdc to 9Vdc) Control common referenced to Input minus External Output Trimming Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 6C Rev2 16-1-04 6C Series 25-30W DC-DC Converters BTCPower TM All dimentions in inches(mm) The information and specifications contained in this brief are believed to be accurate and reliable at the time of publication. Specifications are subject to change without notice. Refer to product specification sheet for performance characteristics and application guidelines. Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 6C Rev2 16-1-04