SD500 5 0 0 W S i n g l e O u t put DC-DC Converter series DC Input Active Surge Current Limiting Wide 4:1~2:1 DC Input Range Protections: Short circuit / Overload / Over voltage / Over Temperature/ Input Polarity(by fuse) 2000VAC I/O Isolation Forced Air Cooling by Built-In DC Fan with Fan Speed Control Function Output OK Signal Built-In Remote ON-OFF Control Built-In Remote Sense Function Model Number Output Volts Output Amps Min Load DC Volt Adjust Efficiency Over Voltage Protection 12 Volts(DC) 24 Volts(DC) 48 Volts(DC) 12 Volts(DC) 24 Volts(DC) 48 Volts(DC) 40 Amps 21 Amps 10.5 Amps 40 Amps 21 Amps 10.5 Amps 0~40Amps 0~21Amps 0~10.5Amps 0~40Amps 0~21Amps 0~10.5Amps 11~15Volt(DC) 23~30Volt(DC) 46~60Volt(DC) 11~15Volt(DC) 23~30Volt(DC) 46~60Volt(DC) 86% 88% 89% 87% 89% 90% 16~19Volts(DC) 30.8~35.2Volts(DC) 62~68Volts(DC) 16~19Volts(DC) 30.8~35.2Volts(DC) 62~68Volts(DC) SINGLE OUTPUT SD500L-12 SD500L-24 SD500L-48 SD500H-12 SD500H-24 SD500H-48 WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 SD500 5 0 0 W S i n g l e O u t put DC-DC Converter series INPUT SPECIFICATIONS GENERAL SPECIFICATIONS Input Voltage Range (Note 3) SD500L-xx: 19~72Volts(DC) SD500H-xx: 72~144Volts(DC) Inrush Current, typ: 60Amps (DC) Input Current FL, typ: SD500L-xx: 24.2Amps/ 19 Volts(DC) 24.8Amps/ 24 Volts(DC) 12Amps/ 48 Volts(DC) SD500H-xx: 8Amps/ 72 Volts(DC) 6Amps/ 96 Volts(DC) Input Current NL, typ: SD500L-xx: 0.2Amps/ 48 Volts(DC) SD500H-xx 0.1Amps/ 96 Volts(DC) Min Load See Selection Chart Safety Insulation Resistance EMI Remote Control Output OK Signal Efficiency Isolation EMS (Note 4) OUTPUT SPECIFICATIONS Voltage and Current See Selection Chart Line Regulation ±0.5% Load Regulation ±0.5% Voltage Tolerance (Note 2) ±1.0% Ripple/Noise (Note 1) 150mVpk-pk max. Setup, Rise Time 500ms, 50m @ FL Over Voltage Protection See Selection Chart Shut down o/p voltage, re-power Over Current Protection 105 ~ 125% rated output power Constant current limiting, shutdown o/p voltage, re-power Over Temperature 80°C±5°C TSW1 detect on heatsink of power transistor 80°C±5(L-48V,H-24V,H-48V), 85°C±5(L-24V) 90°C±5(L-12V), 95°C±5 (H-12V) TSW2 : detect on heatsink of o/p diode. Shutdown o/p voltage auto recov after cool down DC Volt Adjust See Selection Chart All specifications are typical at nominal input, full load, and 25°C unless otherwise noted WWW.ASTRODYNE.COM IEC60950-1 CB approved by TUV ≥ 100MΩ / 500Volts(DC) / 25°C / 70% RH Compliance to EN55022B (CISPR22B) Please refer to function manual Open collector signal low when PSU turns on, max. sink current : 10 mAmps See Selection Chart 2000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground Compliance to EN61000-4-2, 3, 4, 6, 8 ENV50204, light Industry Level, Criteria A ENVIRONMENTAL SPECIFICATIONS Oper. Temperature Relative Humidity Storage Temperature Temperature Coefficient MTBF Vibration -20°C to +60°C (See Derate Curve) 20~90% RH non cond -40°C to +85°C, 10~95% RH ±0.02% / °C (0-50°C) 196.3 KHrs min,MIL-HDBK-217F(25°C) 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size (Millimeters / Inches) Weight 215 x 115 x 50 / 8.46” x 4.53 ” x 1.97 ” 20.46 oz (580g) NOTE 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line regulation and load regulation. 3. Derating may be needed under low input voltages. Please check the derating curve for more details. 4. The Power Supply is considered a component which will be installed into final equipment, The final equipment must be re-confirmed that it still passes EMC directives Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 SD500 5 0 0 W S i n g l e O u t put DC-DC Converter Assignment series Assignment Hirose HRS DF11-6DS WWW.ASTRODYNE.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W S i n g l e O u t put DC-DC Converter WWW.ASTRODYNE.COM SD500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W S i n g l e O u t put DC-DC Converter WWW.ASTRODYNE.COM SD500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 5 0 0 W S i n g l e O u t put DC-DC Converter WWW.ASTRODYNE.COM SD500 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458