CORCOM Product Guide Compact RFI Filter with IEC Connectors EF Series EF8 UL Recognized CSA Certified VDE Approved* EF1F/EF1FC EF4 EF2F EF Series Specifications This rugged international series of RFI filters incorporates the special IEC power line connector. They are UL recognized, CSA certified, and VDE approved. Electrically the EF international series are general purpose filters effectively providing RFI control of line-toground noise. The design is compact and meets the very low leakage current requirements of VDE portable equipment as well as (120 Volt) UL544 non-patient medical equipment. Models with F suffix have .250” terminals on load side; EF4 and EF8 have wire leads. Model 10EF1FC additionally incorporates a separate ground-circuit inductor to isolate the equipment chassis from power line ground at RF frequencies. Rated voltage (max.): Minimum insertion loss in dB: Electrical Schematics EF & EF-F Models LOAD .21 mA .36 mA 2250 VDC 1450 VDC 50/60 Hz 250 VAC Line-to-ground in 50 ohm circuit Current Frequency-MHz Rating .15 .5 1 5 EF1F, EF2F 01A 03A 06A 10A 15A EF4, EF8 01A 03A 06A EF1FC 10A *15EF1F UL, CSA 15 Amps/250 VAC VDE 10 Amps/250 VAC LINE Maximum leakage current,each line-to-ground @ 120 VAC 60 Hz: @ 250 VAC 50 Hz: Hipot rating (one minute): line-to-ground line-to-line Operating frequency: 10 30 22 15 9 8 – 35 25 20 15 6 40 30 25 20 12 46 45 41 34 20 50 50 45 39 25 49 54 50 44 25 22 15 9 35 25 20 40 30 25 46 45 41 50 50 45 49 54 47 8 15 20 34 39 44 Line Cord EF1FC Model Line Cord No. GA400: 71/2 foot, 3-conductor line cord to mate with EF series. LINE LOAD Resistor location for reference only. 42 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com CORCOM Product Guide Compact RFI Filter with IEC Connectors (Continued) EF Series Case Dimensions EF1F & EF1FC A Part No. (max) C 1EF1F, 3EF1F 1EF2F, 3EF2F 1EF4, 3EF4 1EF8, 3EF8 2.20 55.9 1.55 39.4 1.55 39.4 1.55 39.4 2.20 6EF1F 55.9 1.55 6EF2F 39.4 1.55 6EF4 39.4 1.55 6EF8 39.4 10EF1F 2.62 66.5 10EF1FC 2.62 66.5 15EF1F* 2.62 66.5 B D A E EF2F C .65 Max. 16.5 D E A Typical dimensions: Terminals: .250 [6.35] (3) Slot: .07 x .16 [1.8 x 4.1] B Holes: .07 [1.8] Dia.(2) EF4 E A Blue Brown D Green/Yellow C F EF8 Green/Yellow 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 1.19 30.2 0.81 20.6 0.85 21.6 0.85 21.6 0.81 20.6 0.81 20.6 0.85 21.6 0.85 21.6 0.81 20.6 0.81 20.6 0.81 20.6 0.81 20.6 D ± .015 ± .38 E (max) F (ref) 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 1.98 50.3 — 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1.575 40.01 1EF1F 1EF2F 1EF4 1EF8 3EF1F 3EF2F 3EF4 3EF8 Line Cord No. Insulating Boot No. B D E C (max) — .295 7.5 .295 7.5 — — .295 7.5 .295 7.5 — — — Part Numbers F 06EF1F 06EF2F 06EF4 06EF8 10EF1F 10EF1FC 15EF1F* GA400 FA601 *15EF1F UL, CSA — 15 Amps/250 VAC VDE — 10 Amps/250 VAC F Brown B (max) RFI Power Line Filters Case Styles B Recommended Panel Cutouts Blue F .820 20.8 A 1.200 30.48 1.575 40.01 C Typical dimensions: Wire leads 4.0 [101.6] Min. 18 AWG .900 22.9 .140 Dia. (2) 3.56 .062 R 1.58 .140 Dia. (2) 3.56 1.200 30.48 1.575 40.01 .234 R 5.94 Front Mount Back Mount Tolerance ±.005 [0.13] Tolerance ±.005 [0.13] Mounting Holes: .132 [3.35] Dia.(2) Note 1: EF1F, EF1FC and EF8 allow front or back mounting. Note 2: EF2F and EF4 allow back mounting only. 43 Catalog 1654001 Revised 05-07 Dimensions are in inches and millimeters unless otherwise specified. Values in italics are metric equivalents. Dimensions are shown for reference purposes only. Specifications subject to change. USA Cust. Svc.: 1-800-468-2023 CORCOM Prods: 1-847-680-7400 Germany: 49-89-6089-0 www.corcom.com www.tycoelectronics.com