DATASHEET Rev. A PSPW360 SERIES 90~264VAC Input 360 Watts with 30CFM Forced Airflow Active PFC, Single Output AC/DC Switching Power Supplies Type U Type E Type F FEATURES ● Active PFC ● Single Output ● Remote Inhibit Function ● 5V / 1A Standby Output ● 12V / 1A Output for Fan ● 90~264Vac Input Voltage Range ● 360W with 30CFM Forced Airflow ● Current Sharing Option (Single Wire) ● Short Circuit, Over Load, and Over Voltage Protection ● UL60950-1, CB IEC60950-1, TUV EN60950-1 Safety Approvals ● 3 Mechanical Options Available: U-Chassis, Enclosed with Rear Side Fan, Enclosed with Top Fan DESCRIPTION The PSPW360 series of AC/DC switching power supplies offers 360 watts of output power with 30CFM forced airflow. All models have a single output, 90~264VAC full range input, and active PFC. These supplies also have UL60950-1, TUV EN60950-1, CB IEC60950-1, and CE safety approvals. All models are protected against short circuit, over load, and over voltage conditions. Models are available in U-Chassis (Type U), enclosed with rear side built-in fan (Type E), and enclosed with top built-in fan (Type F) designs. This series also has a current sharing option (suffix “D”). 04/27/2010 Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 Page 1 of 7 Rev. A PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply SPECIFICATIONS: PSPW360 Series All specifications are based on 25°C, Nominal Input Voltage, and Maximum Output Current unless otherwise noted. We reserve the right to change specifications based on technological advances. INPUT SPECIFICATIONS Input Voltage Range Input Frequency Input Current 90 ~ 264Vac (Full Range) 47 ~ 63Hz 4.5A max. at 115Vac < 30A peak at 115Vac cold start and 25°C < 80A peak at 230Vac cold start and 25°C > 0.9 at 115Vac/230Vac Inrush Current Power Factor OUTPUT SPECIFICATIONS Output Current Output Voltage Output Regulation (See Note 3) Output Power Ripple & Noise (20MHz BW) (See Note 4) Hold Up Time Temperature coefficient PROTECTION Short Circuit Protection Over Voltage Protection Over Load Protection See Table See Table 5% 360W max. with 30CFM forced air cooling ±1% 20ms typical at 115Vac input ±0.04%/°C Auto-recovery 110% to 130% above nominal output. Latching type, AC recycle 110% to 150% maximum rating. Auto-recovery GENERAL SPECIFICATIONS Efficiency 83% typical at 115Vac and full load 86% typical at 230Vac and full load Isolation Voltage Input to Output: 4242Vdc Input to Ground: 2121Vdc Output to Ground: 707Vdc Current Share Option (See Note 1) ENVIRONMENTAL SPECIFICATIONS Operating Temperature Humidity (non-condensing) MTBF PHYSICAL SPECIFICATIONS Single wire (add the suffix “D” to the part number) 0°C to +50°C ambient; each output derates at 2.5% per degree from +50°C to +70°C 5% to 95% >100,000 hours at full load and 25°C ambient temperature Dimensions (L x W x H) U Type: 8.00 x 4.66 x 1.51 inches (203.2 x 118.5 x 38.5 mm) E Type: 9.03 x 4.66 x 1.63 inches (229.4 x 118.5 x 41.5 mm) F Type: 8.00 x 4.66 x 2.85 inches (203.2 x 118.5 x 72.5 mm) Weight U Type: 40oz (1134g) E Type: 52.8oz (1497g) F Type: 52.8oz (1497g) SAFETY & EMI Safety Standards EMI Standards 04/27/2010 UL 60950-1, CSA-C22.2 NO.950-1, TUV EN60950-1, CB IEC60950-1 FCC Part 15 Class B, EN55022 Class B, CE Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 Page 2 of 7 PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply Rev. A MODEL SELECTION TABLE Model (1) Input Voltage Output Voltage Output Current (30CFM forced air) Maximum Output Power (2) (30CFM forced air) PSPW360B-1Y12-X (D) 90 ~ 264 VAC 12 VDC 30A 360W PSPW360B-1Y24-X (D) 90 ~ 264 VAC 24 VDC 15A 360W PSPW360B-1Y30-X (D) 90 ~ 264 VAC 30 VDC 12A 360W PSPW360B-1Y36-X (D) 90 ~ 264 VAC 36 VDC 10A 360W PSPW360B-1Y48-X (D) 90 ~ 264 VAC 48 VDC 7.5A 360W PSPW360B-1Y54-X (D) 90 ~ 264 VAC 54 VDC 6.67A 360W PSPW360B-1Y57-X (D) 90 ~ 264 VAC 57 VDC 6.32A 360W NOTES 1. Mechanical Options: The “x” in the part number can be “U” for U-chassis type, “E” for enclosed type with rear side built-in fan, or “F” for enclosed type with top side built-in fan. The “D” is for current sharing option. 