BTCPower TM Broadband TelCom Power, Inc. Redefining “Current” Limits In Power Conversion 5C Series 15W DC-DC Converters Features • • • • • 15W Isolation Output 4:1 Input Range Six-Sided Shield Remote On/Off Control Efficiency to 82% Model Number 5C-01 5C-02 5C-03 5C-04 5C-05 5C-06 5C-07 5C-08 5C-09 5C-11 5C-12 5C-13 5C-14 5C-15 5C-16 5C-17 5C-18 5C-19 Input Voltage Output Voltage Output Current Input Current No Load Full Load 9-36 VDC 5 VDC 12 VDC 15 VDC ±5 VDC ±12 VDC ±15 VDC 5/±12 VDC 5/±15 VDC 3.3 VDC 3000 mA 1250 mA 1000 mA ±1500 mA ±625 mA ±500 mA 1500/±310 mA 1500/±250 mA 3000 mA 15 15 15 20 20 20 20 20 15 mA mA mA mA mA mA mA mA mA 18-72 VDC 5 VDC 12 VDC 15 VDC ±5 VDC ±12 VDC ±15 VDC 5/±12 VDC 5/±15 VDC 3.3 VDC 3000 mA 1250 mA 1000 mA ±1500 mA ±625 mA ±500 mA 1500/±310 mA 1500/±250 mA 3000 mA 10 10 10 15 15 15 15 15 10 mA mA mA mA mA mA mA mA mA % Efficiency Case 810 mA 780 mA 780 mA 810 mA 780 mA 780 mA 780 mA 780 mA 545 mA 77 80 80 77 80 80 80 80 76 C 410 mA 390 mA 390 mA 400 mA 380 mA 380 mA 380 mA 380 mA 270 mA 77 80 80 79 82 82 82 82 76 C Note: Nominal Input Voltage 24 or 48VDC Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 5C Rev2 16-1-04 5C Series BTCPower 15W DC-DC Converters TM Specifications Input Specifications: Input Voltage Range…………….……24V……...………………..9-36V 48V……………………..18-72V Input Filter………………………………………………………..Pi Type Output Specifications: Voltage Accuracy Single output………………………..…………………….+/- 1.0 % max. Daul + output……………………………………………..+/- 1.0 % max. Daul - output………………………………… …………..+/- 3.0 % max. Triple, 5V………………………………………………….+/- 2.0 % max. 12V/15V…………………………………………..………+/- 3.0 % max. Voltage Balance ( Dual )………………………………...+/- 1.0 % max. Transient Response Single 25% Step Load Change…………………………….<500ìsec. Dual FL. 1/2L+/-1% Error Band…………………………….<500ìsec. Ripple & Noise, 20 MHz BW…………………….… 10mV RMS max. 75 mV p-p max. Temperature Coeffcient………………………… +/- 0.02 % / ºC max. Short Circuit Protection………………………………..……Continuous Line Regulation ¹ Single / Dual Output………….……..+/- 0.2 % max. Triple………………………….………..+/- 1.0% max. Load Regulation ² Single / Dual Output…………….….+/- 1.0 % max. Triple………………………..…………+/- 5.0 % max. General Specifications : Efficiency………………………………………………..……...see table Isolation Resistance…………………………………………..100Mohm Switching Frequency……………………………...….…..300 KHz, min. Case Grouding………………………………Capacity coupled to input Operating Temperature Range…………………………-25ºC ~ +71ºC Case Temperature………………………………………….100 ºC max. Cooling……………………………………………….free air convection Storage Temperature Range……………………..…..-40 ºC ~ +100ºC Isolation Voltage………………………….………………..500VDC min. EMI/RFI……………………………...……Six-Sided Continuous Shield Dimensions……………….……2” x 2” x 0.4 “(50.8 x 50.8 x 10.2 mm) Case Material……..Black Coated Copper with Non-conducted base Note: 1. Measured from high line to low line 2. measured from full load to ¼ load Triple output loading table Ouput (pin no.) 7 8&5 8&5 Voltage (V) 5 +12 or -12 +15 or -15 Amperes Min. (2) Nom. 0.25 1.5 0.1 0.31 0.1 0.25 Note: 1. Maximum total power from all outputs is limited to 15W but no output should be allowed to exceed its maximum current 2. Minmum current on each output is required to maintain specified regulation Outline Information and Pin-out Pin Connection Pin 1 2 3 4 5 6 7 8 Single No pin -Vin +Vin Trim -Vout +Vout No pin Dual Triple Remote On/Off Control No pin No pin -Vin -Vin +Vin +Vin Trim -Aux.out -Vout Common Common +5Vout +Vout +Aux.out Remote On/Off Control Logic compatibility CMOS or Open collector TTL Ec-0n >5.5 Vdc or open circuit Ec-Off <1.8 Vdc Shutdown Idle current 10mA Input resistance 100K ohms (Ein 0Vdc to 9Vdc) Control common Referenced to Input minus External Output Trimming Output may optionally be externally trimmed (+/-10%) with a fixed resistor or an external trimpot as shown. Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 5C Rev2 16-1-04 5C Series 15W DC-DC Converter BTCPower TM The information and specifications contained in this brief are believed to be accurate and reliable at the time of publication. Specifications are subject to change without notice. Refer to product specification sheet for performance characteristics and application guidelines. Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A. Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: [email protected] DS LP 5C Rev2 16-1-04