G2T60 MEDICAL SERIES SINGLE OUTPUT POWER SUPPLY SUMMARY Low Power Medical Power Supplies 60 Watt AC/DC Universal Input Power Supply • 100 - 240 Vac nominal input range • Overvoltage and short circuit protection • Approved to UL, CSA and EN Standards • Class I input available (GNT60) The G2T60 Series is a 60 W universal input AC/DC power supply in a very small footprint. With the medical approvals the G2T60 is ideal for a variety of medical device applications including, small single board computers, battery charging, and running small motors, pumps, and solenoids. The series with full approval to EN60601-1 and EN60950-1 Standard, improves design-in time and reduces end system compliance costs. SPECIFICATIONS All specifications are typical at nominal input, full load at 25 OC unless otherwise stated OUPUT SPECIFICATIONS Output Power INPUT SPECIFICATIONS Natural Convection Total Regulation 60 Watts max.(65 W with airflow) See table Input Voltage range Universal input 100-240 nom (85 - 264 max) Vac Rise time At turn-on 2.0 s max. Input frequency Transient response Main output 50% 0.2 A/ms 5% max. dev. 1 ms recovery to 1% Input surge current Thermistor limited 37 A max. Ground Leakage current 132 Vac 60 Hz 100 mA Input to groundedoutput Input current 120 Vac 1.2 A 230 Vac 0.7 A F1,F2 3.15 A Temperature Coefficient +/-0.03%/oC Overvoltage protection Short Circuit protection 125% +/-10% Power cycling Yes Input fuse 55 Hz +/- 10 Hz ENVIRONMENTAL SPECIFICATIONS EMC INFORMATION operating ambient (see ratings chart) 0-70 oC Complies non-operating -40 to +85 oC EN61000-3-3 Complies 60 Watts ESD EN61000-4-2 Contact 6 kV Air 8 kV 0 - 50 oC Convection cooled derate to 50% Radiated immunity EN61000-4-3 3 V/m 50 -70 oC ambient Convection cooled Fast Transients (EFT) EN61000-4-4 2 kV Relative Humidity non-condensing 5% - 95% RH Line surge immunity EN61000-4-5 DIfferential 1 kV Common 2 kV Maximum Altitude operating / non-operating 10,000 ft. / 40,000 ft. max. Conducted immunity EN61000-4-6 3 Vrms Vibration 5 Hz- 500 Hz 2.5 g rms Power freq. mag. field EN61000-4-8 3 A/m Shock per MIL-STD-810E 516.4 part IV Voltage dip immunity EN61000-4-11 95% dip, 0.5 cycle 60% dip, 5 cycles 30% dip, 25 cycles RF emissions EN55011 Conducted Class B Radiated Class A Line freq. harmonics EN61000-3-2 Voltage fluctuations Note: Voltage dip immunity at 100 V is done with a 20% load Thermal Performance GENERAL SPECIFICATIONS Hold-up time Efficiency isolation voltage 120 Vac, 60 Hz 120 Vac 60 W output input to ouput Switching frequency Safety Approvals fixed Maximum weight 16 ms at 60 Watts output >80 % 4000 Vac 1500 Vac 60 KHz, +/- 5 KHz UL/EN/IEC 60601-1 CSA22.2 No.601 UL/EN/IEC 60950-1 CSA22.2 No.60950-1 140 g (0.29 lbs) MODEL NUMBER 40oC Convection 50oC Convection 50oC Airflow RIPPLE REGULATION G2T60-12 G2T60-15 G2T60-24 12 V 5.0 A 15 V 4.35 A 24 V 2.7 A 120 mV 150 mV 240 mV 2% 2% 2% 12 V 4.2 A 15 V 4.0 A 24 V 2.1 A 12 V 3.35 A 15 V 3.7 A 24 V 1.9 A NOTES 1. Convection cooling rating is 40 Watts worst case (G2T60-12 @ 50oC) 2. When the input voltage is less than 90 Vac the operating temperature range is 0oC to 40oC. The ripple and regulation specs. may not be met. 3. Peak output rating is 70 Watts for 1 minute. 4. Noise 0.5% RMS, 1% Pk-Pk, 20 MHz Bandwidth, differential mode. Measured with scope probe directly across output terminals of the power supply. 5. Heatsink temperatures should not be allowed to exceed 90 oC 6. Installation data is online at www.condorpower.com MECHANICAL NOTES INPUT J1 AMP P/N 640445-2 TB1 PIN 1 AC LINE PIN 1 AC LINE PIN 2 AC NEUTRAL PIN 2 AC NEUTRAL OUTPUT J2 AMP P/N 640445-4 TB2 PIN 1 OUTPUT 1 PIN 1 COMMON PIN 2 OUTPUT 1 PIN 2 OUTPUT 1 PIN 3 COMMON PIN 4 COMMON MATING CONNECTOR (TYCO/AMP) INPUT HOUSING 640250-2 CONTACT 640706-1 OUTPUT HOUSING 640250-4 CONTACT 640706-1 Condor DC Power Supplies Inc. 2311 Statham Parkway, Oxnard CA, 93033, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 Email: [email protected] G2T60 Rev C 7/27/05. Data Sheet © 2005 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication. However, Condor accepts no responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.