TEMPIL°, INC. 2901 Hamilton Blvd. South Plainfield, NJ 07080 PHONE: 908-757-8300 MATERIAL SAFETY DATA SHEET MSDS NO: TS - 200°C DATE: June 10, 2000 EMERGENCY NO: 800-424-9300 FAX: 908-757-9273 SECTION 1 MATERIAL IDENTIFICATION PRODUCT NAME: TEMPILSTIK 200°C/392°F GENERIC NAME OR FAMILY: Temperature Indicating Product SHIPPING NAMES: DOT: Non-regulated HAZARDOUS COMPONENTS OF MIXTURE WEIGHT % Adipic Acid 3-5 95-97 Non-hazardous ingredients IATA: Non-regulated OSHA PEL ACGIH TLV (PPM) (PPM) N.E. N.E. CAS Number 124-04-9 SECTION 313 SUPPLIER NOTIFICATION This product contains the following toxic chemical (s) subject to the reporting requirements of section 313 of the Emergency Planning and Community Right-to-Know Act of 1986 and of CFR 372: Chemical Name Not applicable % CAS Number SECTION 2 PHYSICAL DATA SPECIFIC GRAVITY (H2O = 1): N.E. PERCENT VOLATILE BY VOLUME (%) : N.A. EVAPORATION RATE (N-Butyl Acetate = 1) : N.A. VOLATILE ORGANIC COMPOUNDS (VOC) : N.A. BOILING POINT (°F): N.E. VAPOR PRESSURE (mm Hg.) : N.E. VAPOR DENSITY (AIR =1): N.E. SOLUBILITY IN WATER: Negligible APPEARANCE AND ODOR: Crayon like solid stick SECTION 3 FIRE AND EXPLOSION HAZARD DATA FLASH POINT ( and Method): N.E. FLAMMABLE LIMITS LOWER N.E. UPPER N.E. ______________________________________________________________________________________________ _ EXTINGUISHING MEDIA: Water, CO2 , dry chemical, foam ______________________________________________________________________________________________ _ SPECIAL FIRE FIGHTING PROCEDURES: Wear self contained breathing apparatus and protective clothing. ______________________________________________________________________________________________ _ UNUSUAL FIRE AND EXPLOSION HAZARDS: None known ______________________________________________________________________________________________ _ SECTION 4 - REACTIVITY HAZARD DATA O:\MSDS’s\msdsform Page 1 of 3 CONDITIONS TO AVOID: Not applicable STABILITY: Stable Incompatibility (Materials to Avoid): Strong oxidizing agents or strong mineral acids. ______________________________________________________________________________________________ _ Hazardous Decomposition Products: Carbon monoxide, carbon dioxide HAZARDOUS POLYMERIZATION: Will not occur CONDITIONS TO AVOID: Not applicable SECTION 5 - CONTROL AND PROTECTIVE MEASURES Respiratory Protection (Specify Type): NIOSH approved respirator if ventilation is insufficient. ______________________________________________________________________________________________ _ Protective Gloves: Rubber gloves Eye Protection: Safety glasses ______________________________________________________________________________________________ _ VENTILATION TO Local Exhaust Mechanical(general): If local ventilation is insufficient. BE USED Other Protective Clothing & Equipment: Not normally required. Hygienic Work Practices: Wash hands thoroughly after using this product. SECTION 6 - HEALTH HAZARD DATA Inhalation Skin Absorption PRIMARY ROUTES OF ENTRY Acute: May cause eye, skin or respiratory tract irritation. HEALTH Chronic: Unknown HAZARDS Signs & Symptoms of Exposure: Skin irritation. Vapors may cause headache, dizziness, nausea Target Organ Information: Unknown EMERGENCY FIRST AID PROCEDURES - Seek medical assistance for further treatment, observation and support if necessary. Eye Contact: Flush eyes with water for 15 minutes. Skin Contact: Wash with soap and water. Inhalation: Remove to fresh air. If breathing is difficult, Ingestion: Obtain immediate medical attention. obtain medical attention. SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE Steps to be taken if Material Is Spilled or Released: Sweep up and place in bag for waste disposal. ______________________________________________________________________________________________ _ Waste Disposal Methods: Dispose of in accordance with all Federal, State and local laws. ______________________________________________________________________________________________ _ Precaution to be taken in Handling & Storage: Store in cool, dry area. Avoid skin contact. Avoid breathing vapors. ______________________________________________________________________________________________ _ Other Precautions and/or Special Hazards: Not applicable HMIS rating: 0= Minimal hazard O:\MSDS’s\msdsform 1= Slight hazard Page 2 of 3 2= Moderate hazard 3= Serious hazard 4= Severe hazard Health: 1 Flammability: 1 Reactivity: 0 This information contained herein is furnished without warranty of any kind. Employers should use this information only as a supplement to other information gathered by them and must make independent determinations of suitability and completeness of information from all sources to assure proper use of these materials and the safety and health of employees. O:\MSDS’s\msdsform Page 3 of 3