ECG Label and Adhesive Remover MATERIAL SAFETY DATA SHEET Finished Product Date-Issued: MSDS Ref. No: Date-Revised: Revision No: 01/20/2003 RX2600-6 01/20/2003 New MSDS ECG Label and Adhesive Remover 1. PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: ECG Label and Adhesive Remover PRODUCT DESCRIPTION: Label/Adhesive Remover PRODUCT CODE: RX2600-6 MANUFACTURER NTE Electronics, Inc. 44 Farrand St. Bloomfield, NJ 07003 24 HR. EMERGENCY TELEPHONE NUMBERS CHEMTREC (U.S.): (800) 424-9300 CANUTEC: (613) 996-6666 Emergency Phone: 1-888-748-1777 8:00 am - 5:00 pm CST Phone: 973-748-5089 2. COMPOSITION / INFORMATION ON INGREDIENTS Chemical Name Wt.% CAS# d-Limonene 30 - 50 5989-27-5 Mixed Aliphatic Hydrocarbons 70 - 85 64742-489 1-4 124-38-9 Carbon dioxide EEC LABEL SYMBOL AND CLASSIFICATION EEC Irritant - "Xi" 3. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW PHYSICAL APPEARANCE: Clear to amber, sticky resin. EINECS# ECG Label and Adhesive Remover POTENTIAL HEALTH EFFECTS EYES: Liquid contact can cause irritation, which may be severe. SKIN: Prolonged or repeated contact may cause skin irritation. INGESTION: Harmful if swallowed. INHALATION: Prolonged or excessive inhalation may cause respiratory tract irritation. SIGNS AND SYMPTOMS OF OVEREXPOSURE EYES: Contact may cause eye irritation. SKIN: May cause slight irritation. INGESTION: Not a likely route of exposure. 4. FIRST AID MEASURES EYES: Immediately flush eyes with plenty of water. Get medical attention, if irritation persists. SKIN: Wash with soap and water. Get medical attention if irritation develops or persists. INGESTION: Ingestion is unlikely because of the physical properties and is not expected to be hazardous. Do not induce vomiting unless instructed to do so by a physician. INHALATION: Remove to fresh air. 5. FIRE FIGHTING MEASURES FLAMMABLE LIMITS: 0.7% to 3.1% GENERAL HAZARD: Combustible Liquid. Can form explosive mixtures at temperatures at or above the flash point. HAZARDOUS COMBUSTION PRODUCTS: Smoke, fumes and oxides of carbon. 6. ACCIDENTAL RELEASE MEASURES SMALL SPILL: Avoid runoff into storm sewers and ditches which lead to waterways. LARGE SPILL: -Implement cleanup procedures. -If in public area, keep public away and advise authorities. -Recover by pumping (use an explosion proof or hand pump) or with a suitable absorbent. ENVIRONMENTAL PRECAUTIONS WATER SPILL: This material is a water pollutant and should be prevented from contaminating soil or from entering sewage and drainage systems and bodies of water. RELEASE NOTES: Spills and releases may have to be reported to Federal and/or local authorities. file:///N|/MSDS/8590wvwy.htm (2 of 6)1/13/2004 12:00:25 PM ECG Label and Adhesive Remover SPECIAL PROTECTIVE EQUIPMENT: Only personnel equipped with proper respiratory and skin/eye protection should be permitted in area. See Section 8 for details. 7. HANDLING AND STORAGE GENERAL PROCEDURES: Keep container closed when not in use. HANDLING: Avoid prolonged or repeated contact with skin. STORAGE: Keep away from sources of ignition. STORAGE TEMPERATURE: (120°F) maximum 8. EXPOSURE CONTROLS / PERSONAL PROTECTION EXPOSURE GUIDELINES: OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200) EXPOSURE LIMITS OSHA PEL ACGIH TLV ppm mg/m3 ppm mg/m3 d-Limonene TWA Mixed Aliphatic Hydrocarbons OSHA TABLE COMMENTS: 1. NL = Not Listed TWA 1900 Supplier OEL ppm mg/m 3 [1] PERSONAL