PSP600 6 0 0 W w i t h P F C and Parallel Function series Universal AC Input Protections:Short Circuit/Over Load/Over Voltage/Over Temperature Built-In Active PFC Function Forced Air Cooling by Built-In DC Fan Current Sharing up to 2000W (3+1) With DC OK Signal Output Built-In Remote ON-OFF Control Built-In Remote Sense Function Fixed Switching Frequency at PFC: 88KHz PWM: 100KHZ Model Number Output Volts Output Amps 5 Volts(DC) 12 Volts(DC) 13.5 Volts(DC) 15 Volts(DC) 24 Volts(DC) 27 Volts(DC) 48 Volts(DC) 80 Amps 50 Amps 44.5 Amps 40 Amps 25 Amps 22.2 Amps 12.5 Amps OVP Min Load DC Volt Adjust Load Reg Efficiency SINGLE OUTPUT PSP600-5 PSP600-12 PSP600-13.5 PSP600-15 PSP600-24 PSP600-27 PSP600-48 WWW.ASTRODYNE.COM 5.75~6.75Volt(DC) 13.8~16.2Volt(DC) 15.5~18.2Volt(DC) 18~21Volt(DC) 27.6~32.4Volt(DC) 31~36.5Volt(DC) 57.6~67.2Volt(DC) 0~80Amps 0~50Amps 0~44.5Amps 0~40Amps 0~25Amps 0~22.2Amps 0~12.5Amps 4.75~5.5Volt(DC) 10~13.2Volt(DC) 12~15Volt(DC) 13.5~18Volt(DC) 20~26.4Volt(DC) 24~30Volt(DC) 41~56Volt(DC) ±1.0% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% ±0.5% 79% 84% 85% 85% 86% 86% 87% ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 PSP600 6 0 0 W w i t h P F C and Parallel Function INPUT SPECIFICATIONS Input Voltage Range (Note 3) Frequency Range Inrush Current, typ: (cold start) Input Current Leakage current Min Load Power Factor (typ.) @ FL 90 ~ 264VAC 124~370 Volts(DC) 47-63Hz 20Amps/115VAC; 40Amps/230VAC 6.8 Amps@115VAC 3.4 Amps@230VAC < 1.3mAmps / 240VAC See Selection Chart 0.95/230VAC; 0.99/100VAC OUTPUT SPECIFICATIONS Voltage and Current See Selection Chart Line Regulation ±0.5% Load Regulation See Selection Chart Voltage Tolerance (Note 2) ±2.0%: 5Volts(DC) ±1.0%: 12~48Volts(DC) Ripple/Noise (Note 1) 180mVpk-pk: 5Volts(DC) 240mVpk-pk: 12~27Volts(DC) 300mVpk-pk: 48Volts(DC) Hold Up Time @ FL 20mS Setup, Rise Time @ FL 1500mS, 50mS Over Voltage Protection See Selection Chart Shutdown o/p voltage, re-power Over Current Protection 105~135% rated output power Constant Current limiting, auto-recov Over Temperature Protection +5Volts(DC): 95°C(TSW1) detect on heatsink of power transitor; 95°C(TSW51) detect on heatsink of power diode +12~48Volts(DC): 85°C(TSW1) detect on heatsink of power transitor; 80°C(TSW51) detect on heatsink of power diode shutdown o/p voltage, re-power after cool down DC Voltage Adjust See Selection Chart GENERAL SPECIFICATIONS Safety Insulation Resistance EMI Harmonic Current Efficiency Isolation EMS Remote Control Pok Signal series Compliance to EN55022B(CISPR22B) Compliance to EN61000-3-2,-3 See Selection Chart 3000VAC Input - Output 1500VAC Input - Ground 500VAC Output - Ground Compliance to EN61000-4-2,3,4,5,6,8,11 ENV50204, light Industry Level, Criteria A RC+/RC-: Short=Power ON Open=Power Off PSU turn on: 3.3~5.6Volts(DC) PSU turn off: 0~1Volts(DC) ENVIRONMENTAL SPECIFICATIONS Oper. Temperature Storage Temperature Relative Humidity Temperature Coefficient MTBF Vibration -20°C to +60°C (See Derate Curve) -40°C to +85°C, 10~95% RH 20~90% RH, non cond ±0.03% / °C (0-50°C) 116.4KHrs min,MIL-HDBK-217F(25°C) 10~500Hz, 2G10min./1cycle, period for 60min. each along X, Y, Z axes PHYSICAL SPECIFICATIONS Size Weight 170 x 120 x 93 mm (6.69”x 4.72”x 3.66”) 67.02 oz (1900g) NOTE 1. Ripple & noise are measured at 20MHz of bandwidth by using a 12” twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 2. Tolerance : includes set up tolerance, line regulation and load regulation. 3. Derating may be needed under low input voltages. Please check the derating curve for more details. UL60950-1, TUV EN60950-1 Approved ≥100MΩ/500Volts(DC)/25°C/70%RH All specifications are typical at nominal input, full load, and 25°C unless otherwise noted WWW.ASTRODYNE.COM Astrodyne products are not authorized or warranteed for use as critical components in life support systems, equipment used in hazardous environments, nuclear controls systems, or other mission-critical applications. ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 6 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP600 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 6 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP600 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458 6 0 0 W w i t h P F C and Parallel Function WWW.ASTRODYNE.COM PSP600 series ASTRODYNE USA: 1-800-823-8082 ASTRODYNE PACIFIC: 886-2-26983458