Frontier Electronics Corp. 667 E. COCHRAN STREET, SIMI VALLEY, CA 93065 TEL: (805) 522-9998 FAX: (805) 522-9989 E-mail: [email protected] Web: http://www.frontierusa.com 2A GLASS PASSIVATED ULTRA FAST RECOVERY RECTIFIER UF20-005G THRU UF20-10G FEATURES z PLASTIC PACKAGE HAS UNDERWRITERS LABORATORY FLAMMABILITY CLASSIFICATION 94V-0 z GLASS PASSIVATED CHIP JUNCTION z ULTRA FAST RECOVERY TIMES FOR HIGH EFFICIENCY z LOW FORWARD VOLTAGE, HIGH CURRENT CAPABILITY z LOW LEAKAGE z HIGH SURGE CAPABILITY z HIGH TEMPERATURE SOLDERING GUARANTEED: 260°C/0.375” (9.5mm) LEAD LENGTHS FOR 10 SECONDS AT 5 LBS. (2.3KG) TENSION MECHANICAL DATA z CASE: MOLDED PLASTIC, DO15, DIMENSIONS IN INCHES AND (MILLIMETERS) z TERMINALS: AXIAL LEADS SOLDERABLE PER MIL-STD- 202, METHOD 208 z POLARITY: COLOR BAND DENOTES CATHODE END z MOUNTING POSITION: ANY z WEIGHT: 0.4 GRAMS 1.0(25.4) MIN .034(0.9) .028(0.7) .300(7.6) .230(5.8) .140(3.6) .104(2.6) 1.0(25.4) MIN MAXIMUM RATINGS AND ELECTRICAL CHARACTERISTICS RATINGS AT 25°C AMBIENT TEMPERATURE UNLESS OTHERWISE SPECIFIED SINGLE PHASE, HALF WAVE, 60 HZ, RESISTIVE OR INDUCTIVE LOAD. FOR CAPACITIVE LOAD, DERATE CURRENT BY 20% UF20 UF20 UF20 UF20 UF20 UF20 UF20 UNITS RATINGS SYMBOL -005G -01G -02G -04G -06G -08G -10G MAXIMUM RECURRENT PEAK REVERSE VOLTAGE VRRM 50 100 200 400 600 800 1000 V MAXIMUM RMS VOLTAGE VRMS 35 70 140 280 420 560 700 V MAXIMUM DC BLOCKING VOLTAGE VDC 50 100 200 400 600 800 1000 V MAXIMUM AVERAGE FORWARD RECTIFIED CURRENT IO 2.0 A 0.375”(9.5mm) LEAD LENGTH AT TA=55°C PEAK FORWARD SURGE CURRENT, 8.3ms SINGLE HALF IFSM 60 A SINE-WAVE SUPERIMPOSED ON RATED LOAD TYPICAL JUNCTION CAPACITANCE (NOTE 1) CJ 30 20 PF TYPICAL THERMAL RESISTANCE (NOTE 2) 40 ℃/W R θjc STORAGE TEMPERATURE RANGE TSTG -55 TO + 150 ℃ OPERATING TEMPERATURE RANGE TOP -55 TO + 150 ℃ ELECTRICAL CHARACTERISTICS (AT TA =25°C UNLESS OTHERWISE NOTED) UF20 UF20 UF20 UF20 CHARACTERISTICS SYMBOL -005G -01G -02G -04G MAXIMUM FORWARD VOLTAGE AT IO DC VF 1.3 MAXIMUM DC REVERSE CURRENT AT TA=25°C IR 1 MAXIMUM DC REVERSE CURRENT AT TA=100°C IR 10 MAXIMUM REVERSE RECOVERY TIME (NOTE3) TRR 50 NOTES: 1. MEASURED AT 1 MHZ AND APPLIED REVERSE VOLTAGE 0F 4.0 VOLTS 2. BOTH LEADS ATTACHED TO HEAT SINK 20x20x1t(mm) COPPER PLATE AT LEAD LENGTH 5mm 3. REVERSE RECOVERY TEST CONDITIONS: IF=0.5A, IR=1.0A, IRR=0.25A UF20-005G THRU UF20-10G UF20 -06G UF20 -08G 1.7 75 UF20 -10G UNITS V μA μA nS Page: 1 RATINGS AND CHARACTERISTIC CURVE UF20-005G THRU UF20-10G FIG. 1-TEST CIRCUIT DIAGRAM AND REVERSE RECOVERY TIME CHARACTERISTIC 10Ω NO INDUCTIVE FIG. 2-TYPICAL FORWARD CURRENT DERATING CURVE Trr (-) 3.0 +0.5A AVERAGE FORWARD CURRENT (A) 50Ω NO INDUCTIVE D.U.T. (+) 25 Vdc (approx) (-) PULSE GENERATOR ( NOTE 2 ) 1Ω NON INDUCTIVE OSCILLOSCOPE ( NOTE 1 ) (+) 0 -0.25A 0 25 50 75 100 125 150 175 TJ=25oC .1 40 60 10 INSTANTANEOUS FORWARD CURRENT (A) INSTANTANEOUS REVERSE CURRENT (uA) TJ=80oC 20 AMBIENT TEMPERATURE (oC) FIG. 4-TYPICAL INSTANTANEOUS FORWARD CHARACTERISTICS TJ=125oC .01 0 0 SET TIME BASE FOR 10/20 ns/cm 100 1.0 1.0 1cm FIG. 3-TYPICAL REVERSE CHARACTERISTICS 10 2.0 -1.0A NOTE: 1. RISE TIME=7ns MAX. INPUT IMPEDANCE=1 MOhms 22PF 2. RISE TIME =10ns MAX. SOURCE IMPEDANCE=50 OHMS Single Phase Half Wave 60 Hz Resistive or Inductive Load 80 100 120 140 UF20-005G~02G 1.0 UF20-03G~04 0.1 UF20-08G~10G .01 UF20-06G .001 .2 .4 PERCENT OF RATED PEAK REVERSE VOLTAGE (%) .6 .8 1.0 1.2 1.4 1.6 1.8 2.0 INSTANTANEOUS FORWARD VOLTAGE (V) FIG. 5-MAXIMUM NON-REPETITIVE FORWARD SURGE CURRENT FIG. 6-TYPICAL JUNCTION CAPACITANCE 60 50 40 30 20 10 JUNCTION CAPACITANCE (pF) PEAK FORWARD SURGE CURRENT (A) 200 8.3 ms Single Half Sine Wave (JEDEC Method) TJ=25oC 100 UF20-005G~04G 40 20 10 UF20-06G~10G 6 4 2 0 0 1 2 4 6 10 20 40 60 NUMBER OF CYCLES AT 60HZ UF20-005G THRU UF20-10G 100 1 .1 .2 .4 1.0 2 4 10 20 40 100 REVERSE VOLTAGE (V) Page: 2