PROTECTIVE EQUIPMENT EYES AND FACE: For normal conditions, wear safety glasses. Where there is reasonable probability of liquid contact, wear splash-proof goggles. SKIN: The glove(s) listed below may provide protection against permeation. Gloves of other chemically resistant materials may not provide adequate protection. Buna Butyl Natural Latex Neoprene Solvex Viton 9. PHYSICAL AND CHEMICAL PROPERTIES PHYSICAL STATE: Liquid ODOR: Strong, fruity odor. COLOR: Clear to Light yellow file:///N|/MSDS/8590wvwy.htm (3 of 6)1/13/2004 12:00:25 PM ECG Label and Adhesive Remover pH: Not Applicable PERCENT VOLATILE: 30 BOILING POINT: (325°F) to (332°F) SPECIFIC GRAVITY: 0.7630 to 0.7930 @ 25°C (VOC): 750 to 800 g/L (non-exempt VOC) 10. STABILITY AND REACTIVITY STABLE: YES HAZARDOUS POLYMERIZATION: NO STABILITY: Stable under normal conditions. HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Dioxide and carbon Monoxide may form when heated to decomposition. 11. TOXICOLOGICAL INFORMATION EYE EFFECTS: May be mildly irritating to eyes. 12. ECOLOGICAL INFORMATION ENVIRONMENTAL DATA: There is limited information available on the environmental fate and effects of this material. The primary environmental concern for release is the impact on aquatic and terrestrial species. Due care should be taken to avoid the accidental release of this material into the environment. 13. DISPOSAL CONSIDERATIONS DISPOSAL METHOD: Federal, State, and Local laws governing disposal of materials can differ. Ensure compliance with proper authorities before disposal. 14. TRANSPORT INFORMATION DOT (DEPARTMENT OF TRANSPORTATION) PROPER SHIPPING NAME: CONSUMER COMMODITY ORM-D TECHNICAL NAME: Terpene Hydrocarbons N.O.S. PRIMARY HAZARD CLASS/DIVISION: No classification AIR (ICAO/IATA) PROPER SHIPPING NAME: CONSUMER COMMODITY ID8000 PRIMARY HAZARD CLASS/DIVISION: 9 UN/NA NUMBER: ID8000 PACKING GROUP: NA file:///N|/MSDS/8590wvwy.htm (4 of 6)1/13/2004 12:00:25 PM ECG Label and Adhesive Remover VESSEL (IMO/IMDG) PROPER SHIPPING NAME: AEROSOLS IN LIMITED QUANTITIES OF CLASS 2 PRIMARY HAZARD CLASS/DIVISION: 2.2 UN/NA NUMBER: 1950 PACKING GROUP: NA 15. REGULATORY INFORMATION UNITED STATES TSCA (TOXIC SUBSTANCE CONTROL ACT) TSCA STATUS: All components of this product are either listed or exempt from listing in the TSCA inventory. CANADA DOMESTIC SUBSTANCE LIST (INVENTORY): All components of this product are listed on the Canadian DSL. EUROPEAN COMMUNITY EEC LABEL SYMBOL AND CLASSIFICATION EEC Irritant - "Xi" 16. OTHER INFORMATION APPROVED BY: Pierce A. Pillon TITLE: Chemist REVISION SUMMARY New MSDS NFPA CODES 2 1 0 DATA SOURCES: Code of Federal Regulations (CFR) The Sigma-Aldrich Library of Regulatory and Safety Data OSHA Hazard Communication Standard (29CFR1910.1200) Various Federal, State and Local Regulations file:///N|/MSDS/8590wvwy.htm (5 of 6)1/13/2004 12:00:25 PM ECG Label and Adhesive Remover MANUFACTURER DISCLAIMER: To the best of our knowledge, the information contained herein is accurate. However, neither Stratus, or any of its subsdiaries assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final determination of suitability of any material is the sole responsibility of the user. All materials my present unknown hazards and should by used wth caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards which exist. file:///N|/MSDS/8590wvwy.htm (6 of 6)1/13/2004 12:00:25 PM