3W DC-DC Converter P3J-Series ● ● ● ● ● ● 7 Pin SIL Low ripple and noise Up to 3000 VDC isolation MTBF > 1.8 Mhours -40...85°C operating temperature range High efficiency Model selection guide Typ Input nominal voltage [VDC] Input current no-load [mA] Single output P3J0505S 4.5..5.5 P3J0509S 4.5..5.5 P3J0512S 4.5..5.5 P3J0515S 4.5..5.5 P3J1205S 10.8..13.2 P3J1209S 10.8..13.2 P3J1212S 10.8..13.2 P3J1215S 10.8..13.2 Dual output P3J0505D 4.5..5.5 P3J0509D 4.5..5.5 P3J0512D 4.5..5.5 P3J0515D 4.5..5.5 P3J1205D 10.8..13.2 P3J1209D 10.8..13.2 P3J1212D 10.8..13.2 P3J1215D 10.8..13.2 Suffix: “H” for 3kV isolation voltage Input current full-load [mA] Output voltage Output current Efficiency typ. [VDC] [mA] [%] Capacitive load [µF] 80 80 80 80 20 20 20 20 730 730 725 725 295 295 274 274 5.0 9.0 12.0 15.0 5.0 9.0 12.0 15.0 600 333 250 200 600 333 250 200 80 81 82 84 84 86 89 90 220 220 100 100 220 220 100 100 70 70 70 70 20 20 20 20 730 730 700 700 300 300 275 275 ±5.0 ±9.0 ±12.0 ±15.0 ±5.0 ±9.0 ±12.0 ±15.0 ±300 ±167 ±125 ±100 ±300 ±167 ±125 ±100 82 83 84 86 85 86 89 90 2 x 100 2 x 100 2 x 47 2 x 47 2 x 100 2 x 100 2 x 47 2 x 47 Page 1 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 3W DC-DC Converter P3J-Series Specifications Input Voltage range Filter I/O-Isolation: DC-Isolation voltage tested for 3 sec. Resistance Capacitance Output Voltage accuracy Ripple and noise (at 20 MHz BW) Line voltage regulation @ 1% Vin change Temperature coefficient Short circuit protection Voltage stability at load change 10...100% EMC EME ESD RS ± 10 % Capacitors 1 kV, 3 kV 9 10 Ω, max. 60 pF, typ. ± 3 %, max. 50 mVp-p, max. ± 1.2 % 0.02 % / °C Momentary ± 10 % ± 20 % @ 3.3 V output EN 55022 Class A IEC 61000-4-2 / A IEC 61000-4-3 / A General Safety standard Switching frequency Environmental Operating temperature (ambient) Case temperature Storage temperature Derating Humidity Cooling Physical Dimensions Weight Case material Capacitive Load: Single Output Dual Output Pin soldering temperature 1.5mm distance from body IEC 60950-2001 ~ 70 kHz -40 °C to +85 °C 100 °C, max. -40 °C to +125 °C None required Up to 95%, non-condensing Free-air convection SIL 19.50 x 6.00 x 9.50 mm 2.8 g non-conductive black plastic (UL94V-0 rated) 220 µF, max. 100 µF, max. 260°C for 10sec Output voltage at load change Page 2 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected] 3W DC-DC Converter P3J-Series L1 18µH Coiltronics SD3118-180R + Vin + Vout max. C-Load see table 2.2µF CerChip X7R - Vin - Vout 1. Ripple & Noise measured with a 1uF ceramic capacitor on output. 2. Tested by minimal Vin and constant resistive full load. 3. Exceeding the absolute ratings of the unit could cause damage. It is not allowed for continuous operating. 4. Operation under no-load conditions will not damage these devices, however they may not meet all listed specifications. 5. Input filter components (2.2µF and 18µH) are used to help meet conducted emissions requirement for the module. These components should be mounted as close as possible to the module; and all leads should be minimized to decrease radiated noise. Dimensions 6.0 19.5 PHI-CON 9.5 1 2 4 5 6 7 3.05 0.5 2.54 15.2 0.5 0.25 1.25 0.5 All dimensions in mm Tolerances: Case ±0.5 Pin pitch ± 0.35 Pin diameter ±0.05 Life Support Policy: HY-LINE does not authorize the use of any of its products for use in life support devices or systems without the express written approval of an officer of the Company. Life support systems are devices which support or sustain life, and whose failure to perform, when properly used in accordance with instructions for use provided in the labeling, can be reasonably expected to result in significant injury to the user. Rev: 03.11 f Pin connections Pin 1 2 4 5 6 7 Standard Single Dual +V Input +V Input -V Input -V Input -V Output -V Output Omitted Common +V Output +V Output Omitted Omitted 3 kVDC Isolation Single Dual +V Input +V Input -V Input -V Input Omitted Omitted -V Output -V Output Omitted Common +V Output +V Output Page 3 of 3 Deutschland: Inselkammerstraße 10 D-82008 Unterhaching Tel.: 089 614 503-10 E-Mail: [email protected] Schweiz: Gründenstrasse 82 CH-8247 Flurlingen Tel.: 052 647 42 00 E-Mail: [email protected]