2. U Type: 360W max. with 30CFM forced air at +50°C ambient temperature. E Type: 360W max. at +50°C ambient temperature. F Type: 360W max. at +50°C ambient temperature. 3. At 25°C including initial tolerance, line voltage, load currents, and output voltages adjusted to factory settings. 4. Ripple & Noise is measured at 20MHz bandwidth with a tantalum 10µF in parallel with a 0.1µF ceramic capacitor. 04/27/2010 Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 Page 3 of 7 PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply Rev. A MECHANICAL DRAWINGS Type “U” Models (U-Chassis Type): 8.00 x 4.66 x 1.51 inches Unit: inches (mm) 0.35 (8.9) 0.35 (8.9) 0.50 (12.7) 0.50 (12.7) 7.30 (185.4) 2.35 (59.75) 0.32 (8.25) 3.66 (93.1) CN4 1.05 (26.75) 0.32 (8.25) CN1 0.50 (12.7) 0.50 (12.7) 4-M3P0.5 0.35 (8.9) 0.35 (8.9) FAN FAULT FAN FULL SPEED CN7 P2.54-2*3P Molex P/N:90122-0123 or Equivalent 0.75 (19.0) 0.75 (19.0) 2-M3P0.5 7.30 (185.4) 0.35 (8.9) POWER GOOD GND GND 0.35 (8.9) 8.00 (203.2) 1.51 (38.35) CN3 1 CN5 CN2 FAN1 FAN2 N.C. Recommended direction for forced airflow REPLACE ONLY WITH SAME TYPE AND RATING OF FUSE +V CN1 RTN RTN G IN FG 04/27/2010 W AR N AC(L) FG 0.47 (12.0) AC(N) AC(L) CN4 0.75 (19.0) AC(N) +V RTN !! 8A/250V +V Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 Page 4 of 7 PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply Rev. A Type “E” Models (Enclosed with Rear Side Built-in Fan Type): 9.03 x 4.66 x 1.63 inches Unit: inches (mm) 7.30 (185.4) 0.35 (8.9) 0.5 (12.7) 2.35 (59.75) 0.32 (8.25) CN4 3.66 (93.1) 1.05 (26.75) 0.32 (8.25) CN1 4-M3P0.5 0.5 (12.7) 0.77 (19.5) 0.77 (19.5) 0.35 (8.9) 2-M3P0.5 0.35 (8.9) 7.30 (185.4) FAN FULL SPEED CN7 P2.54-2*3P Molex P/N:90122-0123 or Equivalent POWER GOOD GND 0.35 (8.9) GND 9.03 (229.4) CN2 CN3 1 CN5 1 FAN1 4.66 (118.5) N.C. +V +V +V CN1 RTN 8A/250V FG FG RTN RTN CN4 0.47 (12.0) L AC(L) Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 1 0.75 (19.0) N AC(N) RTN RTN RTN +V +V +V NC 1.63 (41.5) 04/27/2010 FAN FAULT Page 5 of 7 PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply Rev. A Type “F” Models (Enclosed with Top Side Built-in Fan Type): 8.00 x 4.66 x 2.85 inches Unit: inches (mm) 7.30 (185.4) 0.35 (8.9) 0.5 (12.7) 0.5 (12.7) 0.35 (8.9) 2.35 (59.75) 3.67 (93.1) 0.32 (8.25) CN4 1.05 (26.75) 0.32 (8.25) 4-M3P0.5 CN1 0.5 (12.7) 0.5 (12.7) 0.35 (8.9) 0.35 (8.9) 7.30 (185.4) 0.35 (8.9) 0.35 (8.9) FAN FAULT FAN FULL SPEED 0.75 (19.0) 0.75 (19.0) 2-M3P0.5 CN7 P2.54-2*3P Molex P/N:90122-0123 or Equivalent POWER GOOD GND 1.00 (25.5) 8.00 (203.2) CN3 1 CN5 1 +V +V CN1 RTN 8A/250V FG FG RTN RTN CN4 0.47 (12.0) L AC(L) 04/27/2010 Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 0.75 (19.0) N AC(N) +V +V +V 4.67 (118.5) N.C. NC FAN1 +V CN2 RTN RTN RTN 1.85 (47.0) GND Page 6 of 7 Rev. A PSPW360 Series Up to 360 Watts Active PFC, Single Output AC/DC Switching Power Supply COMPANY INFORMATION Wall Industries, Inc. has created custom and modified units for over 50 years. Our in-house research and development engineers will provide a solution that exceeds your performance requirements on-time and on budget. Our ISO9001-2008 certification is just one example of our commitment to producing a high quality, well-documented product for our customers. Our past projects demonstrate our commitment to you, our customer. Wall Industries, Inc. has a reputation for working closely with its customers to ensure each solution meets or exceeds form, fit and function requirements. We will continue to provide ongoing support for your project above and beyond the design and production phases. Give us a call today to discuss your future projects. Contact Wall Industries for further information: Phone: Toll Free: Fax: E-mail: Web: Address: 04/27/2010 (603)778-2300 (888)587-9255 (603)778-9797 [email protected] www.wallindustries.com 5 Watson Brook Rd. Exeter, NH 03833 Wall Industries, Inc. 5 Watson Brook Road Exeter, NH 03833 603-778-2300 www.wallindustries.com Fax 603-778-9797 Page 7 of 7