SP480 480W S i n g l e Ou t put w it h P FC Func t i on series Universal AC input Protections:Short circuit/Over load/Over voltage/Over temperature Built-in active PFC function, PF >0.95 Forced air cooling by built-in DC Fan High power density 5.18w/cubic inch Low profile:43mm thickness Built in remote ON-OFF control Built-in remote sense function Active AC surge current limiting Model Number Output Volts Output Amps OVP 3.3 Volts(DC) 5 Volts(DC) 12 Volts(DC) 15 Volts(DC) 24 Volts(DC) 48 Volts(DC) 85 Amps 85 Amps 40 Amps 32 Amps 20 Amps 10 Amps 3.8 ~ 4.45Volt(DC) 5.75 ~ 6.75Volt(DC) 13.8 ~ 16.2Volt(DC) 18 ~ 21Volt(DC) 28.8 ~ 33.6Volt(DC) 57.6~ 67.2Volt(DC) Min Load DC Volt Adjust OCP Efficiency SINGLE OUTPUT SP480-3.3 SP480-5 SP480-12 SP480-15 SP480-24 SP480-48 WWW.ASTRODYNETDI.COM 0~85Amps 0~85Amps 0~43Amps 0~35Amps 0~22Amps 0~11Amps 2.9~3.6Volt(DC) 4.5~5.5Volt(DC) 10~13.2Volt(DC 13.5~18Volt(DC) 22~27.6Volt(DC) 41~56Volt(DC) 87~103Amps 87~103Amps 45.15~58.05Amps 36.75~47.25Amps 23.1~29.7Amps 11.55~14.85Amps 73% 79% 85% 85% 87% 89% ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 SP480 480W S i n g l e Ou t put w it h P FC Func t i on INPUT SPECIFICATIONS Input Voltage Range (Note 5) Frequency Range Inrush Current, typ: (cold start) Input Current Leakage current Min Load Power Factor @ FL series GENERAL SPECIFICATIONS 90 ~ 264VAC 120~370 Volts(DC) 47-63 Hz 20Amps/115VAC; 40Amps 230VAC 6.5Amps @ 115VAC 3.5 Amps @ 230VAC < 2mAmps / 240VAC See Selection Chart PF > 0.95 / 230VAC > 0.98 / 115VAC OUTPUT SPECIFICATIONS Voltage and Current (Note3) See Selection Chart Line Regulation ±0.5%: 3.3;5Volts(DC) ±0.3%: 12;15Volts(DC) ±0.2%: 24;48Volts(DC) Load Regulation ±1.0%: 3;5Volts(DC) ±0.5%: 12~48Volts(DC) Voltage Tolerance (Note 2) ±2.0%: 3.3;5Volts(DC) ±1.5%: 12;15Volts(DC) ±1.0%: 24;48Volts(DC) Ripple/Noise (Note 1) 80mVpk-pk: 3.3;5Volts(DC) 120mVpk-pk: 12Volts(DC) 150mVpk-pk: 15;24Volts(DC) 240mVpk-pk: 48Volts(DC) Hold Up Time @ FL 18mS /230VAC 18mS /115VAC Setup, Rise Time @ FL 1000mS, 80mS /230VAC 2500mS, 80mS /115VAC Over Voltage Protection See Selection Chart Shut down o/p volt,re power Over Current Protection See Selection Chart Constant current limiting,auto recover Over Temperature (Note 3) 80°C TSW1: detect on heatsink of power transistor 90°C TSW2: detect on heatsink of power diode Shut down o/p voltage, auto recover DC Volt Adjust See Selection Chart Peak Load: 10min (Note 4 ) 10% max Safety Insulation Resistance EMI Harmonic Current Remote Control Efficiency Isolation EMS UL60950-1, TUV EN60950-1 Approved ≥ 100MΩ / 500Volts(DC) Compliance to EN55022B (CISPR22B) Compliance to EN61000-3-2,-3 RC+/RC-: 4~10Volts(DC) Power off 0 ~ 0.8Volts(DC) Power on See Selection Chart 3000VAC Input - Output 1500VAC Input - Ground Short Output - Ground Compliance to EN61000-4-2,3,4,5,6,8,11 ENV50204,EN61000-6-2(EN50082-2) light Industry Level, Criteria A ENVIRONMENTAL SPECIFICATIONS Oper. Temperature Storage Temperature Relative Humidity Temperature Coefficient MTBF Vibration -20°C to +60°C (See Derate Curve) -40°C to +85°C, 10~95% RH 20~90% RH non cond ±0.03% / °C (0-50°C) 120.5KHrs min,MIL-HDBK-217F(25°C) 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size Weight 278x127 x 43mm (10.94”x5 ”x1.69”) 59.97 oz (1700g) NOTE 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line regulation and load regulation. 3. TSW1: Detect on heatsink of power transistor. TSW2: Detect on heatsink of output diode. 4. 33% Duty cycle maximum within every 30 minute. Average output power should not exceed the rated POWER. 5. Derating may be needed under low input voltages. Please check the derating curve for more details. All specifications are typical at nominal input, full load, and 25°C unless otherwise noted WWW.ASTRODYNETDI.COM ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 480W S i n g l e Ou t put w it h P FC Func t i on WWW.ASTRODYNETDI.COM SP480 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 480W S i n g l e Ou t put w it h P FC Func t i on WWW.ASTRODYNETDI.COM SP480 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458