Material Safety Data Sheet for Product Number 16060 - Stainless Steel Ball Texpen - Yellow - #0 Tip ITW Mark-Tex 565 Eagle Rock Ave Roseland, NJ 07068 Phone: (800) 222-0876 (973) 403-9890 Chemtrex: (800) 262-8200 www.dykem.com/msds Product Identification: PRODUCT NAME: CV Yellow OTHER NAMES: J1129 HMIS: HEALTH: 2 FLAMMABILITY: 3 REACTIVITY: 0 PERS PROTECTION: C Shipping Information: UN ID UN 1263 DOT SHIPPING NAME (CLASS): PAINT(3) Containers <1 Pint are ORM-D WHMIS (CANADA ONLY) B3 PACKING GROUP: II Hazardous Ingredient(s): Information on this Material Safety Data Sheets refers to inks or paints used in pens and markers; however, it applies to these inks or paints in bulk. The inks or paints are contained in capillary or valve reservoirs and will not spill or lead under normal conditions. INGREDIENT CAS REG. NUM % WEIGHT THRESHOLD LIMIT VALUE AROMATIC HYDROCARBON 64742-95-6 24 100 PPM/8 HRS PEL CLAY, SILICA 1332-58-7 21 15 mg/M3* TITANIUM DIOXIDE 13463-67-7 7 15 mg/ M3* HYDROCARBON RESIN 68240-01-7 19 10 mg/ M3* PIGMENT YELLOW 34 1344-37-2 9 .05 mg/ M3* HYDROCARBON RESIN 9003-55-8 16 10 PPM TLV* This product is in compliance with the EPA TSCA Inventory. Physical Data: BOILING POINT: LOW: 350oF (177oC) HIGH: 410oF SPECIFIC GRAVITY: >1.0 % VOLATILE BY VOLUME: ca.40 SOLUBILITY IN WATER: NIL APPEARANCE: Thick Liquid with Aromatic Odor (210oC) VISCOSITY: 3000-4000 CPS VAPOR DENSITY: 4.8 VOC: 3.02 +/- .2 VAPOR PRESSURE: 3 mm Hg @ 25oC EVAPORATION RATE: Slower than Ether Fire and Explosion Data: FLASH POINT: 112oF TCC LEL: 0.01 UEL: 0.07 EXTINGUISHING MEDIA: Foam, CO2, Dry Chemical, and Water Spray UNUSUAL HAZARDS: NA SPECIAL PROCEDURES: NNR Health Hazard Data: LISTED AS POSSILE CARCINOGEN NPT: YES IARC: YES OSHA: YES IF YES: Long Term Exposure to Lead Chromate May Cause Cancer See 29CFR 1910.1025 Sections G through J SYMPTOMS OF OVEREXPOSURE: Headache, Dizziness, Nausea, Anesthesia, Coughing, Eye, Throat, and Irritation EFFECTS OF OVEREXPOSURE: Slight to Severe Irritation to eyes and mucous membranes of nose and throat. Dermatitis. Affects central nervous PRIMARY ROUTES OF ENTRY: Ingestion, Dermal or Inhalation EMERGENCY FIRST AID: Inhalation; Seek fresh air. Give artificial respiration if not breathing. Skin contact; Wash with copious water. Ingestion; Reactivity Data: STABILITY: Stable HAZARDOUS POLYMERIZATION: WILL NOT OCCUR CONDITIONS TO AVOID: Heat, Open Flames, and Sparks INCOMPATABILITY: Do not mix with strong oxidants HAZARDOUS DECOMPOSITION: Carbon Monoxide, Carbon Dioxide, and unidentified organic combustion products Environmental Protection Procedures: SPILL RESPONSE: Remove all ignition sources, ventilate area, and use absorbent material to clean spill. DISPOSAL METHODS: Dispose of waste in accordance with local and federal regulations. PROTECTIVE GEAR: NNR ADDITIONAL MEASURES: Keep away from heat, fire, and strong oxidants. Store in cool place (room temperature). Use adequate ventilation. SPECIAL PRECAUTIONS: NA * Free dust, not bound in paint/ink matrix. NA = Not Applicable, NL = Not Listed, NNR = Not Normally Required, NE = Not Established REVISION: JC-10/99 ADDITIONAL INFORMATION: McMASTER-CARR CAT.#16105T43